2001 FORD RANGER Power Trainautomatic Transmission Problems

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) I WAS DRIVING MY FORD RANGER, (2001 XLT AUTOMATIC TRANSMISSION) IN AN ATTEMPT TO WARM UP THE TRUCK AS THE TRANSMISSION HAD BEEN ACTING UP AS IT WAS NOT SHIFTING AS WELL AS IT SHOULD INTO HIGHER GEARS. THE TRUCK WAS HAVING TROUBLE GOING PAST 10-15 MPH BEFORE SHIFTING GEARS AND WAS GOING MUCH SLOWER THAN NORMAL. AS I DROVE AROUND THE PARKING LOT WHERE I WORK TO WARM UP THE TRUCK, IT WAS NOT GOING AS FAST AS NORMAL AND IT WARMED UP IN ABOUT 20 MINUTES. I CHECKED THE TRANSMISSION FLUID AND IT WAS AT A NORMAL LEVEL. I TURNED OFF THE TRUCK AND CHECKED THE OIL WHICH WAS IN THE NORMAL RANGE. I PROCEEDED TO GO TO QT AND GET SOME GAS AND ON MY WAY BACK TO WORK, I WENT TO STOP AT...

TRANS SHIFT PROBLEM 1ST TO 2ND SHIFT HARD SHIFT STARTED ABOUT 3 MONTHS AGO 2001 FORD RANGER 4X4 ,STARTED ONLY DOING IT ON COLD STARTS NOW DOES IT ALL THE TIME COLD OR HOT HAVE TO LET OFF ACCELERATOR TO GET TO SHIFT OR MANUALLY SHIFT FROM SHIFT LEVER.OVERDRIVE LIGHT FLASHES AS SOON AS IT SLAMS INTO GEAR ,TRANS SLIP. FORD HAS HAD ON GOING PROBLEMS WITH TRANS. BEEN A AUTO TECH FOR FORD FOR MANY YEARS ITS TIME TO HAVE FORD LOOK AT THE ON GOING PROBLEMS. *TR

BOUGHT 2001 FORD RANGER IN 2005, 18 MONTHS LATER GEARBOX NEEDED REBUILD DUE TO LOSS OF GEAR SELECTION ON AUTO BOX. STILL THE GEARS SOMETIMES DO NOT ENGAGE AND THE O/D LIGHT COMES ON AND GEAR CHANGES ARE ROUGH. I BELIEVE THIS IS A DEFECT IN THE TRANSMISSION FROM WHAT I HAVE READ. *TR

AFTER LOOSING THE BATTERY (POWER LOSS) MY 4X4CM (4WD CONTROL MODULE) WENT BAD ON MY 2001 RANGER 4X4 TRUCK. THIS CAUSED MY 4WD TO NOT FUNCTION AT ALL. I HAD TO REPLACE THE 4X4CM WITH A BRAND NEW ONE. FORD HAS UPDATED THE PART. THE ORIGINAL PART NUMBER IS 1L54-7H417-AC AND THE NEW UPDATED PART NUMBER IS 1L5Z-7E453-AC. *TR

TL*THE CONTACT OWNS A 2001 FORD RANGER. AFTER THE CONTACTS VEHICLE WAS REPAIRED UNDER THE SPEED CONTROL RECALL, THE TRANSMISSION BEGAN TO FAIL. WHILE DRIVING BETWEEN 50 AND 55 MPH, THE TRANSMISSION AUTOMATICALLY SHIFTS INTO NEUTRAL AND THE ENGINE REVS. THE VEHICLE ALSO SHIFTS INTO NEUTRAL WHENEVER THE CRUISE CONTROL IS ENGAGED. THE VEHICLE HAS BEEN TO THE DEALER TWICE REGARDING THIS FAILURE. THE DEALER STATED THAT THE SPEED CONTROL RECALL REPAIR WAS NOT THE CAUSE OF THE TRANSMISSION FAILURE. THEY STATED THAT HE NEEDED A NEW TRANSMISSION, WHICH WILL COST $1,300. THE NHTSA RECALL ID NUMBER FOR THE SPEED CONTROL WAS UNKNOWN. THE CURRENT MILEAGE WAS 66,100 AND FAILURE MILEAGE WAS 65,800. UPDATED 09/25/07 *TR

I WAS DRIVING TO WORK ONE MORNING, AND THE O/D LIGHT (OVER DRIVE LIGHT) STARTED TO FLASH ON MY 2001 FORD RANGER XLT 4.0 V-6 4X4 TRUCK. I HAD NO IDEA IN WHAT THAT MEANT. I DROVE TO WORK, I CALLED AROUND AND THAT IS A TROUBLE CONDITION ON THE TRANSMISSION, I SAID ON THE TRANNY IT ONLY HAS 73 THOUSAND MILES ON IT. I WAS SURPRISED, AND THE TRUCK IS VERY WELL KEPT UP. I TOOK IT A WELL KNOW TRANSMISSION PLACE TO HAVE IT LOOKED AT, AND TEST DROVE, ALONG WITH THE COMPUTER CHECK, AND IT CAME BACK WITH A READING "INCORRECT GEAR RATIO ON 3". I WAS LIKE WHAT IS THAT, HE SAID THAT IS UGLY. SO I TOOK IT AND GOT 2 MORE INQUIRIES, AND 1 FROM A DEALERSHIP. ALL THE SAME 3 RD GEAR TROUBLE. I CONTACTED FORD, AND SPOKE TO HEATHER, AND NEEDLESS TO...

TRANSMISSION FAILURE; 2001 FORD RANGER EDGE- HAVE HAD PROBLEMS WITH PRIOR TO WARRANTY EXPIRING. A TSB FOR THE INITIAL PROBLEM WAS PERFORMED BY THE DEALER, BUT THE PROBLEM PERSISTED AND WHEN ANALYZED, THE SAME ERROR CODE CAME UP. *NM

AUTOMATIC TRANSMISSION STARTED SHIFTING HARD, OVERDRIVE OFF WARNING LIGHT CAME ON AND STARTED FLASHING. TOOK CAR TO DEALER AND THEY SAID TRANSMISSION WAS BAD. THIS VEHICLE ONLY HAS 79000 MILES ON IT. SHOWED THEM MAINT. RECORDS, THEY SAID THERE WAS NOTHING THEY COULD DO. $2800 REPAIR BILL FOR NEW TRANSMISSION. *NM

DT: CONTACT STATES: SHE BOUGHT A BRAND NEW FORD RANGER IN 2000 AND SHE HAS HAD TO PUT 2 TRANSMISSIONS AND 2 TORQUE CONVERTERS ON THE VEHICLE WITHIN 70,000 MILES. THE DEALER SAID THERE WAS NOTHING THEY WERE GOING TO DO ABOUT IT. SHE WROTE A LETTER TO THE PRESIDENT OF FORD AND TO THE NEW MOTOR VEHICLE BOARD AND TO CONSUMER AFFAIRS. SHE HAS TALKED TO CONSUMER AFFAIRS AT FORD. SHE HAS ALSO TALKED TO THE REPRESENTATIVE IN DEARBORN MI. THERE WAS 34,000 MILES ON THE FIRST TRANSMISSION SHE REPLACED. THE SECOND TRANSMISSION WAS REBUILT. *NM THE CONSUMER BEGAN TO FEEL A SLIPPING SENSATION WHEN GOING UP AN INCLINE. THE BRAKES WERE REPLACED.*JB

CONSUMER STATED: THERE WAS A RATTLING NOISE, PRIMARILY IN THE POWER TRAIN AREA, IT MADE NOISE WHEN THE ACCELERATOR WAS APPLIED. IT WOULD HAPPEN WHEN THE CONSUMER REACHED UP TO 2000 RMP'S. *JB

FORD RANGER XLT 2001 TRANSMISSION PROBLEMS. I HAVE OWNED THIS VEHICLE FROM NEW AND NOW JUST OUTSIDE OF WARRANTY BASED ON MILEAGE, THE TRANSMISSION IS NEEDING REBUILDING OR REPLACEMENT. THE VEHICLE HAS ONLY 38412 MILES TOTAL ON IT, WARRANTY COVERAGE ONLY LASTS UNTIL 36000 MILES OR 3 YEARS. VEHICLE WAS PURCHASED IN AUGUST OF 2001. NO SPECIAL OPERATING CONDITIONS HAVE EXISTED FOR THIS VEHICLE (I.E. TOWING, HEAVY EQUIPMENT OR ITEM HAULING). THIS VEHICLE BEGAN VERY EARLY SATURDAY APRIL 10, 2004 FLASHING THE O/D OFF INDICATOR LIGHT ON THE DASH PANEL. I TOOK THIS VEHICLE TO A LOCAL FORD DEALERSHIP WHERE THEY INDICATED THAT THE OBDII SYSTEM WAS REGISTERING 3 DIFFERENT CODES HAVING TO DO WITH THE POWERTRAIN SYSTEM. THE CODES REGISTERING WERE P0731, P0733 AND P0735. ACCORDING TO THE SERVICE TECHNICIAN WHO WAS WORKING ON THE VEHICLE THERE IS A TBS FOR THE CODE P0733 REGISTERING. THE SERVICE MANAGER WHO...

I HAVE A 01 RANGER 4X4 WITH 4.0L ENGINE AND 4.10 REAR END. I CONTINUE TO HAVE AN INTERMITANT SHUDDER PROBLEM FROM 1-2 AND THEN AGAIN FROM 3-4 (AROUND 2500 RPMS) AND 4-5 (AROUND 2100 RPMS). I HAVE HAD THE TRANSMISSION SERVICED SEVERAL TIMES AND HAD THE FOLLOWING REPAIRS PERFORMED: 1. REPLACED DRIVESHAFT 2. OVERHAUL VALVE BODY 3. PCM REPROGRAMMED 4. REPLACED VALVE BODY 5. REPLACED VALVE BODY AGAIN 6. OVERHAULED TRANSMISSION REPLACE OVERDRIVE DRUM DUE TO AN UNEVEN SURFACE SO FAR, I HAVE HAD OVER $2,500 IN REPAIRS (ALL UNDER WARRANTY LUCKILY). HOWEVER, THE SHUDDER IS STILL THERE, ALTHOUGH IT IS NOT AS HARSH AS IT ONCE WAS. A NEW PROBLEM HAS BEGUN IN THE LAST FEW WEEKS, NOW WHEN YOU PUT IT IN GEAR, IT TAKES SEVERAL SECONDS BEFORE IT ENGAGES. IN FACT, YOU CAN SIT THERE WITH YOUR FOOT ON THE GAS AND IT WON'T GO. ONCE...

THE AUTOMATIC TRANSMISSION PERFORMED ERRATICLY. TRANSMISSION HAD A TENDENCY TO NOT SHIFT INTO OVERDRIVE UPON COLD A START. AFTER SEVERAL MINUTES OF OPERATION, THE TRANSMISSIONS PERFORMED NORMAL. PLEASE DESCRIBE DETAILS. *PH

THE CONSUMER HAD PROBLEMS WITH ENGINE ACCELERATION. IT HAPPENED AT DIFFERENT TIMES. DEALER WAS CONTACTED, AND STATED THEY WERE NOT ABLE TO FIND ANYTHING WRONG WITH VEHICLE. *AK CONSUMER ADDED, THE TRANSMISSION SHIFTED BEFORE THE VEHICLE ACCELERATED UNCONTROLLABLY. *TT *JB

THIS COMPLAINT IS ABOUT A FORD RANGER EDGE SUPERCAB 4X4. I HAVE HAD THIS TRUCK BARELY OVER 2 YEARS AND IT HAS 45,000 MILES ON IT. ABOUT ONE YEAR AFTER PURCHASING THE VEHICLE I STARTED HAVING TRANSMISSION PROBLEMS, THE "OVERDRIVE OFF" LIGHT FLASHING AND FUNNY SHIFTS FROM FIRST INTO SECOND AS WELL AS A HESITANT ACCELERATION FOLLOWED BY A SMALL JERK. I TOOK IT IN TO HAVE IT FIXED AND APPARENTLY IT WAS. ABOUT 3 MONTHS LATER THE TRANSMISSION STARTED ACTING UP AGAIN IN THE SAME FASHION. I TOOK IT IN AND ONCE AGAIN THOUGHT IT WAS FIXED UNTIL A FEW MONTHS LATER IT STARTED DOING THE SAME THING. BY THIS TIME SINCE I THOUGHT THE TRUCK WAS FINALLY FIXED I DECIDED TO ADD A 4" SUSPENSION LIFT AND 33" TIRES. WHEN I TOOK IT IN THEY TOLD ME I NEED EITHER A NEW TRANSMISSION OR TO HAVE THIS ONE...

CONSUMER STATES THE VEHICLE EXPERIENCED TRANSMISSION PROBLEMS. *SLC

THE TIRES HAVE BEEN A PROBLEM EVER SINCE I BOUGHT THE CAR. I HAVE ASKED THE DEALER TO REPLACE THEM TO NO EVAIL. THE BATTERY WENT OUT, THE POWER WINDOW ON THE DRIVER SIDE DIED, THE BRAKES HAVE BEEN REPAIRED TWICE THE SEAT BELTS ON BOTH DRIVER AND PASSANGER SEATS REPLACED THE TRAMISSION HAS GONE OUT TWICE THE COMPUTER/BRAIN TO RUN THE TRUCK HAS GONE OUT THREE TIMES. I DONT THINK I CAN TAKE THIS TRUCK BREAKING DOWN ALL THE TIME FOR TO MUCH LONGER. IAM IN A RENTAL CAR MORE THEN IN MY TRUCK. HELP. *AK (DOT NUMBER: W2UU IFO TIRESIZE: P225/70R15)

I HAVE HAD THIS TRUCK FOR ONLY ONE YEAR AND HAVE HAD MANY PROBLEMS. FIRST THE TRANSMISSION WENT BEACAUSE IT WOULD NOT GO PAST 2ND GEAR AND THE OVERDRIVE LIGHT WAS FLASHING. IT WAS FOUND TO BE INTERNAL PARTS AND EXTERNAL WIRING OF THE TRANSMISSION. THAT SAME DAY THE ALTERNATOR WENT AND LEFT ME WITH A DEAD BATTERY. I HAVE TAKEN IT INTO THE DEALER ABOUT 3 TIMES FOR ROUGH IDLE AND HAVE BEEN TURNED AWAY SAYING THE CANNOT FEEL ANYTHING AND THAT NOT TO WORRY BECAUSE ITS STILL UNDER WARRANTY. TWICE I HAVE TAKEN IT IN FOR THE FRONT SUSPENSION DUE TO A VIBRATION TO THE STEERING WHEEL AND TRUCK. ALL ROTORS WERE TURNED AND THE FRONT WAS REALLINED. ALSO THE TRUCK SEEMS TO GO THROUGH GAS A BIT TOO QUICKLY, JUST ABOUT A BIT OVER A QUARTER TANK FOR EVERY 10-15 MILES.*AK

I HAVE HAD THIS TRUCK FOR ONLY ONE YEAR AND HAVE HAD MANY PROBLEMS. FIRST THE TRANSMISSION WENT BEACAUSE IT WOULD NOT GO PAST 2ND GEAR AND THE OVERDRIVE LIGHT WAS FLASHING. IT WAS FOUND TO BE INTERNAL PARTS AND EXTERNAL WIRING OF THE TRANSMISSION. THAT SAME DAY THE ALTERNATOR WENT AND LEFT ME WITH A DEAD BATTERY. I HAVE TAKEN IT INTO THE DEALER ABOUT 3 TIMES FOR ROUGH IDLE AND HAVE BEEN TURNED AWAY SAYING THE CANNOT FEEL ANYTHING AND THAT NOT TO WORRY BECAUSE ITS STILL UNDER WARRANTY. TWICE I HAVE TAKEN IT IN FOR THE FRONT SUSPENSION DUE TO A VIBRATION TO THE STEERING WHEEL AND TRUCK. ALL ROTORS WERE TURNED AND THE FRONT WAS REALLINED. ALSO THE TRUCK SEEMS TO GO THROUGH GAS A BIT TOO QUICKLY, JUST ABOUT A BIT OVER A QUARTER TANK FOR EVERY 10-15 MILES.*AK

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

VEHICLE HAS NO SECOND GEAR. CONSUMER QUESTIONED DEALER, WHO INFORMED HIM THAT WAS HOW VEHICLE WAS DESIGNED.*AK

WHILE DRIVING BETWEEN MY JOB IN BUFFALO, NY, AND MY HOME IN LEXINGTON, OH, I SUFFERED A COMPLETE TRANSMISSION FAILURE AND WAS FORCED TO LIMP INTO A LOCAL FORD TRUCK SALES PLACE. THE FAILURE OCCURRED WITHOUT ANY ADVANCED WARNING AND LEFT ME LIMPING ALONG AT ABOUT 35-40 MPH ON THE I-90 THRUWAY DURING RUSH HOUR WITH HEAVY TRAFFIC TRAVELING 65-70 MPH. BY THE TIME I TRAVELED THE APPROXIMATE 10 MILES, I HAD TOTALLY LOST REVERSE GEAR AND HAD SUBSTANTIAL SLIPPAGE OCCURING IN FORWARD GEARS. MECHANICS INSPECTED THE TRANSMISSION AND DISCOVERED SEVERE DAMAGE TO THE TRANSMISSION REQUIRING IT TO BE REPLACED. FORD TECH CONSULTANTS REVEALED THAT THIS IS HAPPENING TO MANY FORD RANGERS, BUT NO RECALL HAS BEEN ISSUED. APPARENTLY, THE TORQUE ON THE TRANSMISSION WAS INCREASED WITHOUT REDESIGNING THE TRANSMISSION OR SEALS TO BE ABLE TO WITHSTAND THE HIGHER TORQUE. THEREFORE, TRANSMISSION SEALS ARE FAILING UNDER USE, LEADING TO SEVERE...