2013 FORD FLEX Suspension Problems

The contact owns a 2013 Ford Flex. The contact stated while driving at highway speeds, the front end of the vehicle was shaking and vibrating, and the steering wheel was difficult to turn in either direction. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that there was no recall on the VIN. There was no assistance provided. The failure mileage was unknown.

Steering locked up lower control arm snapped at the ball joint where it's connected to cv axel. Sent my car into the rails and nearly.killed me and my passenger.

Front tires look and stay really low no matter how much air is put in. It's leaking brake fluid. The emergency brake barley lock. Also transmission is horrible.

The contact owns a 2013 Ford Flex. The contact stated the alarm and sensors were activated without warning. The contact received notification of NHTSA campaign number: 20V072000 (Suspension) however, the part to do the recall repair was unavailable. The vehicle was taken to the local dealer who confirmed that parts were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was 144,284. Parts distribution disconnect.

RECALL 20S04 I HAVE SECOND LTR. CONTACTED MAC HAIK PASADENA TX 26 FEB 21. THEY TOLD ME PARTS NOT AVAILABLE UNTIL MAY. CONTACTED IN MAY, NOW TELL BE PARTS NOT AVAILABLE UNTIL LATE JUNE. FORD CUSTOMER SVC REPORTS PARTS NOW AVAILABLE.

TL* THE CONTACT OWNS A 2013 FORD FLEX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V072000 (SUSPENSION) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED RUSTY ECK FORD (7310 E KELLOGG AVE, WICHITA, KS 67207, (316) 685-9211) TO CONFIRM THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2013 FORD FLEX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V072000 (SUSPENSION) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. NEITHER THE DEALER NOR THE MANUFACTURER WERE MADE AWARE OF THE ISSUE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

ON FRIDAY, JANUARY 22, 2021 AT APPROXIMATELY 12:05 P.M. WHILE DRIVING THE INTERCHANGE FROM THE SOUTHBOUND 55 FWY TO THE NORTHBOUND 405 FWY (IN COSTA MESA, CA) AT A SPEED OF 60 MPH MY 2013 FORD FLEX SEL BEGAN FISHTAILING ERRATICALLY ' SWERVING AND JERKING BACK AND FORTH BETWEEN LANES. AFTER A FRIGHTENING 10-20 SECONDS, I WAS ABLE TO MANEUVER THE CAR TO THE RIGHT SHOULDER OF THE INTERCHANGE WITHOUT ROLLING THE CAR OR HITTING ANYTHING OR ANYONE. (AT THE TIME THERE WAS AN AVERAGE AMOUNT OF TRAFFIC ON THE ROAD ALL GOING ABOUT 50-60 MPH AND WEATHER CONDITIONS WERE SUNNY, 65). MY INITIAL STOPPING POINT WAS NOT IN A SAFE LOCATION SO WHEN I PROCEEDED TO GO FORWARD ABOUT 300 FEET TO A SLIGHTLY SAFER LOCATION, I COULD AGAIN FEEL THE CAR START TO FISHTAIL WHILE GOING ONLY 5-10 MPH AND MY STEERING WHEEL WAS COMPLETELY OFF BALANCE AND...

ELECTRONIC POWER STEERING ASSIST STOPED WORKING AND WARNINING MESSAGE ON DASH DISPLAY.FRACTURE OF REAR TOE LINK RECALL#20V072 HAVE NOT BEEN REPAIRED AS OF 8/30/2020

TL* THE CONTACT OWNS A 2013 FORD FLEX. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V072000 (SUSPENSION) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT CALLED LUTHER FORD LOCATED AT 3302 36TH ST SOUTH, FARGO, ND 58104, (701) 282-2350, AND IT WAS CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2013 FORD FLEX. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 67 MPH, A LOUD POPPING NOISE OCCURRED AND DRIVER SUDDENLY LOST CONTROL OF THE STEERING CAUSING THE VEHICLE TO VIOLENTLY SWERVE WHILE ON THE HIGHWAY. AFTER STOPPING THE VEHICLE THE DRIVER OBSERVED THE REAR DRIVER SIDE TIRE WAS ANGLED SIDE WAYS. A TOW TRUCK WAS CALLED TO THE SCENE AND THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE REAR SUSPENSION TOE LINK HAD FAILED. THE VEHICLE WAS REPAIRED. DURING THE INCIDENT THE FRONT PASSENGER SUSTAINED A LEFT SHOULDER RE-INJURY WHICH REQUIRED MEDICAL TREATMENT. THE LOCAL DEALER ST. GEORGE FORD (145 HILTON DR. ST. GEORGE, UT) AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS INCLUDED IN THE NHTSA RECALL CAMPAIGN NUMBER 20V072000 (SUSPENSION) BUT THE PARTS NEEDED TO REPAIR THE FAILURE WERE NOT YET AVAILABLE. THE CONTACT INDICATED THAT...

WHILE DRIVING IN SNOW/ICE CONDITIONS ON CITY STREETS IN BIG BEAR CA, ICE BUILT UP IN THE RIGHT REAR TOE LINK CHASSIS POCKET CAUSING THE TOE LINK TO FLEX AND EVENTUALLY BREAK LEAVING US STRANDED IN BIG BEAR... THIS PART IS PART OF A RECALL IN THE CANADIAN PROVINCE S BASED ON THE SAME WEATHER CONDITIONS... THE LAST ATTACHED PHOTO SHOWS THE FORD OEM UPGRADED LINK THAT WE HAD TO GET AS A REPLACEMENT OUT OF OUR OWN POCKET

THE REAR TOE LINK ON THE PASSENGER SIDE FAILED WHILE DRIVING, CAUSING THE VEHICLE TO BECOME UNCONTROLLABLE.

STEERING SUDDENLY STOPPED! A SENSOR THAN CAME UP STATING SERVICE ADVANCE TRAC AND NOT EVEN 2 SECONDS LATER ANOTHER SENIOR COMES UP STATING POWER STEERING ASSIST FAULT! I WAS ABLE TO PULL OVER! I THEN READ CAR MANUAL STATING THAT THE SENSORS THAT WERE SHOWN HAVE TO DO WITH AN ELECTRIC POWER STEERING THAT CAN BE RESET BY SHUTTING OFF CAR AND RESTARTING 10 SECONDS LATER! I THEN BROUGHT IT TO KELLY FORD AND THEY ARE STATING THAT THE ENTIRE POWER STEERING RACK MUST BE REPLACED! THEY STATED THAT THERE ARE NO RECALLS ON MY VIN AND THAT I HAD NO WARRANTY! I BEGAN RESEARCH AND THERE HAVE BEEN OVER 500,000 CARS RECALLED FOR THE SAME EXACT REASON BUTVFORD INSIST THAT MINE IS NOT COVERED! I ALSO CONSTANTES FORD MOTORS AND THEY HAD ME FILE A CASE WHICH DID ABSOLUTELY NOTHING! THE DEALER QUOTED ME THAT THIS WAS A 2,000...

NOTICED UNUSUAL SQUEAK / RATTLE FROM FRONT ENGINE AREA OF MY 2013 FORD FLEX AWD VEHICLE. AT THE SAME TIME STEERING FELT LOOSE OR SLOPPY. THESE SYMPTOMS GOT PROGRESSIVELY WORSE AS I IMMEDIATELY DROVE VEHICLE APPROXIMATELY 8 MILES TO REPAIR FACILITY. VEHICLE WAS INSPECTED BY CERTIFIED TECHNICIAN AND I WAS INFORMED THAT THE ELECTRONIC STEERING GEAR WAS FAILING AND THAT THE VEHICLE WAS UNSAFE TO DRIVE AND THAT STEERING COULD FAIL AT ANY MOMENT. TECHNICIAN INFORMED ME THAT FORD HAD NOT ISSUED A RECALL FOR THIS ISSUE AT THAT TIME. I AUTHORIZED AND PAID FOR THE REPAIR OF MY VEHICLE. RECENTLY, I DISCOVERED THAT FORD HAS ISSUED A RECALL NOTICE 15S18 FOR THIS ISSUE. ON MONDAY JULY 27, 2015, I CONTACTED FORD CUSTOMER SERVICE TO REQUEST REIMBURSEMENT FOR THE REPAIR. I WAS INFORMED BY THE CUSTOMER SERVICE REPRESENTATIVE THAT MY VEHICLE WAS NOT INCLUDED IN THIS RECALL AND THAT THEY...

I WAS TURNING A CORNER AND SOMETHING POPPED AND THE CAR WOULD NOT STEER. THE ONLY THING THAT STOPPED THE CAR WAS THE CURVE, AS I WAS MAKING THE TURN, AND THAT CAUSED A LOT OF DAMAGE. SUTTON FORD LINCOLN IN MATTESON, IL SAID THEY WOULD NOT REPAIR THE DAMAGES CAUSED BY THE LEMON-FORD-FLEX THAT WAS SOLD TO ME BECAUSE THE VEHICLE WAS 300 MILES OUT OF THE WARRANTY. SUTTON FORD LINCOLN IN MATTESON, IL THAN SAID IT WOULD HAVE TO BE REPORTED TO INSURANCE. SO I REPORTED IT TO INSURANCE AND THE REPAIR SHOP, THAT WAS REPAIRING THE DAMAGES, SAID THEY FOUND DAMAGE TO THE RADIATOR (1,500 DOLLARS WORTH OF DAMAGES) WHICH COULD NOT HAVE BEEN CAUSED BY THE CAR HITTING THE CURVE. AND THAT IT LOOKED LIKE SUTTON FORD LINCOLN IN MATTESON, IL RAISED THE CAR INAPPROPRIATELY AND CAUSED THE RADIATOR DAMAGE. THE REPAIR COMPANY SAID, SINCE THE...