2021 JEEP WRANGLER Engine Problems

CLUTCH PRESSURE PLATE DISINTERGRATED CAUSING VEHICLE TO CATCH FIRE AND BURN COMPLETELY TO THE GROUND.. WHEN CLUTCH PRESSURE PLATE FAILED, ENGINE SHUT OFF, LUCKILY I WAS ABLE TO COAST TO A STOP IN AN UNPOPULATED AREA... NO WARNING LAMPS CAME ON UNTIL THE CATASTROPHIC FAILURE, MESSAGE SIMPLY SAID "CLUTCH"...

The contact owns a 2021 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was unavailable. The contact stated while driving approximately 25 MPH, the vehicle stalled. The contact stated that the power steering and braking functionality were inoperable. The contact stated that the vehicle had stalled at an intersection. The contact attempted several times to restart the vehicle however, the vehicle failed to restart. The contact had the vehicle towed to an independent mechanic who diagnosed the vehicle and determined that the high-pressure fuel pump had failed and needed to be replaced. The mechanic informed the contact that the VIN was included in NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) and referred the contact to a dealer. The contact called the dealer and was informed that the fuel pump was on a national backorder....

Dates of problem may 18 and June 9 The Jeep has engine light on the throttle control light is on I was driving on a highway and the vehicle completely went into limp mode would not go above 33 mph and almost caused an accident since the Jeep went into limp mode brought it to dealership they said the fixed it then a 2weeks later it happens again this time with my son in the car going 60 mph it does same exact thing this vehicle is a safety hazard for me and now I’m afraid to drive it at all having to pay for towing and it’s a leased vehicle just dosnt make sense to me what’s the lemon law on this

While driving approximately 15 mph the engine cut out and the engine light came on. I was able to pull over and the engine would not start. My personal obd scanner states it is the high pressure fuel pump. I had to be towed by AAA from Moab UT to grand junction Colorado Jeep Chrysler dealership 5/25/2023

This recall is potentially life threatening. It has been months & the dealer is still saying there is no fix. I believe they are not giving it the proper attention because this recall affects only Diesel engines & there were not many diesel jeep models purchased compared to traditional gas engine jeeps. I own 2. Both are affected & I feel unsafe. Please see that they remedy this problem asap before an accident occurs due to this problem. Thank you

Car shut down in the middle of the highway at around 30 mph. While using the adaptive cruise control, i stepped on the gas to accelerate. The car then shut down and many warning lights came on. The car did not respond to restarting, shifting or anything. Screen just said charge fault error.

After picking up the jeep from the dealership (brand new), we drove to mass from NY. On the second day of ownership, we drove car to store. When i returned to the car to drive home, it would not start and just said charging error with many warning lights. Car had to be towed to the nearest jeep dealer. Car only had 200 miles on it.

The contact owns a 2021 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available. The contact stated that the manufacturer has yet to provide a solution.

1st Jeep recall. Data update completed. Next day engine light. 2 weeks for first appointment. 3 weeks to get next appointment. After recall next day engine light heater codes. PCM replaced. Vehicle went Totally dead. New 12volt battery. Still dead. Star Stellantis Technical Assistance Request #1 Technicians from Michigan came and reprogrammed vehicle. Star #2 engine light heater codes still. A new recall for heater pump out for Jeep 4xe. My Vin # not included. Took possession June or July 2021. Current 3450. Miles. Jeep 4xe Hybrid unlimited. Vehicle has been @ dealership since February 2023. Here it is May 2023. I've talked with customer care. Still no parts. Still no work on vehicle. Told by dealership it needs heater pump and a battery heater warmer. No charging issue ever with plug in. Recall was for Stalling. Getting the big run around. Vehicle sat in garage for about a month...

Same issue as the last time, and the time before that. Very dangerous, battery completely fails. The instrument meters are wrong and it shows that there is gas when there is really not any gas. Also more recently, we were driving on the highway in the express lane in the car just suddenly came to a stop. We could have died - luckily there was no one behind us. I managed to get the car over partially into the other lane so people could go around. The car had to be towed and I’m done paying for this.

Today this morning I parked, put the gear in park and all of a sudden the car ravaged up and jumped forward, causing me to go through a fence and stopped. I had my foot on the break the whole time.

The contact owns a 2021 Jeep Wrangler. The contact stated that on various occasions, the vehicle was intermittently stalling while driving from a stop signal. No warning lights were illuminated. The vehicle was taken to a local dealer, where it was diagnosed that the high-pressure fuel pump (HPFP) needed to be replaced; however, the part for the repair was on backorder. The vehicle was not repaired. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the failure. The approximate failure mileage was 15,000. VIN tool confirms parts not available.

My Jeep was brought to Carl Burger Jeep because the check engine light stays on all the time. The dealership performed several software updates. The Check Engine light still stays on and has been on every since. About two months now. It was discovered that there is a part required for the EV battery that is not available due to back order. The service dept. said it was safe to drive. How do they know that? There has been a case opened up and a person assigned to my case. Who knows what that means. All I know is I'm very uncomfortable driving around with the Check Engine light on 100% of the time, especially with the size of that battery sitting right in back of me. I was told by the service dept. that they do not have an ETA for the back-ordered part. Nor have I received any...

2021 Jeep Wrangler Unlimited 4xe has now lost total power twice and had extreme 'Death Wobble' issues. In 08/2021, at approx 1,400 miles, the vehicle lost all power and control on the highway while going speed limit at 70 mph. The screen reported issue with electronic stability control system. It was a dangerous situation trying to move to the side of the highway with no power nor power steering. Once on the side, multiple warning lights were on and vehicle would not start but control lights remained on. I called the dealership/service department of South Point Dodge and their recommendation was to disconnect the battery connection to reset. I was driving from Houston so I was desperate to get the car to start as my family was waiting outside of the car on the highway as well. I reconnected battery terminal and was able to restart the vehicle. At around...

The contact owns a 2021 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

On multiple occasions, i have gone to start my Jeep and not been able to turn it on. It will then lock in an "on" position where the engine will not run or shut off. Has had to be towed twice and Chrystler is not helping. I am not being told anything other than they do not know what is going on, but say it happens to a lot of these cars.

I was notified of recall ZB7 affecting my 2021 JEEP Wrangler 4xE by phone on February 3, 2023. During this call I made an appointment with JEEP for the issue to be fixed on February 24, 2023. On Wednesday, February 22, 2023, two days before my scheduled appointment, the engine of my Jeep failed ~6PM while I was driving on highway 495S near Merrimac, MA (mile 114.8). I was in the far left lane traveling at about 70 mph and lost all power steering, power brakes, everything. The engine completely lost power without warning. No messages, warning lights or other signs of any issue before a total loss of power. Thankfully, I was able to drift from the left lane, crossing 2 lanes of traffic on a busy highway, to reach the shoulder on the other side of the highway. I did this in the dark without without power brakes...

The vehicle shut down on its own while driving. All warning lights were displayed. Vehicle was unresponsive and caused a crash. Vehicle is at dealer. I filed a complaint with FCA.

My 2021 Jeep Wrangler 4xe died while driving down the road. Luckily I was able to coast to the side and cycle the engine off/on in order to regain power. This was the exact same issue that is described in NHTSA Campaign Number: 22V865000, however, this time (2/3/23) was after the ZB7 recall was completed. Even after the recall work was completed and Jeep told me the vehicle was safe to drive, it still failed in the exact same manner. The recall procedure did not work and this vehicle is not safe to drive. Additionally, during the period after the recall was completed and before it died again while driving, the battery range has decreased dramatically (less than 50% of what it was prior to the recall work).

The contact leased a 2021 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2021 Jeep Wrangler. The contact stated while driving 60-70 MPH, the vehicle began to shudder significantly. There was no warning light illuminated. The contact stated that as he temporarily released the accelerator pedal, the failure decreased. The contact was able to continue driving. The contact stated that the failure reoccurred several times while driving. The contact received recall notification of NHTSA Campaign Number: 22V865000 (Engine) and the vehicle was taken to the dealer for recall repair; however, the failure increased significantly after the recall repair. The contact stated that the vehicle would shudder violently while driving. The vehicle was taken back to the dealer. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 13,000.

The contact owns a 2021 Jeep Wrangler. The contact received notification of the NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while driving at various speed, there was a rattling sound coming from the hood of the vehicle. No warning light was illuminated. The vehicle was not diagnosed or repaired. The local dealer was notified of the recall notification and confirmed that the parts were not available for the recall repair. The manufacturer was not notified of the issue. Parts distributions disconnect.

The vehicle's engine will randomly shut off and not turn back on. It has been to dealerships over 10 times for the same issue. They all attribute it to the start/stop battery, but it happens even when that feature is turned off. The vehicle's engine will shut off while driving and you cannot shift it into park. The only warning is a check engine light and "service auto start/stop system". There is no warning before the vehicle does it, and I have broken down in intersections, highways, and other dangerous locations. The vehicle duplicated the issue on the dealers lot, but they claim " no codes, no repair".

The contact leased a 2021 Jeep Wrangler. The contact stated that while driving the engine, hot message was displayed. The contact looked underneath the hood but failed to determine the cause of the failure. The contact continued to drive but the vehicle lost power and she noticed smoke coming from the vehicle. The contact pulled over. While continuing to drive, the check engine warning light illuminated. The contact received notification of NHTSA Campaign Number: 22V865000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. Parts distribution disconnect. The failure mileage was approximately 12,000.

The contact owns a 2021 Jeep Wrangler. The contact stated that while driving at various speeds, the vehicle stalled with the output control and collision warning lights illuminated. The contact had taken the vehicle to the dealer on numerous occasions; however, the mechanic was unable to determine the cause of the failure. The manufacturer was not notified of the failure. The vehicle was not yet repaired. The failure mileage was 23,915.

The contact owns a 2021 Jeep Wrangler. The contact stated while driving 50 MPH, the vehicle was shaking. The vehicle was taken to the dealer; however, the dealer was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was 5,000.

The contact owns a 2021 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 22V767000 (Fuel System, Gasoline, Engine) however, the part to do the recall repair was not yet available. The contact stated that an oil pressure alert message was displayed on the instrument panel. The contact took the vehicle to the dealer where a diagnostic test was performed which determined that the oil pressure was low. The dealer linked the failure to the recall and confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 37,600. VIN tool confirms parts not available.

Engine shut off completely in August of 2021 and then again today (12/15/22). In both cases, there was no warning. Thankfully, in both cases, we were at low speeds and able to coast to the shoulder and restart the vehicle. After restart, the vehicle operated normally with no warning lights. This seems to be the exact issue as described in NHTSA Recall 22V-865.

The contact owns a 2021 Jeep Wrangler. The contact received notification of NHTSA Campaign Number: 22V865000 (Engine) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Driving at highway speeds in Idaho on a road-trip from California. Vehicle suddenly shuts down with warning lights saying to put in park. Very dangerous as there is little to no shoulder on this stretch of highway. Cars had to swerve around the vehicle as it rapidly lost speed. Check engine light is now on. No warning lights prior to sudden shut down.

The incident occurred when I attempted to shift the transfer case into 4-Low. The sequence of events is as follows: 1. I stopped the vehicle and shifted into Park. 2. With my foot on the brake, I shifted into neutral and attempted to move the transfer case lever from 4-High, to 4-Low. 3. As I started to move the transfer case lever, a warning appeared in the instrument cluster stating, "Vehicle speed too high to shift". 4. Auto-Park engaged 5. The engine, uncommanded, with my foot still on the brake, began to increase in revs slowly. 6. Check engine light illuminated, the engine continues to increase in revs. 7. When the engine reached 6-7k RPM, I hit the engine start/stop button and held it down until the engine turned off. The engine was still climbing in revs until this point. 8. I restarted the engine and could shift into 4-Low...

I was driving on the expressway when the engine suddenly slowed the car, I lost all ability to use the gas pedal. The deal found metal shavings in the engine leading to the engine being replaced. Prior to this I had several check engine lights that when the dealer looked at the vehicle, they simply reset them and told me all was ok. I lost all power on the expressway- all passengers in the car felt it and were terrified. In a separate incident also on the expressway I experienced a violent wobble and rattle of the entire car including the steering- I have a video of this as my daughter happened to catch it. It felt very dangerous and I had to slow to stop it. It happens when I hit a bump. This is a new vehicle with less than 10 K miles.

Vehicle loses power without warning. This has occurred numerous times, twice on a crowded freeway when I had to navigate across 5 lanes of traffic. Dealer was unable to isolate and repair the problem the first time. Vehicle is in for repair again. An internet search indicates this is not uncommon and at least two class action suits are pending. I'm shocked this life threatening fault has not already been reported to the NHTSA. Repair codes are : P1E1D control module improper wake up performance, U1817 Lost communication with hybrid powertrain control module on D-PT, U0293 confirmed, lost communication with hybrid control module.

i was. driving on the FWY, when I pass the bridge, there is a small rupper bump. the car starts shaking vertically and starts to slow down in the middle of the Fwy. I try to speed up to pull over to the right, but no response, where I felt the gas peddle is not working at that moment. I was lucky there were not too many cars behind me on the Fwy. I went to the dealer and they say something about, dead throttle.

I pulled my Jeep into my driveway. I put the car in park with my foot on the brake. When I went to turn the car off, I heard a loud sound coming from the car. the car jerked forward, my foot still on the brake, and then it took off into the side of my house and garage. I tried to stop the car with the brakes and it wouldn't stop. After it hit the house, I looked down and the car was still in park. I had to restart the car as it shut off after hitting the house, I put the car in reverse and backed it up. When I put it back in drive the car wouldn't move. Only reverse worked. After an hour the car started working in drive. I had the car towed to the dealership. They told me that there were no error...

I was driving home from a trip to the store. I stopped at a red light and all of the sudden I got a message that traction control failed, service charging system, and power train failure occurred. I had no power to move the car and the brakes barely worked. It told me to put it in park and restart the Jeep. I was able to roll downhill to the median out of traffic and put it in park and restart it. It seemed to work normally until I went another mile or so and it happened again. This time I was in motion and had a very difficult time stopping in the middle of traffic to put the Jeep in park and restart. This is a VERY serious problem and I’m very lucky it didn’t happen on the interstate. I am a member of two Jeep 4xe groups on...

While driving on the freeway at about 70mph, my vehicle shut off completely and I had to pull over to the shoulder. While pulled over I was unable to restart the vehicle for about 45 minutes. Vehicle dash displayed “Service Transmission, E-Drive Unavailable, Charge system fault.”

Went on a 1600 mile round trip from Florida to Pennsylvania. On the way back down to Florida my upper coolant hose busted and stranded me in South Carolina, 300 miles from Florida. Was on the side of the interstate with less than 20k miles on a new jeep. Thankfully no fire or anything started and the engine was close to blowing up. Only took about 45 seconds for the engine to over heat once the hose busted and I pulled over.

When starting the vehicle after sitting for an hour, there was a strong smell of a sweet substance and the cooling fans were running at full speed while stationary. Approximately 3 minutes later the vehicle stated the engine coolant temperature was 280 degrees Fahrenheit and to pull over. After pulling over and shutting off the vehicle on the side of the road, driver noticed a large puddle forming under the vehicle of pink color and was dripping from the front drivers side of the engine, at the water pump and coolant reservoir was empty. Vehicle was towed by Jeep roadside to nearest dealer who cant look at for a week.

While driving the jeep it gets a error code that says Service Electric throttle body. I’ve owned the car for about 20 months. This is the fourth time this issue has happened. Seems to happen every 5 months or so. The first time they replaced the throttle body. Second time they replaced it again and had it back for one day and the issue popped up again. They then said they would replace it but it had to be something else since it was a brand new throttle body. They ended up replacing the PCM and I was without the Jeep for an entire month. This time I went in and they said it wasn’t the throttle body. So they cleared the codes and I went to pick it up, when I turned it on it tells me to service electric throttle body. I couldn’t even make it out of...

While driving my vehicle and going about 30-40mph, the dashboard began flashing and telling me there was a charging system failure. At that point I could no longer accelerate and the "D" light on the gear shift was blinking. After putting the car in park, it would not allow me to change the shift gear to a different position. The Jeep app on my phone alerted me that my vehicle could not charge which was strange because I was driving and not charging at all. I had to pull over in the middle of a very busy intersection and turn off my car and turn it back on just to get it going again. When I turned it on, everything was back to normal and I was able to drive. This is very dangerous and luckily I was not on the highway and going 60mph when this happened or it...

Brand new 2021 Jeep Wrangler Unlimited Sahara 4xE (purchased 02/03/22 for $57,295) with 1,300 miles on it shut down while traveling at full highway speed (75 mph) on a major highway in the San Francisco Bay Area. The system flashed a 'stabilizer system' warning and immediately lost speed and did not respond to pressure on the gas/e pedal. We turned on the hazards and coasted across several lanes of traffic to the shoulder. After restarting, the dash displayed a check engine light the remainder of the trip, and the engine cut out one more time on the way home in a much slower safer area, thankfully. This is the second similar/major issue with this vehicle. On March 10, 2022, with only 419 miles on it, the vehicle displayed a charging error message at attempted start, provided no power to the engine, and locked itself in 'Park.' Fortunately, this engine power...

A coolant fitting came loose from the engine block, spewing coolant and steam from the engine bay and partially obstructing vision through windshield. After researching online I see this is a very common issue on 2018-2022 Jeep Wranglers.

Subject: 2021 Wrangler Unlimited (3.6L) Automatic with manufacturing defects. I am writing this email to complain about my 2021 Wrangler Unlimited (3.6L) Automatic that I Purchased on 28 November 2021 from Trading Enterprises company LLC Al-Futtaim group(sales Office Dubai UAE-DFC). Unfortunately, The Jeep’s problem started on day one drive-by suspecting strange noises coming from the Engine’s side. I requested an appointment at Trading Enterprises Dubai, and the Service Advisor told me the sound is normal (it's a new car, and the noise will go after some time). In January 2022 I went on a mountain camping trip with my small family in Fujairah city and suddenly the car’s power was cut completely on a steep mountain(Have shared the videos with the TE team showing the front wheels are not spinning). The car was about to roll over and I was embarrassed, frightened, and worried about my family’s safety. I managed...

We had just reached highway speed of 70mph and the Jeep began a normal regen cycle. However, the engine revved up on it’s own and the check engine light came on and a message that stated the exhaust filter was 100% full see a servicing dealer. Then without any warning, the Jeep went into limp mode from 70mph-50mph. With no notice, we were thrown forward due to the sudden decrease in speed. This action caused the vehicles behind us to swerve to avoid collision. My adaptive cruise control shut itself off and the electronic throttle control warning light started flashing. My throttle control was weak and unreliable, taking a lot of pedal to respond and then not needing hardly any pedal and would surge forward with sudden speed. It was a very dangerous situation. We continued driving in limp mode as there were no safe locations to stop and we...

Cylinder head failure caused engine to leak engine oil. Ultimately FCA was able to repair the defective upon replacing a cylinder and head gasket multiple times. The true cause of the leak was never determined as the replaced head did not appear defective. This is being reported to NHTSA due to numerous defects and safety concerns that have arisen with this vehicle.

Red Turtle warning light appears and the vehicle slows down immediately to 5~8 mph. Happens without warning and apparent triggers. Occurred multiple times in last week on freeways, exiting parking lot and on side road.

I bought a brand new Jeep Wrangler Rubicon 4xe in July 2021. Starting in December of 2021 and continuing to this day I will periodically get an error message that says "Service Hybrid Electrical System" and the car will either not start or shut off while it is in motion. I have contacted Jeep Cares and have been elevated to their customer retention group to continue to try to solve this issue. The dealer has been great at trying to fix the issue but they have admitted that they don't know what it is or how to fix it and are relying on the national Jeep engineers to help try to fix it. Talking with the mechanics at the dealer they keep saying the national Jeep engineers are just guessing at this point on what the issue is and they don't know what the issue is either. I am far...

I was driving my car last night and it it just stopped on the 15 fwy, while everyone was driving 70 MPH. This car will kill me or kill others!!!! It’s unsafe!!!

Could not start my 2021 jeep only 900 miles on it and said charging fault and then started an hour later but then later on that day Was driving with my child and dead stop in middle of turnpike just shut off. Thank god it turned he Ck on and made it home. Now dealership is saying they can look at it within two to four weeks. This is a terrible.