2001 FORD RANGER Structurebody Problems

The rear frame rusted so bad the bumper fell off and the frame actually cracked. This is a common issue with the late 1990s & early 2000s Ford Ranger, I do not understand why this isn't a recall yet as is it very dangerous. This happened on the highway. The front end frame, engine and all the components work flawlessly while the rear frame is just crumbling in rust.

The frame has rusted so bad it has completely separated from the body. The Ranger frame rusting is a known problem but it has not been recalled like the Toyota Takoma has been.

The frame is rotted and broken on both side in the rear

I noticed that there was significantly more rust than there should be. There are places where the frame has rusted through. It is a major safety concern. I researched the issue and found several others with the same concern. I also found that Toyota has previously recalled several vehicles for the same issue.

REAR FRAME HAS RUSTED THROUGH. REAR DRIVER SIDE SPRING MOUNT HAS RUSTED AND BROKEN FROM THE FRAME. REAR BUMPER MOUNTS AND SPARE TIRE MOUNTS ARE RUSTED OUT. VEHICLE WAS STATIONARY WHEN PROBLEM WAS DISCOVERED .

THESE ARE PICTURES OF THE FRAME ON MY RANGER. THE FRAME IS RUSTING OUT AND IT ONLY HAS 76,619 MILES ON IT. MY MECHANIC FOUND THIS WHEN I WAS HAVING THE BRAKE LINE REPAIRED AND HE LIFTED THE TRUCK.

TAKATA RECALL. MY VEHICLE WAS STATIONARY WHEN I GOT TO WORK I NOTHING MY REAR BUMPER FELL OFF WITH NO GIVEN WARNING AND I DIDN'T HEAR IT HIT THE GROUND I GOT HOME AND LOOKED UNDER THE FRAME AND NOTICED THE WHOLE FRAME WAS ROTTEN AWAY AND IS NOT SAFE TO DRIVE

I PURCHASED A USED 2001 FORD RANGER, WENT TO HAVE IT INSPECTED AND THERE WAS SEVERE RUST UNDERNEATH OF THE FRAME TO THE POINT THE INSPECTOR SAID IT WAS HIGHLY DANGEROUS TO BE DRIVING MY VEHICLE AROUND. WOULD LIKE TO KNOW IF THERE WAS ANY RECALLS FOR THE TRUCKS FRAME UNDERNEATH? WILL PROVIDE PICTURES IF NEEDED.

I BOUGHT THIS TRUCK USED. THIS IS THE FIRST VEHICLE THAT I'VE HAD THE FRAME RUST OUT. I JUST HAD SOME WORK DONE TO THE TRUCK AND MY MECHANIC SAID THAT A CHUNK OF THE FRAME FELL OFF WHEN HE LIFTED THE TRUCK TO DO WORK TO THE BRAKE LINES. I'VE ALREADY HAD WELDING WORK DONE TO THE TRUCK RIGHT AFTER I BOUGHT IT BECAUSE IT WASN'T DISCLOSED THAT THE FRAME WAS RUSTING OUT. THIS HAS BEEN AN ON GOING ISSUE. THE ATTACHED IMAGE IS FROM WHEN I HAD THE WELDING WORK DONE THE FIRST TIME.

TL* THE CONTACT OWNS A 2001 FORD RANGER. WHILE DRIVING 25 MPH OVER A RAILROAD TRACK, THE SPARE TIRE LOOSENED FROM THE VEHICLE WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OVER TO THE SHOULDER OF THE ROAD, LOOKED UNDERNEATH, AND NOTICED NOTHING BUT RUST WHERE THE FRAME FOR THE SPARE TIRE WAS LOCATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 136,092. *BF *TR

THE SALT ON THE ROADS RUSTED THE FRAME HORRIBLY CAUSING HOLES AND WEAK POINTS THROUGH THE BODY.

ALL 4 REAR SHACKLES HAVE BEEN REPLACED DUE TO RUSTING AWAY. ALSO DRIVERSIDE REAR SHOCK WHERE IT ATTACHES FRAME RUSTED OFF. THE BED HAS RUSTED OFF OF THE FRONT 2 BED MOUNTS

2001 FORD RANGER FRAME IS RUSTED OUT BAD. THERE SHOULD BE A RECALL ON THIS SINCE SO MANY PEOPLE ARE HAVING THE SAME PROBLEM. FORD SHOULD BE ASHAMED OF THEMSELVES FOR MAKING A VEHICLE THAT THE FRAME ONLY LASTS 15 TO 17 YEARS!

BODY FRAME RUSTED TO THE POINT I NOTICED THE BUMPER WAS HANGING DOWN ON DRIVERS SIDE, AS I LOOKED UNDER THE TRUCK IN MY DRIVEWAY I HAD SEEN THE SHACKLE WAS BROKEN AND THE PLATE OVER THE SPARE TIRE WAS CRACKED WHICH COULD HAVE CAUSE THE TIRE TO FALL OUT FROM UNDER THE TRUCK OR BUMPER WHICH WAS NOT CONNECTED ON DRIVERS SIDE BECAUSE OF RUST ALSO FRAME HAD TO BE REPAIRED THESE ARE THE REPAIRS I HAD DONE, REPLACED REAR FRAME SECTION FROM REAR AXLE SNUBBERS TO BUMPER, REPLACED REAR SHACKLES-REPLACED RIGHT SIDE REAR FRAME SHACKLE MOUNT REPAIRED CROSSMEMBER FOR GAS TANK RIGHT SIDE-REPAIR RIGHT FRONT FRAME RAIL ROUND CONTRO; ARM TO TRANS CROSSMEMBER COST WITH LABOR $973.69

FRAME IS RUSTING AWAY. BOTH REAR SHOCK MOUNTS. GAS TANK HOLDING STRAPS. BOTH CHASIS RAILS ARE RUSTING AWAY WITH BIG CHUNKS OF STEEL FALLING OFF. TRANS CROSS MEMBER RUSTING AWAY

CHASSIS IS SEVERELY RUSTED. YOU CAN BREAK CHUNKS OF METAL OFF WITH BARE HANDS.BOTH REAR SHOCK MOUNTS HAVE RUSTED OFF. STRAPS THAT HOLD GAS TANK HAVE RUSTED THROUGH. CROSS MEMBER HOLDING TRANNY IS SEVERELY RUSTED. GAS TANK FILL TUBE IS SEVERELY RUSTED GAS VAPOR RETURN TUBE RUSTED OFF. WHOLE CHASSIS. THE WHOLE FRAME IS SO RUSTED I AM AFRAID TO DRIVE THE TRUCK. TRUCK ONLY HAS 155,000 ON IT AND HAS ALWAYS BEEN MAINTAINED (HAVE ALL SERVICE RECORDS)

FRAME HAS EXCESSIVE RUST/CORROSION.

TL* THE CONTACT OWNS A 2001 FORD RANGER. UPON INSPECTION, THE CONTACT WAS INFORMED THAT THE VEHICLE FRAME EXPERIENCED SEVERE CORROSION. AS A RESULT, THE VEHICLE WAS NO LONGER OPERABLE. THE DEALER WAS NOT CONTACTED AND THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 82,000. *TT *TR

FRAME IS RUSTED BADLY AT POINTS WHERE CONTROL ARM CONNECTS TO FRAME AND CROSS MEMBERS WHERE HOLDS GAS TANK. BODY IS IN PERFECT CONDITION AND ONLY ISSUE IS IN THE FRAME . IT'S UNSAFE TO DRIVE ANY LONGER. IF CONTROL ARM BREAKS OFF THE FRAME COULD CAUSE SERIOUS INJURY OR DEATH TO PASSENGERS AND OTHERS ON HIGHWAY.

TL* THE CONTACT OWNS A 2001 FORD RANGER. WHILE DRIVING, ONE OF THE VEHICLE'S SPARE TIRES AND HALF OF THE REAR BUMPER DETACHED FROM THE VEHICLE. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THE FRONT FRAME WAS ROTTED. THE CONTACT STATED THAT THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO STATED THAT THE FRONT FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

BACK HALF OF FRAME RUST OUT CROSSMEMBERS AND GAS TANK BRACKET. BECOMES UNSAFE

REAR SPRING SHACKLES RUSTED SO BAD THEY BROKE APART AND STARTED TO COME THROUGH THE CARGO BED. NOW THE ENTIRE REAR SECTION OF THE FRAME IS SO RUSTED I AM AFRAID TO USE THE TRAILER HITCH. FRONT SECTION IS ALSO SEVERELY RUSTED. THIS TRUCK ONLY HAS 55000 MILES ON IT AND I AM AFRAID TO DRIVE IT. I HAVE OWNED FORDS ALL MY LIFE AND HAVE NEVER HAD AN ISSUE LIKE THIS BEFORE. I CAN UNDERSTAND SOME BOY PANEL RUST, BUT TO HAVE THE FRAME COMPLETELY DISINTEGRATE IS TOTALLY UNACCEPTABLE. FORD NEEDS TO BE REQUIRED TO FIX THESE TRUCKS OR BUY THEM BACK AT A FAIR MARKET VALUE.

BOUGHT A USED 2001 FORD RANGER AFTER DRIVING IT FOR A MONTH OR SO SHOCKS WERE REALLY BAD LOOKED UNDERNEATH TO FIND TWO CLEAN CRACKS THROUGH FROM NEAR BACK SHOCKS NOT SURE IF BAD SHOCKS ARE TO BLAME OR WEAK FRAME

SERIOUS STRUCTURAL FRAME RUST AFFECTING AREAS RELATED TO SUSPENSION (SHOCKS, BRACKETS/SHACKLES OF LEAF SPRING) WHILE THE REST OF THE TRUCK, INCLUDING THE BODY IS GENERALLY UNAFFECTED BY ANY SERIOUS RUST.

RUSTY FRAME,

TL* THE CONTACT OWNS A 2001 FORD RANGER. WHILE SERVICING THE VEHICLE, THE CONTACT NOTICED THAT THE FRAME WAS CORRODED AND FRACTURED. IN ADDITION, THE SUSPENSION WAS CORRODED. THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 58,000.

WAS CHANGING A BROKEN ADJUSTER ON REAR BRAKES AND NOTICED THE FRAME AT THE REAR SHOCK MOUNT HAS LARGE CRACKS IN IT ON BOTH SIDES. THE CONCERN IS THE STRESS PLACED ON THE CRACKED FRAME AS THAT IS WHERE MOST OF THE STRAIN IS PLACED. THAT PORTION OF THE FRAME HAS A BUNCH OF RUST CAUSING THE METAL TO PIT AND LIKELY WEAKEN. I'M SPECULATING THAT THE METAL USED WAS INFERIOR OR THAT THE SHOCK PLATE WAS MOUNTED IN WRONG LOCATION. THE FRAME WILL REQUIRE WELDING WHICH WILL NOT BE AS STRONG.

THE FRONT CROSS FRAME HAS RUSTED TO THE POINT OF BEING UNSAFE AS HAS THE REAR

SPARE TIRE ASSEMBLY RUSTED COMPLETELY TIRE AND FULL ASSEMBLY FELL OFF ON ON HIGHWAY CREATED A HAZARD AND ALMOST AN ACCIDENT. THE TRUCK WAS IN MOTION DOING ABOUT 50 MPH.

TO BEGIN WHEN I GOT THE TRUCK THE AIR BAG LIGHT WOULD NEVER GO OFF WHEN EVER I TURNED THEM ON AND OFF. WHICH MADE ME WONDER WEATHER THEY WERE EVER REALLY OFF AND CONSIDERING YOU CAN'T FIT A CAR SEAT IN THE BACK SEAT I HAD TO PUT IT IN THE FRONT SEAT. THEN WHEN MY WIFE WAS DRIVING THE SPARE TIRE FELL OFF THE TRUCK WHILE SHE WAS GOING DOWN THE ROAD. HERE RECENTLY SHE WAS DRIVING AND SOME ONE STOPPED HER TO TELL HER THAT SOMETHING FELL OFF THE TRUCK ABOUT 2 FOOT LONG. SHE CALLED ME AND SAID THE TRUCK WAS STILL RUNNING SO I TOLD HER TO JUST TRY AND MAKE IT HOME AND I WOULD LOOK AT IT BECAUSE I DIDN'T THINK IT WAS THAT SERIOUS. ONCE I STARTED LOOKING AT IT, A CANISTER HAD COME LOOSE FROM THE TRUCK BECAUSE THE FRAME BROKE...

WENT TO HAVE THE TRUCK INSPECTED WHEN THEY NOTICE THAT WHERE THE SPARE TIRE WENT IT WAS RUSTED THROUGH. THIS WAS ALL NOTICED WHEN THE TRUCK WAS SITTING STILL BEING INSPECTED

NOTED PIECE OF METAL DANGLING FROM REAR OF TRUCK. TOOK VEHICLE TO MY MECHANIC AND WAS SHOWN THAT DRIVER SIDE GAS TANK STRAP HAD RUSTED AWAY FROM MOUNTING BRACKET. TOURED UNDERNEATH VEHICLE WHILE IT WAS ON LIFT AND WAS ASTONISHED TO SEE THE RUST THRU ON ALL COMPONENTS OF UNDERBODY. FRAME, FUEL AND BRAKE LINES, MOUNTING BRACKETS ETC. MECHANIC UNABLE TO FIND A SECURE PART OF FRAME THAT WOULD HOLD TEMPORARY REPAIR. {AUTO BODY MECHANIC MADE TEMP REPAIR}. THE DETERIORATION OF THIS VEHICLE GOES WAY BEYOND NORMAL WEAR AND TEAR. I HAVE MAINTAINED THIS VEHICLE THROUGH ITS 80,000 MILES AND THE BODY AND PAINT LOOK PERFECT. IT IS A LIFE SAFETY CATASTROPHE WAITING TO HAPPEN. I BABIED THIS TRUCK AND PLANNED ON KEEPING IT MANY MORE YEARS. I CAN'T EVEN SELL IT NOW DUE TO COMPLETE DETERIORATION FROM PREMATURE RUSTING.

TL* THE CONTACT OWNS A 2001 FORD RANGER. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR OF THE VEHICLE. AFTER SERVICING THE VEHICLE, THE CONTACT DISCOVERED THAT THE REAR DRIVER SIDE FRAME WAS RUSTED AND CRACKED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 190,389. UPDATED 6/8/15*CN

THE ENTIRE FRAME HAS RUSTED OUT. REAR LEAF SPRINGS FRAME CROSS MEMBERS, CAB MOUNTS, I WOULD NEVER BUY ANOTHER FORD. *TR

FRAME SUPPORTING SPARE TIRE CARRIER FELL OFF CAUSING SPARE TO DRAG. ALSO HAVE IN THE PAST HAD BOTH REAR LEAF SPRING MOUNTS AND SHACKLES BREAK OFF THE FRAME TO EXCESSIVE ROT. *TR

ENTIRE FRAME RUSTED OUT-GAS TANK-REAR SHACKLES-BUMPER FELL OFF. *TR

I BOUGHT THIS 2001 FORD RANGER EDGE, REGULAR CAB FROM A DEALER IN CONNECTICUT. THE EXTERIOR BODY PANELS THEMSELVES LOOKS IMMACULATE NOT A SPOT OF RUST ANYWHERE, HOWEVER, AFTER I HAD DRIVEN HOME THE VEHICLE AND HAD MY FAMILY MECHANIC LOOK IT OVER HE DISCOVERED THERE ARE TWO LOCATIONS WHERE THE FRAME HAS COMPLETELY RUSTED/ ROTTED THROUGH (OVER 2 INCHES IN DIAMETER) ON THE DRIVER SIDE OF THE VEHICLE JUST IN FRONT OF THE REAR AXLE, ADJACENT TO THE GAS TANK. THIS VEHICLE ONLY HAS 89,000 MILES ON IT AND WAS VERY WELL CARED FOR. THIS MECHANIC THEN TOLD ME THAT THIS WILL EVENTUALLY LEAD TO THIS VEHICLE BEING UNSAFE TO DRIVE AND THAT THE VEHICLE IS BORDERLINE UNSAFE TO DRIVE IN ITS CURRENT CONDITION. *TR

TL* THE CONTACT OWNS A 2001 FORD RANGER. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE FRAME WAS SEVERELY RUSTED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO CONFIRMED THAT THE FRAME WAS PERFORATED DUE TO RUST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 151,238.

SYMPTOMS INCLUDED ENGINE STALL DURING HIGHWAY AND UPHILL DRIVING. STOPPED AT FUEL STATION TO FILL TANK; WHEN TANK APPROACHED FULL; SOUND OF STRUCTURAL FAILURE NOTED FOLLOWED BY LARGE FUEL SPILLAGE FROM TANK AREA (SATURATED TRUCK RT REAR UNDERBELLY, GROUND, REAR TIRE, MY SHOES AND LOWER PORTION OF PANTS). SUBSEQUENT INSPECTION REVEALED GAS TANK STRAP DETACHED FROM FRAME DUE TO SEVERE AND WIDESPREAD FRAME ROT. TANK APPARENTLY HANGING FROM REMAINING CORROSION DAMAGED STRAP AND FUEL FILLER NECK (CAUSED TANK TO TILT BACKWARDS; STARVING ENGINE OF FUEL DURING UPHILL OR DYNAMIC DRIVING). FUEL FILLER NECK WAS ALSO SEVERELY ROTTED AND FINALLY FAILED DURING FUEL FILL CAUSING ENTIRE TANK LOADED WITH 16 GALLONS FUEL TO BECOME DETACHED AT SHARP ANGLE. FOLLOWING INCIDENT; VEHICLE PROFESSIONALLY INSPECTED REVEALING EXTENSIVE FRAME AND SUSPENSION COMPONENT DISINTEGRATION DUE TO PREMATURE FAILURE OF FORD DESIGNED SUB-STANDARD MATERIALS. LARGE AREAS OF MATERIAL MISSING FROM BOTH FRONT FRAME MEMBERS (REAR OF...

BOUGHT THE TRUCK AND A FEW WEEKS OF DRIVING NOTICE THE BED WAS OFF CENTER. PUT TRUCK ON LIFE AND FOUND WHOLE FRAME IS RUSTED OUT. *TR

UNDERCARRIAGE AND FRAME HAS EXCESSIVE RUST PROBLEMS CAUSING PARTS ON FRAME TO FAIL AND FALL OFF. *TR

FAILED NYS INSPECTION DUE TO STRUCTURAL CRACKS IN FRAME. ADDITIONALLY THE BRACKET HOLDING ONE OF THE FUEL TANK STRAPS WAS COMPLETELY ROTTED AWAY LEAVING THE TANK SUSPENDED BY ONLY ONE STRAP. *TR

THE FRAME RUSTED OUT AND BENT OUT OF SHAPE IN THE REAR END. *TR

TL* THE CONTACT OWNS A 2001 FORD RANGER. AFTER EXAMINING THE VEHICLE, THE CONTACT NOTICED THAT THE ENTIRE FRAME AND SUB FRAME HAD CRACKED AND RUSTED THROUGH. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC ON SEVERAL OCCASIONS, WHERE THE LEAF SPRINGS WERE REPLACED EACH TIME. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 140,000. THE VIN WAS UNAVAILABLE.

REAR LEAF SPRING BRACKET HASEXSESSIVE AMOUT OF RUST AND WILL BREAK OFF. *TR

SINCE I HAVE OWNED THE VEHICLE I HAVE HAD MANY ISSUES WITH THE FRAME OF MY 2001 FORD RANGER EDGE. AT ONE POINT I WAS DRIVING DOWN THE ROAD AND I HEARD A LITTLE NOISE SO I STOPPED AND THE SPARE TIRE CAME ROLLING BY ME DOWN THE STREET. ONE OF MY LEAF SPRINGS CRACKED SO I HAD MY MECHANIC CHECK IT OUT AND HE SAID THE FRAME WAS ALL ROTTED OUT AND THAT THIS WAS VERY COMMON FOR THIS YEAR RANGER. HE SAID THE SHACKLES THAT HOLD ON THE LEAF SPRIG WERE BROKEN BECAUSE OF ROT. SO HE BRACED UP SOME AREAS WITH METAL AND INSTALLED NEW LEAF SPRINGS AND SHACKLES. THE BED OF THE TRUCK IS TILTED BECAUSE OF THE FRAME. I CANT GIVE YOU AN EXACT DATE THAT THIS FIRST HAPPENED BUT I BELIEVE IT IS AROUND THE DATE I PUT DOWN. I GET NERVOUS TOWING MY...

TL* THE CONTACT OWNS A 2001 FORD RANGER. THE CONTACT STATED THAT THE REAR FRAME WAS COMPLETELY CORRODED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO ADVISED THAT THE MATERIAL USED TO BUILD THE FRAME WAS DEFECTIVE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 120,000.

FRAME WAS NOTED TO HAVE SEVERE RUST DAMAGE TO REAR PORTION OF FRAME, HOWEVER,THE FRONT PORTION OFTHE FRAME DOES NOT SHOW SUCH DAMAGE. I HAVE DONE RESEARCH ON THIS ISSUE AND IT SEEMS TO BE SO COMMON THAT THERE IS AN AFTER MARKET FRAME REPAIR KIT FOR THIS SPECIFIC VEHICLE. THE TRUCK HAS NO OTHER ISSUES. I BELIEVE THAT IT SOULD NOT BE MUCH TO ASK TO HAVE DEFECT REPAIRED BY THE MANUFACTURER TO AVOID SAFETY ISSUES.

REAR FRAME ON RANGER IS RUSTING. THE SLOT WHERE THE GAS TANK STRAP HOOKS ON TO THE FRAME HAS RUSTED AWAY THIS CAUSED THE GAS TANK TO DROP THE WHOLE BACK FRAME LOOKS BAD. *TR

NOTICED MY TRUCK WAS SITTING CROOKED. TOOK IT TO REPAIR SHOP TO HAVE REPAIRED. ABOUT 2 HOURS AFTER I DROPPED IT OFF THE REPAIR SHOP CALLED MY PHONE AND ASKED ME TO COME TO THEIR SHOP. THE MECHANIC SHOWED ME THE RUSTED SPRING SHACKLES AND RUSTED SPRING HANGERS AND THE RUSTED FRAME. THIS SHOP WOULD NOT PUT MY TRAILER HITCH BACK ON BECAUSE HE SAID MY RUSTY FRAME WOULD NOT HOLD IT UP. I TOOK MY TRUCK BACK TO A FORD DEALER FOR THEM TO LOOK AT. THEY TOLD ME THAT THE TRUCK WAS PAID FOR, WARRANTY WAS OUT AND AS FAR AS THEY WERE CONCERNED THE PROBLEM WAS MINE. I TRIED TO TELL THE DEALER THAT THIS DIDN,T HAPPEN OVERNIGHT. HE DIDN,T CARE. I HAVE HAD PARTS OF THE FRAME PLATED SO IT WOULDN,T BREAK INTO. GAS TANK BRACKETS HAVE RUSTED OFF. MAIN FRONT CROSSMEMBER HAS RUST HOLES IN...