1999 GMC SAFARI — Problems, Recalls & Safety Data

TL*THE CONTACT OWNS A 1999 GMC SAFARI. SINCE THE VEHICLE WAS PURCHASED IN MAY OF 2005, THE STEERING IDLER ARM HAS BEEN REPLACED FOUR TIMES. AS A RESULT, THE VEHICLE HAS LOST STEERING ABILITY. THE CONTACT HAS PUT 30,000 MILES ON THE VEHICLE IN TWO YEARS. THE MECHANIC STATED THAT THE IDLER ARMS HAVE FAILED AND NEED TO BE REPLACED. THE MECHANIC ALSO STATED THAT THIS IS A COMMON FAILURE DUE TO A DESIGN FLAW. SHE HAS NOT CONTACTED A LOCAL AUTHORIZED DEALER OR THE MANUFACTURER. THE VIN AND ENGINE SIZE WERE UNKNOWN. THE CURRENT MILEAGE IS 99,000 AND FAILURE MILEAGE WAS 70,000.

DT*: THE CONTACT STATED WHILE TRAVELING 5 MPH, THE VEHICLE'S ABS SENSOR UNIT FAILED ON THREE SEPARATE OCCASIONS. THE SERVICE DEALER REPLACED THE ABS SENSOR UNIT THREE TIMES, BUT THE PROBLEM PERSISTED.

1999 GMC SAFARI TRANSMISSION FAILURE. SEE GM TSB #00-07-30-002 DATED 11/2000. 1ST-2ND LATE SHIFT, REVERSE, 2ND, & 4TH GEAR CAUSED IMMEDIATE FAILURE. ALL REQUIRED TRANSMISSION SERVICE PERFORMED BY DEALER ON THIS VEHICLE. ROOT CAUSE IS THE KNOWN SUN GEAR SHELL FAILURE IN THE GM 4L60E AUTOMATIC TRANSMISSION. VEHICLE HAS 70,511 MILES. FILED GMC CUSTOMER COMPLAINT #1-366073225. *JB

DT: ABOUT A YEAR AGO THE PROBLEM BEGAN. WHEN BRAKING AT LOW SPEEDS ABOUT 5-10 MPH ABS KICKS IN AND A GRINDING SOUND OCCURS. THIS CAUSES EXTENDED STOPPING DISTANCES. ALL WHEEL DRIVE, ALL WHEEL ANTILOCK TO THE OWNER'S KNOWLEDGE. NO WARNING LIGHTS ILLUMINATED AND THE DEALER SAID THAT THE ABS SENSOR LOOKED CORRODED. THE VEHICLE WAS PUT ON THE DIAGNOSTIC MACHINE BUT IT SHOWED NO CODES. WHEN THE ABS FUSE IS PULLED THE CAR WORKS FINE BUT HAS NO ABS. THE OWNER HASN'T DISCONNECTED THE ABS FUSE. THE VEHICLE HAS NOT BEEN REPAIRED YET AND THE PROBLEM HAS REMAINED ABOUT THE SAME. THE PROBLEM OCCURS ABOUT 90 PERCENT OF THE TIME DURING LOW SPEED BRAKE APPLICATIONS.*AK *NM

THIS MORNING (5/4/05) WHILE DRIVING MY 1999 GMC SAFARI, I EXPERIENCED A JOLT AND A HIGH RPM REV AND A LONG 1-2 SHIFT. I GOT TO MY DESTINATION (1/4 MILE UP THE ROAD) AND THEN DISCOVERED THAT I HAD NO REVERSE. I IMMEDIATELY DROVE TO THE DEALER (A 6-MILE DRIVE). I NOTICED IN ADDITION TO NO REVERSE, THERE WAS ALSO NO OVERDRIVE (4TH GEAR). THE PRELIMINARY DIAGNOSIS FROM THE DEALER IS A FAILED SUN SHELL ASSEMBLY. THEY (THE DEALER) INDENTIFIES THIS AS A COMMON PROBLEM. TO REPAIR IT REQUIRES A MAJOR OVERHAUL A NEARLY $2000.00 REPAIR. I'M A MEMBER OF IATN (INTERNATION AUTOMOTIVE TECHNICIANS' NETWORK) AND I DID A SERACH OF THIS CONCERN AND LEARNED THAT THIS IS A COMMON FAILURE. I ALSO LEARNED THAT GM HAS A TSB ON THIS CONCERN (I DON'T KNOW THE NUMBER OR NATURE OF THE TSB). AT 6-YEARS OF AGE AND 88,000 MILES THIS (IN MY ESTIMATION) IS A PREMATURE FAILURE. THE TRANSMISSION HAS BEEN SERVICED (FLUSHED AND FILTER REPLACEMENT) TWICE IN THE PAST THREE YEARS AND HAS NOT BEEN ABUSED. I DO TOW TWO SNOWMOBILES IN THE WINTER, BUT THE WEIGHT IS BY FAR WITHIN THE PARAMETERS STATED FOR THIS VEHICLE. I CALLED THE GM SERVICE ASSISTANCE CENTER AND THE WOMAN ACKNOWLEDGED THE PATTERN FAILURE, BUT SAID THEIR "POLICY" FOR GOODWILL ASSISTANCE IS CAPPED AT 72,000 MILES, MY VEHICLE HAS 88,000 MILES. SHE WAS PREPARED TO OFFER ME SOME KIND OF VOUCHER TO BE USED TOWARD THE PURCHASE OF A NEW GM VEHICLE, BUT I'M NOT INTERESTED IN THAT. THERE'S CLEARLY A PRODUCT CONCERN, AND IF GM IS WILLING TO GIVE ME A DEAL ON A NEW CAR, WHY DON'T THEY GIVE ME A "DEAL" ON REPAIRING THIS ONE? ANYWAY, THAT'S MY COMPLAINT.