2001 FORD RANGER Fuelpropulsion System Problems

TAKATA RECALL. MY VEHICLE WAS STATIONARY WHEN I GOT TO WORK I NOTHING MY REAR BUMPER FELL OFF WITH NO GIVEN WARNING AND I DIDN'T HEAR IT HIT THE GROUND I GOT HOME AND LOOKED UNDER THE FRAME AND NOTICED THE WHOLE FRAME WAS ROTTEN AWAY AND IS NOT SAFE TO DRIVE

FRAME IS RUSTING AWAY. BOTH REAR SHOCK MOUNTS. GAS TANK HOLDING STRAPS. BOTH CHASIS RAILS ARE RUSTING AWAY WITH BIG CHUNKS OF STEEL FALLING OFF. TRANS CROSS MEMBER RUSTING AWAY

CHASSIS IS SEVERELY RUSTED. YOU CAN BREAK CHUNKS OF METAL OFF WITH BARE HANDS.BOTH REAR SHOCK MOUNTS HAVE RUSTED OFF. STRAPS THAT HOLD GAS TANK HAVE RUSTED THROUGH. CROSS MEMBER HOLDING TRANNY IS SEVERELY RUSTED. GAS TANK FILL TUBE IS SEVERELY RUSTED GAS VAPOR RETURN TUBE RUSTED OFF. WHOLE CHASSIS. THE WHOLE FRAME IS SO RUSTED I AM AFRAID TO DRIVE THE TRUCK. TRUCK ONLY HAS 155,000 ON IT AND HAS ALWAYS BEEN MAINTAINED (HAVE ALL SERVICE RECORDS)

NOTED PIECE OF METAL DANGLING FROM REAR OF TRUCK. TOOK VEHICLE TO MY MECHANIC AND WAS SHOWN THAT DRIVER SIDE GAS TANK STRAP HAD RUSTED AWAY FROM MOUNTING BRACKET. TOURED UNDERNEATH VEHICLE WHILE IT WAS ON LIFT AND WAS ASTONISHED TO SEE THE RUST THRU ON ALL COMPONENTS OF UNDERBODY. FRAME, FUEL AND BRAKE LINES, MOUNTING BRACKETS ETC. MECHANIC UNABLE TO FIND A SECURE PART OF FRAME THAT WOULD HOLD TEMPORARY REPAIR. {AUTO BODY MECHANIC MADE TEMP REPAIR}. THE DETERIORATION OF THIS VEHICLE GOES WAY BEYOND NORMAL WEAR AND TEAR. I HAVE MAINTAINED THIS VEHICLE THROUGH ITS 80,000 MILES AND THE BODY AND PAINT LOOK PERFECT. IT IS A LIFE SAFETY CATASTROPHE WAITING TO HAPPEN. I BABIED THIS TRUCK AND PLANNED ON KEEPING IT MANY MORE YEARS. I CAN'T EVEN SELL IT NOW DUE TO COMPLETE DETERIORATION FROM PREMATURE RUSTING.

THE GAS TANK SUPPORT WHICH WAS A PART OF THE FRAME RUSTED OFF. *TR

ENTIRE FRAME RUSTED OUT-GAS TANK-REAR SHACKLES-BUMPER FELL OFF. *TR

I PURCHASED A 2001 FORD RANGER ON FEBRUARY 3RD 2014 FROM COLUMBUS AUTO BODY RESALE. WE TOOK THE VEHICLE IN TO REPAIR THE TIRE TO FIND OUT THE GAS TANK WAS HANGING OFF THE TRUCK AND COULD NOT INSTALL THE GAS TANK STRAPS TO SECURE THE GAS TANK BECAUSE THE FRAME IS TO RUSTED. THE TRUCK IS UNSAFE TO DRIVE. *TR

THE RIGHT REAR LEAF SPRING SHACKEL BROKE OFF FROM THE FRAME DUE TO RUST. THE SPARE TIRE CARRIER FAILED DUE TO RUST AND CAUSED THE SPARE TIRE TO DROP. THE STEEL SHIELD UNDER THE GAS TANK DROPPED DOWN DUE TO RUST. *TR

SYMPTOMS INCLUDED ENGINE STALL DURING HIGHWAY AND UPHILL DRIVING. STOPPED AT FUEL STATION TO FILL TANK; WHEN TANK APPROACHED FULL; SOUND OF STRUCTURAL FAILURE NOTED FOLLOWED BY LARGE FUEL SPILLAGE FROM TANK AREA (SATURATED TRUCK RT REAR UNDERBELLY, GROUND, REAR TIRE, MY SHOES AND LOWER PORTION OF PANTS). SUBSEQUENT INSPECTION REVEALED GAS TANK STRAP DETACHED FROM FRAME DUE TO SEVERE AND WIDESPREAD FRAME ROT. TANK APPARENTLY HANGING FROM REMAINING CORROSION DAMAGED STRAP AND FUEL FILLER NECK (CAUSED TANK TO TILT BACKWARDS; STARVING ENGINE OF FUEL DURING UPHILL OR DYNAMIC DRIVING). FUEL FILLER NECK WAS ALSO SEVERELY ROTTED AND FINALLY FAILED DURING FUEL FILL CAUSING ENTIRE TANK LOADED WITH 16 GALLONS FUEL TO BECOME DETACHED AT SHARP ANGLE. FOLLOWING INCIDENT; VEHICLE PROFESSIONALLY INSPECTED REVEALING EXTENSIVE FRAME AND SUSPENSION COMPONENT DISINTEGRATION DUE TO PREMATURE FAILURE OF FORD DESIGNED SUB-STANDARD MATERIALS. LARGE AREAS OF MATERIAL MISSING FROM BOTH FRONT FRAME MEMBERS (REAR OF...