2005 FORD FOCUS Electrical System Problems

FUSE CONTINUED TO BLOW OUT CAUSING ENTIRE LEFT SIDE OF LIGHTS FROM FRONT TO BACK TO TURN OFF UNTIL NEW FUSE REPLACED OLD. WAS CONNECTED TO CONTINUED LIFTING OF HATCHBACK ON WAGON MODEL. ELECTRICAL HARNESS WAS ARCING AND INSULATION FLAKING OFF AND WOULD HAVE CAUSED A FIRE HAD NOT THE HARNESS BEEN REPLACED. THIS HAD BEEN ON AND OFF FOR APPROXIMATELY 2 YEARS STARTING WITH BLOWING OUT THE BULBS THEN THE FUSE STARTED BLOWING OUT IN JAN 2021. MIDAS REPLACED HARNESS THIS MARCH. CAR IS A 2005 FOCUS WAGON,

TODAY MY ACCELERATOR GOT STUCK WHEN PULLING INTO A PARKING LOT WITH MY KIDS. I WAS LUCKILY NOT GOING MORE THAN 10MPH AND WAS ABLE TO QUICKLY PUT THE CAR INTO NEUTRAL AND STOP THE CAR WITHOUT HITTING ANYONE OR ANYTHING. EARLIER IN THE DAY I NOTICED IT TOOK A LITTLE MORE EFFORT TO PUSH THE GAS PEDAL DOWN, BUT NOT BY MUCH AND AFTER THE CAR RESTING FOR SEVERAL HOURS, IT WASN'T AN ISSUE ANYMORE. I WASN'T EXPECTING IT TO BE AN ISSUE LATER ON. AS FAR AS ELECTRICAL ISSUES GO; MY HEADLIGHTS DO NOT LIKE TO STAY ON. I HAVE TO PLAY WITH THE WIRES WHERE THEY CONNECT TO THE HEADLIGHTS IN ORDER FOR THEM TO TURN ON, BUT THEY OFTEN DO NOT STAY ON, AND THEY FREQUENTLY WILL TURN OFF AND ON WHILE DRIVING, SOMETIMES IT'S JUST ONE SIDE, OR ALTERNATING SIDES. THIS HAS BEEN AN ISSUE...

THE BACKSEAT DOORS WILL NOT LATCH AND OR LOCK. THEY HAVE TO BE HELD TOGETHER WITH ZIP TIES. THE RANDOMLY OPENED WHILE I WAS DRIVING DOWN THE ROAD. THIS IS A SERIOUS SAFETY CONCERN, AS I CANNOT USE MY CARE TO TRANSPORT MY CHILD. I KNOW OTHER VERSIONS OF THIS SAME VEHICLE HAVE HAD A SAFETY RECALL ISSUED FOR THIS, AND I AM CURIOUS AS TO WHY MY SPECIFIC MODEL WAS LEFT OUT WHEN I AM EXPERIENCING THE SAME PROBLEMS. THIS CAR IS NO LONGER DRIVEABLE.

THE ICON SEAT BELT INDICATOR COMES AND GOES AS LIT AND THEN SOME TIMES IT IS NOT VISIBLE WHEN VEHICLE IS IN MOTION (ENGINE RUNNING).

THE WIRING BETWEEN THE HATCH DOOR AND THE BODY IS DETERIORATED WITH A BROKEN WIRE FOR THE LICENSE PLATE LIGHT AND THE INSULATION CRACKED AND MISSING ON MANY OF THE OTHER WIRES. THIS IS A REAL HAZARD AS SHORTS COULD OCCUR AFFECTING ALL THE REAR LIGHTS THAT ARE CONTROLLED WITH THESE WIRES. LUCKILY I READ ON A YOUTUBE REPORT ABOUT THIS PROBLEM. I DETECTED THE PROBLEM WITH THE VEHICLE PARKED IN MY GARAGE WHILE INVESTIGATING THE LIGHTING PROBLEM.

TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED THAT THE MASTER KEY FAILED TO FUNCTION PROPERLY WHEN ATTEMPTING TO LOCK AND UNLOCK THE VEHICLE. AS A RESULT, THE CONTACT CONSTANTLY HAD TO USE THE KEY FOB. ALSO, DURING INCLEMENT WEATHER BELOW 30 DEGREES, THE VEHICLE WAS EXTREMELY HESITANT. THE CONTACT HAD TO WAIT FOR A MOMENT TO ENSURE THAT THE VEHICLE WOULD START AND NOT SHUT OFF. THE CONTACT ALSO HEARD AN ABNORMAL NOISE COMING FROM THE ENGINE AREA. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC, BUT THE CAUSE OF THE FAILURES WAS UNKNOWN. SCHICKER FORD (3300 S KINGS HIGHWAY, ST. LOUIS, MISSOURI 63139, (314) 664-4100) WAS CONTACTED, BUT DID NOT DIAGNOSE THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

HATCHBACK WIRING HARNESS BETWEEN BODY AND HATCHBACK, HAS MULTIPLE WIRE INSULATION FAILURE AND WIRE BREAKAGE CAUSING FUSES TO BLOW AND NON-FUNCTIONING PARKING LIGHTS, REVERSE LIGHTS, BREAK LIGHTS, INSTRUMENT COLUMN LIGHTS, AND UNCONTROLLED RELEASE OF ELECTRICAL TRUNK WHILE DRIVING.

THROUGHOUT MY OWNERSHIP OF 2005 FORD FOCUS WAGON SES ZXW, I HAVE HAD PERIODIC ISSUES WITH THE REAR HATCH UNLATCHING ON ITS OWN. I WILL UNLATCH WHILE DRIVING ON THE HIGHWAY. SOMETIMES IT WILL UNLATCH WHEN DEPRESSING THE BRAKE PEDAL. ALTHOUGH IT WILL UNLATCH UPON THE START OF A TRIP AT SLOW SPEEDS AS WELL, IT HAS MOSTLY OCCURRED ON THE HIGHWAY. I HAVE OWNED THE VEHICLE SINCE 2007. THE PROBLEM WOULD OCCUR PERIODICALLY 3-7 TIMES EVERY 1-1.5 YEARS SINCE THE 2008-2009. THE PROBLEM DEFINITELY OCCURS UNDER A DAMP AND MORNING DEW CONDITION. IT'S LIKE AN ELECTRICAL SHORT HAS OCCURRED I MY VEHICLE. THE LATCH STOPPED WORKING IN 2009 VIA THE PUSH BUTTON IN THE DASH AND EVEN WITH MY REMOTE KEY. I CHECKED THE FUSE PANEL ... AND IT WAS NOT BLOWN. THIS CONDITION MOSTLY OCCURS WHILE THE VEHICLE IS IN MOTION.

FIRST ISSUE: ON SEVERAL OCCASIONS, WHEN STOPPING THE CAR, PARKING, AND ATTEMPTING TO REMOVE THE KEY, THE KEY HAS BECOME STUCK IN THE IGNITION AND CANNOT REMOVE IT--- SOMETIMES FOR A FEW DAYS, OTHER TIMES FOR A FEW WEEKS, AT WHICH TIME IT SIMPLY COMES OUT WHEN ATTEMPT IS MADE. SECOND ISSUE: GEARS OCCASIONALLY SLIP UPON ACCELERATING, RESULTING IN FINALLY SLAMMING INTO GEAR.

ON MANY OCCASIONS THE REAR HATCH (ZXW WAGON) HAS OPENED ON ITS OWN. I'VE ALWAYS ASSUMED I MUST NOT HAVE CLOSED IT PROPERLY AS IT ALSO HAS NOT LATCHED ON MANY OCCASIONS WHEN CLOSING IT. SOMETIMES IT CAN TAKE SEVERAL ATTEMPTS, CLOSING IT FIRMLY. ONE THE MOST RECENT OCCASSION OF THE HATCH OPENING WHILE DRIVING OUR DOG WAS IN THE CAR BAG CARGO AREA, SO YOU CAN IMAGINE MY ANGER AT THE LATCH. ANOTHER ISSUE HAS BEEN THE LICENCE PLATE LIGHTS NOT ILLUMINATING THE PLATE AT NIGHT, WHICH HAS RESULTED IN A STOP BY AN OFFICER. YESTERDAY, MAY 18TH 2017, THE BATTERY LIGHT ILLUMINATED FOR ABOUT 2 MINUTES ON MY DRIVE HOME, THEN WENT OFF. WHEN I GOT HOME I PUT A METER ON THE BATTERY WHILE THE ENGINE WAS RUNNING AND GOT 12.04-12.7 VOLTS. WHILE SEARCHING YOUTUBE FOR SOME HOW-TO ALTERNATOR VIDEOS I STUMBLED ACROSS A VIDEO THAT SPOKE...

TAKATA RECALL CAR RANDOMLY SHUTS OFF BUT RADIO IS STILL ON AT STOP LIGHT. I PUT IT ON NUETRAL AND IT STARTS BACK UP NO PROBLEM.

TL* THE CONTACT OWNS A 2005 FORD FOCUS. WHILE DRIVING 25 MPH, THE DOOR AJAR WARNING LIGHT ILLUMINATED WITH NO INDICATION AS TO WHICH DOOR WAS AFFECTED. THE CONTACT MENTIONED THAT ALL DOORS WERE PROPERLY CLOSED WHEN THE FAILURE OCCURRED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE FAILURE WAS UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2005 FORD FOCUS. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE PULLED WITHOUT WARNING. THE CONTACT WAS UNABLE TO OPEN THE FRONT PASSENGER AND DRIVER DOORS FROM OUTSIDE THE VEHICLE. THE REAR PASSENGER DOOR FAILED TO OPEN. THE REAR DRIVER SIDE DOOR HANDLE WAS SLIGHTLY DETACHED. THE ELECTRICAL WARNING LIGHT WAS ILLUMINATED. A CERTIFIED MECHANIC STATED THAT THE TIE RODS AND WHEEL WELL NEEDED TO BE REPLACED, AND THE RACK AND PINION TIGHTENED. THE TIE ROD AND WHEEL WELL WERE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 9,000.

TL* THE CONTACT OWNS A 2005 FORD FOCUS. WHILE STOPPED AT AN INTERSECTION, THE VEHICLE SHUT OFF AND LOST ALL POWER WITHOUT WARNING. THE CONTACT HEARD A CLICKING NOISE FROM THE STEERING RACK. THE CONTACT CALLED ROADSIDE ASSISTANCE; HOWEVER, THE VEHICLE RESTARTED AFTER THE TOW TRUCK DRIVER SHOOK THE BATTERY A COUPLE OF TIMES. THE CONTACT DROVE HOME. THE FAILURE RECURRED A FEW DAYS LATER AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS A RECALL FOR NHTSA CAMPAIGN NUMBER: 05V030000 (LATCHES/LOCKS/LINKAGES). THE MANUFACTURER STATED THAT THERE WAS NO RECALL FOR THE FAILURE AND REFERRED THE CONTACT TO NHTSA TO FILE A COMPLAINT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 150,000. UPDATED 04/22/16*LJ THE CONSUMER STATED THE RADIO WOULD INTERMITTENTLY TURN ON THEN OFF, THE BATTERY CABLE MUST...

THE FORD ZXW WAGON'S LIFTGATE WIRING HARNESS HAD FRAYED INSIDE THE RUBBER HOUSING AT THE JUNCTION WHERE THE GATE PIVOTS BETWEEN THE CAR BODY AND LIFTGATE. THE WIRES SHORTED WHICH CAUSED THE ELECTRIC GATE RELEASE TO OPEN AT 70MPH, WHILE DRIVING STRAIGHT ON A FREEWAY. THE LIFTGATE ROSE UP, OPENING THE BACK OF THE CARGO AREA TO TRAFFIC. LUCKILY FREEWAY SPEED WINDS KEPT IT FROM COMPLETELY OPENING, BUT WHEN SLOWED TO 30MPH IT WENT STRAIGHT UP. I'M LUCKY I HAD NO CHILDREN OR ANIMALS IN THE BACK CARGO AREA. AND THE FELLOW DRIVERS ON THE ROAD WERE LUCKY NOTHING SHIFTED AND FELL OUT. THE LIFTGATE REFUSED TO LATCH AFTER THIS POINT, MAKING DRIVING THE CAR SAFELY IMPOSSIBLE. IN RESEARCHING THE CAUSE AND REPAIR, I NOTICED SEVERAL FORUMS WHERE AN IDENTICAL PROBLEM WITH FORD'S DESIGN WAS POSTED. THE REPLACEMENT BILL AT A FORD DEALERSHIP WAS AROUND $1,200, NOT INCLUDING MY TIME...

TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED THAT THE IGNITION KEY WAS LOCKED WITHIN THE IGNITION SWITCH. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

BOTH THE FRONT AND BACK DRIVERS SIDE DOORS CAN BE LOCKED EITHER ELECTRONICALLY WITH THE REMOTE OR MANUALLY BY HAND. THE FRONT DRIVERS SIDE DOOR HANDLE WONT OPERATE FROM THE OUTSIDE. IT HAS BEEN FIXED TWICE ALREADY AND NOW BROKEN FOR A THIRD TIME. THIS SEEMS TO BE A WIDESPREAD PROBLEMS WITH THE 02-08 FOCUS. A LITTLE GOOGLING WILL SHOW JUST HOW OFTEN THIS HAPPENS. *TR

WAS DRIVING ON THE HIGHWAY AND BROKE DOWN. CAR TOWED TO GARAGE AND ALTERNATOR REPLACED ALONG WITH THE BATTERY. THE CAR RAN FINE FOR ABOUT 1 WEEK WHERE AFTER TURNING THE CAR OFF IT WOULDN'T START AGAIN. AGAIN HAD IT TOWED TO THE GARAGE AND THE BATTERY NEEDED TO BE CHANGED. A WEEK LATER THE CAR DID IT AGAIN AND AGAIN THE BATTERY WAS REPLACED. I TOOK THE CARD TO MY FORD DEALERSHIP AND HAD AN ELECTRICAL CHECK DONE AND THE ELECTRICAL TEST CAME BACK THAT THE BATTERY THAT WAS JUST PUT IT WAS LOW AND THE ALTERNATOR HAD TESTED FINE. CHANGED THE BATTERY AGAIN..YUP YOU GUESSED IT...IT DIED AGAIN. CHANGED THE BATTERY AGAIN AND THE CAR HAS NOW BEEN RUNNING FOR 2 WEEKS NOW. CALLED FORD'S HOME OFFICE AND FILED A COMPLAINT NOT THAT IT WILL DO ANYTHING. *TR

CAR STARTED NORMALLY. DASHBOARD LIGHTS CAME ON AS USUAL. LIGHTS WENT OUT IN SEQUENCE AS USUAL. NORMAL DRIVING STARTED WITH NO ABNORMAL DASHBOARD DISPLAY. MOMENTS LATER ALL DASHBOARD LIGHT STARTED FLASHING OFF AND ON ERATICALLY. THERE WAS NO EFFECT ON DRIVING THAT COULD BE DISCERNED. ALL THE CAR HANDLING FEATURES SEEMED NORMAL. AS DRIVING CONTINUED SOME OR ALL OF THE DASH LIGHTS WOULD COME ON AND OFF ERATICALLY. THE ONLY LIGHT THAT STAYED ON WHEN THE REST WENT OUT WAS THE ENGINE SYMBOL LIGHT. THE FUEL GAUGE ALSO INDICATED NO-FUEL ERATICALLY. *TR

I'VE HAD THIS 05 FORD FOCUS FOR LESS THAN A YEAR AND HAD SEVERAL PROBLEMS, ALL RESOLVED BUT THIS ONE. I WAS TAKING MY 4 YEAR OLD AND AUTISTIC 13 YEAR OLD STEP CHILDREN TO THE PARK LAST MONDAY AND MY CAR STARTED GOING HAYWIRE. IT WOULD LOSE AND GAIN POWER IN INTERVALS AND ALL OF THE DASH CLUSTER STOPPED WORKING. THE CAR LOST POWER AND DIED ON THE SIDE OF THE ROAD WITH NO CARS IN SIGHT. ENDED UP HAVING TO WALK ALMOST 3 MILES WITH THEM BEFORE WE FINALLY SAW SOMEONE NICE ENOUGH TO GIVE US A RIDE. SINCE THEN THE CAR HAS DRAINED AND RUINED 3 BATTERIES AND TWO ALTERNATORS. MY DASH LIGHTS ARE NOW STAYING ON WITH NO KEY IN THE IGNITION AND BATTERIES KEEP GETTING DRAINED. THERE'S ALSO A CHIRP I'M ASSUMING SOMETHING TO DO WITH THE SECURITY SYSTEM OR THE WIRING HARNESS ON THE...

SO IDK EVERY [XXX] YEAR! FOR THE LAST FEW YEARS! IT GOES GOOD THEN SHE STARTS ACTING FUNNY BOOM BATTERY LIGHT COMES ON. I USE THE VOLTMETER AND EVERYTHING'S FINE FULL CHARGE SAME WITH THE ALTERNATOR. A WEEK OR SO PASSED THEN THE STARTER WENT OUT REPLACED 7/3/13!! WTF! FRIED PUT A NEW ONE IN. NOW MY[XXX] CLUTCH FEELS DIFFERENT DON'T KNOW WHAT IT'S NOT SLIPPING BUT IT'S REALLY SMOOTH.2 DAYS GO BY AND BOOM ACTS LIKE THE BATTERY IS DEAD..NOPE TAKE KEY OUT GET VOLTMETER IT'S AT 12.5 SO I TRY AGAIN SEEMS OK DOESN'T TURN OVER. AGAIN TURN KEY ALL LIGHTS ON SEEMS OK NOTHING.... OK 1 MORE TURN KEY STRUGGLES LIKE STARTER THEN LIGHTS FLICKER DASH WACKS OUT BOOM DEAD NOTHING!!!!! GET OUT STILL 12.5VOLTS. I DON'T KNOW TRY 1 MORE TIME I PUMPED THE CLUTCH AD IT HESITATED TO TURN OVER AND BOOM IT WORKS!!!! GET...

TURN SIGNAL STOPPED WORKING. REMOVED REAR TAIL LENSES TO REPLACE ALL THE BULB AND FOUND BRAKE/TURN SIGNAL SOCKET FUSED TO INTERIOR PORTION OF TAIL LENS INHIBITING REMOVAL DUE TO HEAT WARPAGE. WILL CONTACT DEALER FOR REPLACEMENT SOCKETS FOR RIGHT AND LEFT SIDES AND LENS REPLACEMENT FOR RIGHT AND LEFT SIDES. THIS SHOULD BE A RECALLED ITEM DUE TO HAZARD OF NO TURN OR BRAKE LIGHT AND POOR DESIGN TO ALLOW BULB TO PRODUCE ENOUGH HEAT TO CAUSE THERMAL REACTION AND POSSIBLE FIRE HAZARD. *JS

TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED THAT THE INSTRUMENT PANEL, OVERHEAD DOME LIGHT, REAR WINDSHIELD WIPER, AND REAR EXTERIOR LIGHTS FAILED WITHOUT WARNING. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 135,000.

THE BACK DOOR DRIVERS SIDE WILL NOT LOCK. THE DRIVERS DOOR WILL NOT OPEN FROM THE OUTSIDE. I REPLACED THE DOOR HANDLE BUT IT WILL STILL NOT WORK. IT DOES NOT SEEM TO BE TOUCHING OPENING MECHANISM. *JS

THIS IS THE THIRD TIME I HAD TO PLACE FRONT LEFT AND RIGHT HEAD LAMPS AND HIGH BEAMS . I BROUGHT THIS CAR OFF OF ENTERPRIZE DEALER IN NEVADA. OVER THE YEARS I BEGAN HAVEN LOTS OF PROBLEMS WITH THIS CAR. SO MUCH NEEDED TO BE DONE ON THIS CAR AND I SPENT LOTS OF MONEY TOO. NOT KNOWING UNTIL NOW THIS CAR HAS SOME RECALL ISSUES. PASSENGER REAR DOOR REPLACE AND BROKEN AGAIN. THE REAR BRAKE ARE RUSTED AND NEEDS TO BE REPLACE,DRUMS PADS EXT.. NOISE IN THE STEERING WHEEL WHEN I TURN THE CAR. *TR

REFERRING TO CASE # [XXX]. UPON FURTHER INSPECTION IT WAS DETERMINED THAT THE ROOT CAUSE OF THE SHORT WAS IN FACT THE SMALL BUNDLE OF WIRES GOING INTO THE LIFTGATE. REPAIRS HAVE BEEN MADE TO ALL AFFECTED WIRES. INCLUDING INSTALLATION OF A BRAND NEW HEADLIGHT SWITCH FORD CERTIFIED. COST OF REPAIRS 2347 DOLLARS AND 97 CENTS.UPON READING OTHER COMPLAINTS ON THIS WEBSITE I'VE SEEN AT LEAST 40 OTHER CASES CAUSED BY THE SAME BUNDLE OF WIRES. THIS IS VERY DANGEROUS AND AS YOU CAN SEE COULD POTENTIALLY CAUSE A VEHICLE TO BURST INTO FLAMES WHILE DRIVING. SOMETHING'S GOTTA BE DONE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

DRIVING ON ROUTE 209 APPROXIMATELY 40 MILES AN HOUR. I NOTICED WHITE SMOKE COMING THROUGH THE DASH. IMMEDIATELY PULLED THE CAR OVER, PUT THE CAR IN PARK, REMOVED THE KEY, AND GOT OUT OF THE CAR. WITH NO KEY IN THE IGNITION THE STARTER BEGAN TURNING OVER. I DIDN'T HAVE ANY TOOLS TO UNHOOK THE BATTERY. THE STARTER TURNED OVER FOR ABOUT A MINUTE, THEN THE WINDSHIELD WIPERS, HEADLIGHTS, AND HORN ALL BEGAN ACTIVATING. I IMMEDIATELY CALLED MY MECHANIC FOR EMERGENCY ROADSIDE ASSISTANCE. AFTER ABOUT 4 MINUTES OF THE WIPERS HEAD LIGHTS AND HORN ALL ACTIVATING WITH NO KEY IN THE IGNITION, SOMEONE STOPPED AND HAD SOME TOOLS UNHOOK THE BATTERY.MECHANIC SHOWED UP ABOUT FIVE MINUTES LATER, HAD THE CAR TOWED TO HIS SHOP, AND BEGAN SEARCHING FOR THE PROBLEM. AFTER REMOVING THE DASH PANELS HE SAYS THAT THE HEADLIGHT SWITCH COST A SHORTWHICH MELTED ALL THE WIRES TOGETHERUNDER THE...

THE LEFT REAR TURN SIGNAL STOPPED WORKING- THE BLOWN BULB INDICATION WAS NOTICED BY THE FAST FLASH SIGNAL ON THE DASHBOARD INDICATOR. WHEN GOING TO REPLACE THE BULB IT WAS FOUND THAT THE UPPER SOCKET FOR THE TURN SIGNAL SOCKET IS MELTED TO THE LENS COVER. THE LENS COVER SOCKET MOUNTING HOLE WAS DISTORTED BY HEAT. ONCE THE SOCKET WAS REMOVED THE BULB WAS FOUND NOT TO BE BLOWN. THE SOCKET HOUSING SHOWS INTERNAL SIGNS OF HEAT DAMAGE -COLOR CHANGE. THE BULB WAS IN POSITION IN THE SOCKET AND THE BULB BASE SHOWED NO SIGN OF MELTING AT THE BULB CONTACT POINTS. IT APPEARS THE HEAT WAS GENERATED IN THE SOCKET CONNECTION TO THE BULB BASE. THERE ARE MULTIPLE COMPLAINT OF A SIMILAR FINDING ON MULTIPLE YEARS OF THE FORD FOCUS THAT WERE EASILY FOUND WITH A INTERNET SEARCH- FORD FOCUS MELTED SOCKET. PURCHASING REPLACEMENT SOCKET FROM DEALER AS THIS...

SINCE WE RECEIVED THE CAR, WE HAVE NOTICED INCONSISTENT ACCELERATION AND DECELERATION - BOTH IN TOWN AND ON THE HIGHWAY. THIS PARTICULAR INCIDENT WAS A SIMPLE SLOWING DOWN FOR A STOP LIGHT. I PRESSED ON THE BRAKE GENTLY TO START COMING TO A FULL STOP BEHIND A FEW CARS. AS MY CAR TRIED TO SLOW DOWN, I NOTICED IT WAS FIGHTING TO SLOW DOWN. I PRESSED ON THE BREAK HARDER, BUT IT WASN'T GOING TO BE ENOUGH TO STOP WITHOUT HITTING THE CAR IN FRONT OF ME. I TAPPED THE ACCELERATOR, THEN BACK ON THE BREAK, NO CHANGE. NOT KNOWING WHAT ELSE TO DO, I PUT THE CAR INTO NEUTRAL. THE ENGINE DID NOT STOP REVVING UP SO I TURNED THE CAR OFF. AFTER WAITING A MINUTE, I TURNED THE CAR BACK ON AND OPERATED FINE FOR THE REMAINDER OF THE DAY. *TR

TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED THAT THE WIRING HARNESS FAILED ON THE REAR HATCH OF THE VEHICLE. THE BRAKE LIGHTS STOPPED WORKING AND IT CAUSED THE GEAR SHIFT TO BECOME STUCK. THE VEHICLE WAS TAKEN TO THE DEALER WHO DETERMINED THAT THE DESIGN OF THE WIRING HARNESS WAS TOO SHORT AND WHEN IT WAS STRETCHED THE WIRES CAUSED THE FAILURE TO OCCUR. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS 110,000. *TR

TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH WITH THE HEADLIGHTS IN OPERATION, THE HEADLIGHTS AND INSTRUMENT PANEL LIGHTS BECAME EXTREMELY DIM. THE ENGINE WAS TURNED OFF AND THE VEHICLE FAILED TO RESTART. A CERTIFIED MECHANIC INSPECTED THE VEHICLE AND REPLACED THE ALTERNATOR. THE FAILURE WAS CONTRIBUTED TO A FAULTY LIFTGATE WIRING HARNESS. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 176,000. UPDATED 08/15/13*LJ

KEY STUCK IN IGNITION. THE COLUMN WAS NOT LOCKED. ON THE GEAR SHIFT THERE IS A PLASTIC SLEEVE. I PUT THE GEAR SHIFT IN PARK AND SLID MY HAND BELOW THE KNOB AND PULLED THE SLEEVE UP AND THE KEY COMES OUT. *TR

THE REAR DRIVER SIDE DOOR LOCK WILL NOT LOCK. THE CHILD SAFETY LOCK DOESN'T EVEN MAKE IT WORK. ALL OTHER DOORS WORK WITH THE REMOTE ENTRY KEY FOB AND ALARM ACTIVATES BUT THE REAR PASSENGER DOOR REMAINS UNLOCKED. I CAN NOT EVEN LOCK IT MANUALLY. I FEAR MY GRANDCHILDREN WILL BE ABLE TO SIMPLY OPEN THE DOOR AND EXIT THE CAR AND AM VERY CONCERNED FOR THEIR SAFETY NOT TO MENTION THE POSSIBLITY OF SOMEONE ENTERING THE CAR TO DO HARM OR VANDELIZE THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2005 FOR FOCUS ZXW STATION WAGON. THE CONTACT STATED THAT WHEN THE KEY WAS IN THE IGNITION AND THE SHIFT OVER RIDE BUTTON WAS DEPRESSED, THE KEY WOULD BECOME LOCKED IN THE IGNITION. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE VEHICLE WAS OPERATING AS DESIGNED. THE CONTACT GLUED THE SHIFT OVER RIDE BUTTON IN PLACE AND CHANGED THE IGNITION, WHICH RESOLVED THE FAILURE. THE CONTACT ALSO STATED THE METAL FRAME OF THE DRIVER'S SEAT BECAME CRACKED. THE CONTACT HAD TO PROP THE SEAT UP SO THAT HE COULD DRIVE THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND A COMPLAINT WAS FILED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 205,000. UPDATED 02/20/13*LJ THE CONSUMER STATED THE TRANSMISSION WAS POORLY DESIGNED. UPDATED 02/21/13 THE CONSUMER STATED THE EXPERIENCED NUMEROUS PROBLEMS WITH THE TRANSMISSION, AFTER HAVING THE FLUID FLUSHED. THE...

PURCHASED THE CAR NEW, HAVE HAD TO HAVE ALTERNATOR AND BATTERY REPLACED 3 TIMES NOW. EVERY TIME IT GOES OUT WITHOUT WARNING AND IN MOST CASES ON THE HIGHWAY OR IN HEAVY CITY TRAFFIC. I ALMOST COULDN'T STOP NOR STEER THE CAR SAFELY AWAY FROM THE ROAD. EACH OCCURRENCE HAS COST ME 500.00 USD FROM TOWING, PARTS, AND LABOR. *TR

THE REAR PASSENGER DOOR WILL NOT LOCK OR UNLOCK WITH THE KEYLESS ENTRY NOR THE BUTTONS IN THE CAR. TURNING ON OR OFF THE CHILD LOCK FEATURE DOES NOT AFFECT IT. I CAN MANUALLY 'FORCE IT' EITHER WAY - BARELY - FOR NOW. THIS HAPPENED ONCE BEFORE SEVERAL YEARS AGO - WHERE IT WAS STUCK COMPLETELY UNLOCKED, AND YOU COULDN'T MANUALLY FORCE IT. IT WAS LIKE THAT FOR SEVERAL MONTHS AND THEN MYSTERIOUSLY FIXED ITSELF. I HAVE LOOKED UP THIS PARTICULAR PROBLEM ONLINE AND HAVE FOUND THAT THIS MAKE & MODEL APPEARS TO HAVE MANY CARS WITH THIS ISSUE YET FORD HAS NOT DONE A RECALL ON IT. THIS IS A SAFETY ISSUE. TWO SCENARIOS ARE POSSIBLE HERE THAT ALARM ME: EITHER EMERGENCY PERSONNEL CAN NOT OPEN THE DOOR BECAUSE IT'S STUCK IN THE LOCKED POSITION AND CANNOT BE MOVED OR THE DOOR REMAINS UNLOCKED AND UNWANTED PERSONS GET IN...

ON 2/26/2011 AT APPROXIMATLY 1900 HRS. I WAS AT NELLIS AIR FORCE BASE IN LAS VEGAS NEVADA I HAD TO PULL OVER IN A SAFE AREA TO LOOK FOR MY ID AS I GOT OUT OF THE CAR WITH THE CAR IN PARK AND EMERGENCY BRAKE ON I PROCEEDED TO LIFT THE HANDLE IN FRONT OF THE SEAT THAT ALLOWES IT TO BE MOVED FORWARD SO I CAN LOOK UNDER THE SEAT FOR MY ID,I COULDN'T SEE IT SO I PROCEEDED TO DO THE SAME WITH THE PASSANGER SEAT AND IT WASEN'T THERE SO AGAIN I WAS ON THE DRIVERS SIDE AND AGAIN PULLING UP THE HANDLE AND MY RIGHT SIDE OF MY FACE AND EAR WAS WITHIN AN INCH OF THE SIDE AIR BAG WHEN IT EXPLODEDAND NOCKED ME UP AGAINST THE DRIVERS DOOR FRAME AND THE AIRBAG POWDER WAS ALL OVER ME AND FOR 30 SECONDS I COULDN'T...

WENT TO PICK MY SON UP FROM SCHOOL. COULD NOT GET KEY OUT OF IGNITION. TOOK TO A LOCAL MECHANIC AND CYLINDERS WERE REPLACED. THAT WAS IN MARCH. GOT HOME TODAY (MAY) AND THE SAME PROBLEM. LUCKILY HAVE A DRIVEWAY BUT I AM ANNOYED AND NERVOUS ABOUT KEEPING THIS CAR. FEARFUL THAT THE KEY MAY GET STUCK AT AN INOPPORTUNE TIME. *TR

I PURCHASED THIS VEHICLE NEW IN 2005. WITHIN THE FIRST YEAR AND A HALF I STARTED NOTICING THAT THE DASH LIGHTS WOULD ILLUMINATE WHEN THE VEHICLE WAS PARKED, NO KEYS IN THE IGNITION. THE ABS AND BATTERY LIGHT WOULD FLICKER ON AND OFF ACCOMPANIED BY A BUZZING SOUND. THE WIRELESS REMOTES STOPPED WORKING AS WELL. I BROUGHT THE VEHICLE TO FORD AS IT WAS STILL WITHIN THE THREE YEAR/36,000 MILE WARRANTY PERIOD. THEY SAID THAT THEY COULD NOT DUPLICATE THE PROBLEM. THEY RE-PROGRAMMED THE WIRELESS REMOTES. AFTER THIS THE PROBLEM CONTINUED WITH THE FLICKERING LIGHTS AND BUZZING SOUND AND ALSO THE WIRELESS REMOTES STOPPED WORKING. I RETURNED THE VEHICLE TO FORD AND THEY TOLD ME THAT THE DASH LIGHTS WERE MALFUNCTIONING AND THEY WOULD HAVE TO OPEN UP THE DASH, THEY QUOTED ME $700 JUST TO OPEN UP AND DIAGNOSE PLUS THE LABOR CHARGES FOR WHATEVER THE PROBLEM WAS. THIS...

TL* THE CONTACT OWNS A 2005 FORD FOCUS. WHILE ATTEMPTING TO LOCK THE VEHICLE, THE CONTACT NOTICED THAT THE REAR PASSENGER SIDE ELECTRONIC LOCKING MECHANISM FAILED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE DOOR LOCK ACTUATOR AND LOCKING ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE HAS NOT BEEN REPAIRED. THE CURRENT AND THE FAILURE MILEAGES WERE 92,000.

AFTER STARTING THE CAR WHEN IT HAS SET A FEW HOURS THE OVERDRIVE OFF LIGHT IS FLASHES YELLOW, ODOMETER JUST SHOWS DASHES, AND SPEEDOMETER DOSENT WORK. CAR STILL OPERATES BUT SHIFTS GEARS HARD, WHEN IT REACHES THE SPEED FOR DOOR TO LOCK EVERYTHING STARTS WORKING. I HAVE HAD MULTIPLE PROBLEMS WITH THE ENGINE MGMT FUSE, AND HAVE HAD 3 ALTENATORS CHANGED OUT IN THE LAST 2 YEARS. ALSO I HAD A PROBLEM WITH KEY NOT COMING OUT OF IGNITION AND FOUND OUT THAT A PEICE OF THE SHIFTER HAD BROKE OFF AND SLID DOWN AND KEPT IT FROM GOING ALL THE WAY INTO PARK, AFTER REMOVING PART I HAVE HAD NO PROBLEM WITH THE KEY. ALSO ENGINE LIGHT STAYS ON WAS TOLD BY AUTO ZONE IT WAS VACCUM SYSTEM TOOK IT TO FORD PLACE THEY SAID IT WAS MOTOR MOUNTS, THEY WERE REPLACED 20,000 MILES AGO AND IT STILL HASNT...

WAS DRIVING 45 ON A BUSY ROAD AND ALL THE LIGHTS ON DASHBOARD FLICKERED AND THE CAR WENT DEAD AND HAD TO DRIFT OFF ONTO A MEDIAN. HAD 2 PEOPLE LOOK AT THE CAR AND FOUND THAT THERE WAS THE 20 AMP FUSE OUT. WENT TO GET ANOTHER ONE WE MADE SURE ALL THE WIRES WERE ATTACHED AND NOTHING WAS LOOSE, WE TURNED THE STEERING WHEEL A BIT AND WITH THE NEW FUSE IN THE CAR STARTED, AS WE TURNED THE STEERING WHEEL THE CAR STALLED AGAIN. WENT BACK TO THE STORE BOUGHT 2 MORE FUSES AND GOT THE CAR STARTED DROVE 1 MILE AND IT STALLED AGAIN. TRIED THE 3RD FUSE AND NOTHING. HAD TO HAVE THE CAR TOWED TO LOCAL GARAGE 20 MILES AWAY FROM WHERE IT STALLED. THE GARAGE STATES THAT THE ISSUE IS IN THE DASHBOARD AND THEY HAVE TO TAKE IT TO FORD TO HAVE...

TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED WHILE DRIVING 65 MPH ALL OF THE WARNING LIGHTS WOULD FLASH ON THE DASH BOARD AND THE VEHICLE STALLED, NEARLY CAUSING A CRASH. THE CONTACT DROVE ONTO THE EMERGENCY LANE AND RESTARTED THE VEHICLE WITHIN FOUR MINUTES. AFTER RESTARTING THE VEHICLE, THE IDENTICAL FAILURE RECURRED. THE CONTACT DROVE THE VEHICLE TO A DEALER WHO PERFORMED A DIAGNOSTIC TEST WHICH DID NOT IDENTIFY OR DUPLICATE THE FAILURE. THE CONTACT STATED THE FAILURE OCCURRED FOUR TIMES PRIOR TO TAKING THE VEHICLE TO THE DEALER. THE CONTACT WAS CONCERNED SINCE THE VEHICLE WAS UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 77,000.

TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT STATED THE CHECK ENGINE LIGHT CONSTANTLY ILLUMINATED CAUSING MULTIPLE FAILURES WITH THE VEHICLE. THE FAILURE WAS WITHIN THE ELECTRICAL PART OF THE VEHICLE INCLUDING THE SOLENOID, TRANSMISSION, VALVE BODY AND THE SAFETY SWITCH. THE VEHICLE WAS TAKEN TO A DEALER WHO PERFORMED A DIAGNOSTIC TEST BUT DID NOT DIAGNOSE A DEFINITE SOLUTION FOR THE REPAIRS. THE MANUFACTURER WAS CONTACTED AND STATED THERE WERE NO RECALLS OR WARRANTIES ON THE VEHICLE AND OFFERED NO OTHER ASSISTANCE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 40,000 AND THE FAILURE MILEAGE WAS 43,000.

AN ELECTRICAL SHORT IN THE REAR WIRING HARNESS IN THE LIFTGATE HAS CAUSED THE REAR DEFROST, THE REAR WIPER AND THE HIGH-MOUNT REAR BRAKE LIGHT TO ALL FAIL, CONCURRENTLY. THE DEALERSHIP HAS COMMENTED THAT THIS WAS A COMMON PROBLEM WITH ZX3 FORD FOCUS MODEL AND WAS AS RECALLED SERVICE ISSUE ON A PRIOR MODEL YEAR. IT WAS ALSO CAUTIONED BY THE TECH THAT FIRE COULD RESULT. *TR

TL* THE CONTACT OWNS A 2005 FORD FOCUS. THE CONTACT WAS UNABLE TO RELEASE THE KEY FROM THE IGNITION. THE FAILURE WAS EXPERIENCED NUMEROUS TIMES AND THE VEHICLE WAS TAKEN TO THE DEALER IN 2005 BUT THE DEALER DID NOT REPLACE THE IGNITION SWITCH. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS SCHEDULED TO HAVE DIAGNOSTICS PERFORMED AT THE LOCAL DEALER. THE FAILURE MILEAGE WAS 1,500 AND THE CURRENT MILEAGE WAS 54,000.

2005 FORD FOCUS STATION WAGON REAR HATCH: THE WIRES THAT GO TO THE HATCH (NEAR THE TOP) ARE TOO SHORT AND SO WEAK THAT AFTER 26,000 MILES THE WIRES BROKE AND DUE TO THIS BREAK/SHORT THE CAR WOULD NOT GO OUT OF "PARK". THE BRAKE LIGHTS QUIT WORKING AND IT BLOWS ONE FUSE AFTER ANOTHER FUSE. DUE TO THE WIRES BEING SO SHORT IT IS IMPOSSIBLE TO REPAIR THE BREAKS. THIS APPEARS TO BE A VERY COMMON PROBLEM FROM WHAT I SEE ON THE INTERNET. FORD SHOULD BE LIABLE FOR THESE REPAIRS. *TR

JUST LIKE ALL THE OTHER COMPLAINTS. 'MY KEY BECAME STUCK IN THE IGNITION AND WAS STRANDED HUNDREDS OF MILES FROM HOME" HOW THOUGHTFUL OF FORD TO ONLY CHARGE ME FOUR- HUNDRED DOLLARS! *TR

2005 FORD FOCUS WILL NOT START WHEN THE WEATHER TURNS COLD OR WILL START BUT FOR NO APPARENT RESIN JUST STOPS RUNNING NO FUEL PRESSURE AND FUEL PUMP DOES NOT RUN WHEN THE PROBLEM ARISES WHEN THE WEATHER TURNS WORM THE CAR STARTS AND RUNS FINE DOES NOT DISPLAY ANY ENGINE FAULT COEDS. FROM WHAT I HAVE READ THIS SEEMS TO BE A FORD PROBLEM THAT DOESN'T WON'T TO EXCEPT. *TR

INTERMITTENTLY KEYS GET STUCK IN IGNITION, AFTER A FEW DAYS THEY USUALLY COME OUT MAY BE WEEKS OR MONTHS BEFORE IT HAPPENS AGAIN, WHILE DRIVING I HEAR A CLICKING NOISE, LIGHTS IN THE DASHBOARD AND ALL THE GAUGE LIGHTS START FLICKERING, IF YOU SHUT OFF THE CAR IT WILL NOT START AGAIN AND LOSE ALL POWER, NO LIGHTS, LOCKS ANYTHING POWER SHUTS DOWN, I HAVE BEEN STRANDED DUE TO THIS PROBLEM. HAVE ALREADY HAD SOME WIRES REPLACED, PROBLEM STILL CONTINUES ..WHEN IT HAPPENS THE CAR STARTS TO HESITATE, VERY DANGEROUS IF ON AN INTERSTATE OR GOING THROUGH AN INTERSECTION..CAR IS BACK IN THE SHOP AGAIN FOR THIS ISSUE, ONLY 54000 MILES ON THE CAR...EVEN WHEN I GET IT BACK FROM SHOP THIS TIME AM AFRAID TO DRIVE THE CAR, I WAS TOLD IT WAS FIXED LAST TIME, WHO IS TO SAY THAT IT IS TRULY FIXED THIS TIME, DON'T WANT...