2023 GMC SIERRA 1500 Electrical System Problems

The vehicle has experienced repeated incidents of sudden reduced engine power and loss of acceleration while driving. On multiple occasions, while traveling at highway speeds, the vehicle failed to respond normally to throttle input and would not accelerate as commanded and loss of power steering making it difficult to turn the steering wheel and apply brakes. One incident resulted in throwing my truck off the road and luckily we nearly avoided a multi car collision and potential pile with my wife, 8yr old daughter and newborn son in the vehicle at high speeds up to 60/70+ mph but despite avoiding a major life threatening accident to us and other drivers, resulted in striking objects, glass and debris on the side of the road causing damage to my vehicle and then sliding to a complete stop in the ditch off the highway. This creates a hazardous driving situation, particularly when merging...

I was driving on an overpass and suddenly loss propulsion in my vehicle. My vehicle stopped all of a sudden and while driving, leaving me stranded in the middle of the roadway blocking traffic. Numerous motorists stopped to give a hand but the vehicle would not switch gears from PARK, to neutral to even give me a hand moving the vehicle out of the roadway to the side/shoulder. Due to this issue, authorities were dispatched to my location to conduct traffic control and subsequently called in aide of a tow truck to safely move my vehicle to a better location. I used OnStar in my vehicle and also spoke with a representative who notated the incident and I was advised that a tow truck would take approximately 90 mins to 2 hours to reach me. In this instance, that was too long of a wait for events going wrong with...

Engine shut off on the interstate with no warning. Would not re-start. Forced to cross lanes on traffic with no engine power or power steering. Dealer stated it was the "Fuel Pump Control Module." Stated it was a common issue with parts most likely in stock, but it would be at least 6 weeks before they could even look at the vehicle.

Vehicle will show lane keep assist system as active but provide no intervention and allow vehicle to travel into the next lane intermittently. System will also move itself to the next lane unexpectedly when near the lane markers of the original lane. Navigation system and radio will freeze, stop working all together, and at times fully reboot, randomly while in operation. While these issues are frequent, they are intermittent. No repair suggestions by dealer or manufacturer

The contact owned a 2023 GMC Sierra 1500. The contact stated that while the vehicle was parked on the driveway, it caught on fire. The contact was inside the residence when a passerby knocked on the door and informed the contact of the fire. A neighbor helped extinguish the fire. When the contact stepped outside, the flames were by the instrument panel; the flames had risen to the rooftop. The front windshield was shattered. The fire was contained to the cabin. The fire department was called. The contact stated that weeks before the fire started, an abnormal sound could be heard coming from the engine. The contact removed the battery from the vehicle. The vehicle was not insured. The manufacturer was not made aware of the failure. The failure mileage was unknown. 

This malfunction is ongoing and the dealership cannot fix the problem. The first time it happened in September 2025. I was driving down the road and the gauges started to go crazy. The screen on the dash said reduced acceleration. Then it said Service ESC. Then it said Service Traction Control. It would not let me go over 40 mph. I took it to the dealership and they told me I needed a valve body replacement. They installed the valve body and that did not fix the problem. It happened again and said reduced acceleration took over forcing me to pull over on the side of the road. The GMC dealership said to bring it in again but they could not reproduce the malfunction after driving for a week. It happens randomly. The third time this happened I was traveling up interstate 24 at about 70 mph. There were semi...

The OnStar vehicle locater, GPS maps, clock (auto update) are not responsive as of the 2nd week of December 2025. My truck cannot be located via OnStar, I cannot use the GPS Maps for directions, and the Clock reads 12 minutes fast when I put it into Auto Update mode. Reported to my GMC dealer (Elizabeth City GMC, Elizabeth City, NC 27909, and had in for service 3 times without correction of the issue! The dealership conducted a Software System Update which cost me $400.00, and still did not correct the issue. I spoke with OnStar three (3) times to try and correct issues but they did not resolve the problems either. OnStar stated it is a GMC issue............My last service at the Elizabeth City GMC dealer the Service Tech stated the OnStar Module is bad and requires replacement, and stated it will be an additional $550.00 +/-!!! Please advise...

The Telemetry/OnStar unit stopped working on my 2023 GMC Sierra 1500 Denali. This renders the OnStar unit unusable for both data and calling OnStar. In the event of an accident, the driver could not call OnStar for help and OnStar would not get an automatic notification that there had been a crash with the vehicle's location. The failure of the unit has also caused a code indicating Low Brake System Voltage. I know that is not the case in my vehicle at this time, but if the brake system does start to fail, there is no way to know if the code is real or just a result of the Telematics system failing. This failure occurred shortly after an Over-The-Air software update GMC sent out. I have seen numerous reports of people with the exact same year and model having the same issue. The unit worked fine for 2.5 years...

OTA update GM N25-250380 caused significant problems. Blinker tone and other safety tones are erratic. Infotainment system is erratic. Constant reboots while driving causing distractions. Camera screens will freeze on screen while driving down interstate. It may be affecting other systems as well since everything is erratic and buggy now.

Truck will down shift and transmission will slam, super hard. feels like i hit something. almost causing accident. dealership refuses to service my truck or even take a look at the transmission because "its not broken yet" in their words " it needs to fail before they can service it or even look at it, because they wont get paid." I have expressed my concerns about this safety issue and at this point they are being negligent. My truck is a 2023 gmc sierra 1500 with 3.0 duramax . still under warranty with only 35k miles.

The vehicle has suffered repeated systemic electrical failures all while being under 8,000 miles. What component/system failed? Power distribution/fuse block, starter, fuel pump control module, horn circuit, body control module, instrument cluster, and charging system. Error codes documented include P0627 (Fuel Pump Control Circuit), U0100 (Lost Comm ECM/PCM), B1325 (Control Module Power Low), U0140 (Lost Comm BCM), and B1000 (ECM fault). All repairs are documented by the dealer, and the truck remains available for inspection. How was safety at risk? The truck lost propulsion at speed, emitted smoke from the engine bay, and became disabled in traffic, placing my family, including my toddler, in immediate danger of collision and fire. Electrical defects also disabled horn and instrument cluster, removing critical warning and signaling functions. These electrical issues have been ongoing for months and GM refuses to replace and can't seem to fix it. Has it been confirmed? Yes. Each failure...

Tail gate keeps opening

The entire instrument panel is blacked out. I can not see the speed, how much fuel and no waring lights etc. The screen flashes between black and dark blue and there is a repetative "ding" that I have no idea what is caused from since I can not see any warning lights, etc.This puts me and others at risk due to not being able to see any functions for operation of the vehicle, the speed or any indicator lights of vehicle issues. The dealer has seen the truck, and informed me that this is a known problem and they would have to order parts. According to the service department, parts for replacement will be covered under warranty/recall and they have been on order. It has been 3 weeks and they have no knowledge of when the parts will be in to make repair. There was no warning on this problem,...

Per my dealership, there is chaffing in the main wiring harness of the vehicle and the entire harness needs to be replaced. On recall N222391510, for Sierra's of the same year, the harness had to be replaced as well.

Tailgate opened several times without being prompted. Once while driving, two times while in park.

Diagnostic: Video Processing Module includes replacement and reprogramming and calibrations Diagnostics when referred to in an automotive sense is the various testing done on the automobile to ensure safety and proper engine functioning. These tests are done with different sensors, computers and machines to establish a “cause and effect” relationship between what is working and what is not working with the automobile. The forms of diagnostics can range from brakes, to air conditioning, to suspension and many more. PARKING GUIDELINES ON SCREEN DO NOT WORK AND THERE IS A BLUE HOUR GLASS ON SCREEN. $2,200 estimate to repair.

Subject: Urgent Safety Concern – Widespread Failure and Nationwide Backorder of OnStar Module (GM Part No. 86803964) Dear NHTSA, I am writing to formally raise a serious concern regarding a widespread and well-documented failure of the OnStar module (GM Part No. 86803964) in 2023 GMC Sierra vehicles and potentially other GM models. I own a 2023 GMC Sierra equipped with this module, which has failed, rendering my vehicle’s entire instrument cluster completely inoperative. All screens, including the digital gauges and essential driver information displays, are blacked out, leaving the vehicle in an unsafe and non-drivable condition. After contacting numerous GM dealerships across the country, I have discovered that this part is on national backorder, with over 4,000 units reportedly pending. I have also learned that the part number has been superseded multiple times, suggesting an ongoing and unresolved issue. To make matters worse, Specmo is reported to be the sole...

I just left the gas station from getting a beverage, I got onto the interstate and had gone roughly about 3 miles before setting super cruise a few minutes after that the interstate takes a turn to the left with an exit on the right. Slightly right as I was just getting into the turn my engine shutoff and or died making my truck uncontrollable causing me to drive off the interstate into some small trees between the exit and the interstate. I was not injured and no other vehicles were involved. My truck is currently at the insurances storage yard and they care claiming it to be totaled. I have contacted GM and filled a claim however they are saying they aren’t responsible because the insurance company has my truck. I feel like regardless of who has my vehicle the manufacturer should be responsible if the issue pertains to...

Driving on hwy at 60 mph on regular day going home and trucks all off sudden started rattling and engine knocking very loud , engine started crashing loosing power , has to merge to side of road and call tow truck

2023 GMC 1500 Sierra Denali Ultimate tailgate opens without being commanded. This has happened approximately three (3 ) times in the last two months while being driven with the most recent incident occurring today, 04/27/2025. There are no warning lights indicating when a tailgate opens while the vehicle is being driven.

Engine has seized twice, completely shutting down without electrical power or brakes. The vehicle also shut down in an intersection (no power, brakes, flashers). I was able to pull to the side on the 2 engine seizures but not during the electrical shutdown at the intersection in the turn lane. The engine was replaced the first time by Quality GMC in Albuquerque, NM. The 2nd engine is being replaced by Diamond GMC in Palmdale, CA. Warning lamps on the 1st engine seizure was tire pressure warning. The electrical shutdown was forward collision warning, emergency braking, etc. The 2nd engine seizure said something about engine needed to be restarted.

Tailgate opened while in park.closed garage door.Came back out to leave and garage door got caught on tailgate that had released open on its own causing body damage.

The truck check engine lights came on, and I took it to a dealer. I was told the ECM was faulty, they replaced it, but it didn't fix the issue. I was then told the ONSTAR telematics unit was faulty. The truck has been down for 45 days, with no ETA on parts(several forms say 4-6 months). There is no guarantee that this will fix the CEL. The truck is inoperable at this time.

While entering the highway from a downward slop exit ramp and towing a trailer, my truck shuddered hard and briefly locked up the rear axle. It immediately went into limp mode with a message that driving speed will be reduced. It also wouldn't shift past 5th gear. When the event took place, the OBD2 generated over 20 trouble codes. My local dealer advised I could drive it to them for repair. Upon dropping it off, they now advise it's NOT safe for driving and they have no eta on the parts to repair the issue. It's now been at the dealer for a week with no update. This is a well known issue that GM refuses to repair or provide a reasonable timeframe for repair. There are countless videos such as this one that show what happens when this takes place. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF...

Tailgate opened/unlocked while parked during rain and light snow. The tonneau cover disguised that the tailgate was open (held it up just enough so it was not visable). The tailgate fell open while driving but went unnoticed. Several large and expensive items were lost out of the back of the truck which is used as a work truck for electrical services. This has happened twice on the roads. Now the tailgate is physically checked before driving to ensure it will not fall open. The incident was mentioned to the local GM dealer but we were told our model was not part of the recall. Our next call will be to GM directly to try to remedy the problem and hopefully recoup the items lost.

On the highway, the engine suddenly stopped working. Everything turned black. While driving, the screen turned back on but the motor did not start again. I pressed the breaks and the start button to turn the engine back on, while still driving on the highway. It turned back on but then stopped again before I had time to pull to the side of the road. I did the same again and got to bring the car to the side of the highway. It started and stopped several times. I got it to run again so I exited the highway. It turned off again once I was off the highway. I got to drive it slowly to the dealer. He said it had never happened (which is untrue, I found out it is a recurring problem on the GM 6.2 liter). I had brought the car for service to the same...

The tailgate on my truck opened while I was driving and I was unaware until I got to my destination. I had a utility trailer attached at the time and my tailgate was damaged from the jack on the trailer. I thought maybe I didn't latch the tailgate but it has been several days since I opened it. The following day the tailgate dropped two more times in less than a mile. I see there is a service bulletin and recall on most GM models but my truck is not included. I made a service appointment at my local dealership for them to inspect. The service writer already stated that my truck has no open recalls. I feel this is a safety issue first and second my truck has body damage. I use my truck as a truck and usually have stuff in the bed. My truck is completely stock...

The contact owns a 2023 GMC Sierra 1500. The contact stated upon attempting to start the vehicle remotely, the lights illuminated; however, the engine failed to turn over. The contact stated that upon pressing the Push to Start button, the message "Service Braking System" and other braking system messages, and message that the "Top Speed 43 MPH" were displayed. The check engine warning light was illuminated. Additionally, the contact stated that the vehicle experienced reduced braking while driving at various speeds. The vehicle was taken to the dealer where an unknown software update was performed; however, the failure recurred. The contact stated that the failure occurred intermittently. The vehicle was taken back to the dealer, where a service representative scanned the vehicle and informed the contact that diagnostic trouble codes were retrieved; however, the dealer later informed the contact that the failure could not be replicated. The contact used a...

I have been trying since day one of my brand new 2023 Sierra Denali pickup truck hence I spent a $100 K plus OEM accessories at the dealer ! This complaint is in reference to the safety part of the brake trailing that disconnect and lose light and brakes ! I have Spent insane times at the dealers and have complained to the GMC Executive offices with Nothing but excuses and Absolutely Zero Help from GMC Cooperate but continue to go make appointments at the dealers ! This is Safety complaint and they are not taking this seriously at all ! There is defiantly a ongoing issue with either the computer onboard or the trailer Module ! I am not a engineer but again this is a safety Issue that needs to be looked at ASAP ! I do not feel safe driving the truck !

The contact owns a 2023 GMC Sierra 1500. The contact stated while driving 65 MPH with the cruise control engaged, the instrument cluster was blinking and then went black. The contact stated that the failure was intermittent but had become a recurring failure. The contact also heard a chirping sound when the instrument cluster went black. The contact had taken the vehicle to a dealer and was informed that there were no failures with the electrical system. The contact was unsure if a diagnostic test had been performed. The vehicle was not repaired. The manufacturer was informed of the failure. The failure mileage was approximately 56,000.

Engine goes to limp mode multiple times 3 of which happened getting onto the highway and almost creating an accident due to the reduced acceleration mode. CODe u0656 00 popped up each time. Dealer has yet to rectify due to lack of appointments… making me keep the vehicle saying it’s drivable but each time randomly goes into the reduced acceleration mode every restart. (Blasius GMC Branford CT)

Approx 17 months after purchase, tailgate release button (the lower button on the tailgate that is used to open (fully) the tailgate) stopped releasing the tailgate, however tailgate releases randomly when opening one of the truck doors. Based on the "fix" that has been subscribed for existing Chevy & GMC trucks with recalls for this same problem (although my truck isn't covered by current recalls) , my mechanic has ordered a new tailgate release switch (or whatever it is called) which they are installing tomorrow.

I bought truck brand new one week later the tailgate opened while driving and hit the trailer and destroyed the tailgate. So I bought a brand New tailgate and repaired truck. Few months ago it happened again all my tools flew out into the highway almost caused a major accident and destroyed my saw and tools got thrown all over the road. Last week it opened again and destroyed the new tailgate I bought. The dealer is aware, gmc is aware and no parts to fix it or does anyone want to help me just let me drive a truck that is so unsafe. It's all over the internet this issue people are saying there tailgate opens while driving and gmc made a statement saying they are aware but not helping me. Sold me a truck for alot of money knowing it's a major dangerous defect that can cause major...

Pulled up to a stop sign and attempt to make a right turn as I was in the turn the steering wheel locked up in the turn which almost caused and accident . I had to get the vehicle towed to Wyatt Johnson GMC dealership in Clarksville TN. I purchased this truck in Jan 2024 from Romain Cross Pointe Auto Park in Evansville ,Indiana at 7600 E Division St, Evansville, IN 47715 it had 13k miles. I'm the second owner I only put 2k miles since ownership. I was able to obtain a vehicle history report which shows this has been an on going problem among other issues DTC code U0131 Lost communication with Power steering Module shows at least 9 times that Romain GMC try to fix the problem. This is extremely dangerous to drive and the steering goes out this has been a known problem.. See attachments

Component or system failure: headlights and interior lighting Safety risk: Complete failure of the headlight system and all interior lighting, including the dashboard during active driving. System failed during nighttime driving while in motion. Reproduced?: No Inspected?: No Warning lights/system messages: None present at time of failure

Vehicle had a body control module issue dealer repaired but issues never went away I did not buy the car with the tailgate opening randomly

TRUCK HAS DIED GOING DOWN THE ROAD AT 40MPH. ALSO HAVE ELECTRICAL ISSUES WITH RADIO..RUNNING BOARDS OPENING GOING DOWN THE ROAD. NO SOUND FROM RADIO, SIGNALS ...NO CONNECTIONS TO GOOGLE ON STAR LOST. RADIO SCREEN HALF OF SCREEN SHUTS OFF. FRONT CRASH SENSORS GO OFF WITH NOTING IN FRONT OF VEHICLE...LOSS OF CAMERAS NO CONNECTION. SOUNDS LIKE A BUG ZAPPER UNDER TRUCK. GM HAS REPROGRAMMED TRUCK NOW 3 TIMES SENT A TECH FROM FACTORY...REPLACED RADIO REPROGRAMMED ALL COMPUTERS AGAIN!! TRUCK HAS BEEN IN THE SHOP THIS TIME FOR OVER 30 DAYS WITH 6200 MILES ON IT THIS IS THE 4TH TIME SINCE I BOUGHT IN JUNE. HAVE A CASE REPRESENTATIVE FROM GM WHO WILL NOT HELP WITH ISSUES JUST KEEPS PUTTING ME OFF. HAVE VIDEOS PICTURES OF ALL THE ISSUES AND HAVE GIVEN TO DEALER AND GM

The contact owns a 2023 GMC Sierra 1500. The contact stated while driving 25 MPH, the vehicle lost motive power and decelerated while the accelerator pedal was being depressed. The check engine warning light was illuminated. The dealer diagnosed the vehicle and determined that a software update was needed. The vehicle was repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 7,780.

Driving home in the 2023 GMC Sierra 1500, when the error message came up to Service Power Steering. A short time later also had messages for ESC, Restraint System, and Trail Brakes error messages. Then lost all electric power assist on the power steering, and truck almost impossible to turn without extreme effort. Took to dealer and they had truck for almost 2 weeks and said they couldn't replicate the problem. Within 24 hours of getting it back I had the exact same problem, with total loss of power steering assist. Parked truck for approx an hour, and it reset and was functioning normally again. Short time later got the Service Power Steering message again, but didn't lose power steering this time before the computer evidently reset. Major safety issue because if this happens while taking a turn or something at high speeds, I'll be in a ditch or lose...

Upon start up the HVAC fan speed reduces by self and will not increase by own in auto mode.

--Unwanted Reduction in The Front HVAC Blower Speed and Loss of Radio, Auto AC not working as designed --driver seat vibrating as the lane departure warning activated; I had turned the seat vibrate function off on 25 June 2023. I then went into settings to turn the function off again, and the system would not allow to make the change, it stayed in vibrate function --the passenger front window will not go up automatically, had to hold the button to make the window go up all the way. I then had a message in the DIC, that said, “Open and close passenger door”. I did so, at the next stop, but the message stayed on the DIC and the window still would not go up automatically with the button -- when the vehicle is operated and the AC is NOT on, just the fan, and windows down, and the auto...

Battery - Total discharge of the battery. 2023 GMC Sierra Denali purchased in Jan 2023. In July 2023, vehicle with 3800 miles door would not open, engine turn on, etc with electrical system completely inoperable. Upon checking the battery, it had 0% charge.

The infotainment system loses all audio through the speakers intermittently. when this happens I also lose the Safety warning chimes as well. shutting off the vehicle for an extended period of time resets something and it resumes normal function. I have contacted GM customer service and spoke to 3 different representatives and requested an escalation to a Senior Advisor, which i was told could take up to 4 days to hear back. the vehicle has 800 miles and is 1 month old, this has occurred 4 times. it has not been looked at by the manufacturer as i am waiting for return communication. Other than no sound, everything else on the touch screen seemed to be working normal, but im no technician to determine that. i feel this is a safety concern as i travel with my 13 month old daily.