2004 FORD RANGER Engine And Engine Coolingengine Problems
5 NHTSA complaints on file
Engine And Engine Coolingengine Issues in the 2004 FORD RANGER
5 engine and engine coolingengine complaints have been filed with NHTSA for the 2004 FORD RANGER. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.
5
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
All Engine And Engine Coolingengine Complaints
2004 FORD RANGER, WHILE DRIVING ENGINE SHUTS-OFF. *BF THE CONSUMER STATED SEVERAL DEALERS AND AUTO SHOPS WERE UNABLE TO DUPLICATE THE PROBLEM. *JB
TL* THE CONTACT HAS A 2004 FORD RANGER. THE FUEL SHUT OFF VALVE WAS LOCATED AT THE FRONT OF THE PASSENGER SEAT UNDER THE DASH BOARD. THE PASSENGERS CAN CONTACT THE COMPONENT WITH THEIR FEET BECAUSE OF ITS POSITION. THIS MAKES THE ENGINE SHUT DOWN WHEN DRIVING. HE HAD TO PAY TO REMOVE THE VALVE AND PUT IT BEHIND THE KICK PANEL ON THE RIGHT SIDE. THE MANUFACTURE WAS NOTIFIED AND HE WAS ADVISED THAT THERE WAS NO WARRANTY OR RECALLS ON THIS VALVE. HE SENT A LETTER TO THE PRESIDENT OF FORD MOTOR COMPANY. THE FAILURE MILEAGE WAS 24,000.
ROUGH RUNNING, MISFIRE AND A LACK OF POWER DUE TO A LOSS OF COMPRESSION. *JB
2004 FORD RANGER WITH 3.0 LITER FUEL INJECTION. BOTH CYLINDER HEADS CRACKED AROUND EXHAUST VALVE SEATS. BOTH HEADS HAD TO BE REPLACED. MILEAGE ON VEHICLE IS 46,000 MILES AND NOT ABUSED. *NM
THE CHECK ENGINE LIGHT ON MY 2004 FORD RANGER KEPT COMING ON, I WAS TOLD BY ONE DEALER THAT IT WAS AN EMISSION SIGNAL AND THAT IT WOULD RESET. IT DID BUT KEPT COMING BACK. THE TRUCK THEN STARTED RUNNING BAD, SO I TOOK IT TO ANOTHER DEALER, WHO TOLD ME THAT THERE WAS A TECHNICAL SERVICE BULLETIN OUT ABOUT THIS PROBLEM AND THEY HAD TO REPLACE BOTH OF MY ENGINES HEADS. AND OF COURSE BECAUSE OF THE MILES ON MY TRUCK, I WOULD HAVE TO PAY FOR THESE REPAIRS. I SAID THAT IF FORD KNEW ABOUT THIS DEFECT THEN WHY HAVEN'T THEY RECALLED THESE ENGINES. *NM
Other 2004 FORD RANGER Problem Areas
Air Bags
186 complaints
Structurebody
35 complaints
Suspension
24 complaints
Electrical System
14 complaints
Vehicle Speed Control
14 complaints
Unknown Or Other
13 complaints
Power Trainautomatic Transmission
11 complaints
Engine And Engine Cooling
10 complaints
Power Train
9 complaints
Tires
8 complaints
Engine
7 complaints
Fuelpropulsion System
6 complaints
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip
6 complaints
Structure
6 complaints
Exterior Lighting
5 complaints
Fuel System Gasoline
5 complaints
Seats
5 complaints
Service Brakes Hydraulic
5 complaints
Fuel System Other
4 complaints
Power Traindrivelinedriveshaft
4 complaints
Structureframe And Membersunderbody Shields
4 complaints
Vehicle Speed Controlaccelerator Pedal
4 complaints
Air Bagsfrontal
3 complaints
Fuel System Gasolinedeliveryfuel Pump
3 complaints
Service Brakes
3 complaints
Service Brakes Hydraulicpedals And Linkages
3 complaints
Steering
3 complaints
Suspensionfrontwheel Bearing
3 complaints
Tiressidewall
3 complaints
Tirestemporaryemergency Spare Tire
3 complaints
Visibility
3 complaints
Wheels
3 complaints
Engine And Engine Coolingenginegasoline
2 complaints
Seat Belts
2 complaints
Seatsfront Assemblyhead Restraint
2 complaints
Service Brakes Hydraulicfoundation Componentsdrumshoeslinings
2 complaints
Service Brakes Hydraulicfoundation Componentsdrumwheel Cylinders
2 complaints
Structureframe And Members
2 complaints
Tirestreadbelt
2 complaints
Visibilityglass Siderear
2 complaints
Visibilitywiper
2 complaints
Electrical System Instrument Clusterpanel
1 complaint
Electrical Systemwiring
1 complaint
Electronic Stability Control Esc
1 complaint
Equipment
1 complaint
Fuel System Gasolinedeliveryhoses Linespiping And Fittings
1 complaint
Fuel System Gasolinefuel Injection System
1 complaint
Fuel System Gasolinestoragetank Assembly
1 complaint
Fuel System Otherstoragefuel Gauge System
1 complaint
Latcheslockslinkagesdoorslatch
1 complaint
Latcheslockslinkageshoodlatch
1 complaint
Parking Brakeconventionalmechanicallinkage And Cable
1 complaint
Power Traindrivelinedifferential Unit
1 complaint
Power Trainmanual Transmission
1 complaint
Power Traintransfer Case 4 Wheel Drive
1 complaint
Seat Beltsfrontwarning Lightdevices
1 complaint
Service Brakes Airantilock
1 complaint
Service Brakes Hydraulicfoundation Componentsdiscrotor
1 complaint
Structurebodybumpers
1 complaint
Suspensionfrontcontrol Armlower Ball Joint
1 complaint
Suspensionfrontspringscoil Springs
1 complaint
Vehicle Speed Controlcables
1 complaint
Visibilityrearview Mirrorsdevicesexterior
1 complaint
Visibilitywindshield Wiperwasher
1 complaint