2014 FORD F-53 Structurebody Problems

THE ENTRY DOOR DOES NOT LOCK AND MULTIPLE TIMES HAS OPENED WHILE DRIVING. THERE IS A RECALL ON LATER MODEL YEARS, BUT THIS MODEL YEAR WAS NOT INCLUDED. WHY?? THIS IS A SERIOUS SAFETY ISSUE AND CERTAINLY ONE THAT EXISTS IN PRIOR YEARS. *TT *TR

ENTRY DOOR POPS OPEN IN MOTION *TT *TR

TL* THE CONTACT OWNS A 2014 FORD F-53. THE CONTACT STATED THAT THE DEADBOLT LOCK ON THE ENTRY DOOR WOULD LOCK INDEPENDENTLY. THE OCCUPANTS WERE UNABLE TO ENTER OR EXIT THE VEHICLE. THE CONTACT ALSO STATED THAT THE ELECTRIC STEPS OPENED INDEPENDENTLY WITHOUT WARNING WHILE THE VEHICLE WAS IN MOTION, THE VEHICLE WAS TAKEN TO CAMPING WORLD OF SACRAMENTO (1039 ORLANDO AVE, ROSEVILLE, CA 95661, (916) 772-1155), BUT WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBERS: 15V510000 (LATCHES/LOCKS/LINKAGES) AND 15V866000 (STRUCTURE). THE MANUFACTURER WAS NOT CONTACTED AND MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 17,000.

AN ALMOST NEW 2014 NEWMAR BAY STAR 3303 MOTORHOME WITH A FORD V10 GASOLINE ENGINE ON A FORD CHASSIS. MY FAMILY AND I WERE PREPARING TO LEAVE ON OUR FIRST BIG FAMILY OUTING IN OUR NEW RV. AT THE LAST MINUTE WHILE LOADING THE VEHICLE A GASOLINE ODOR WAS NOTICED. UPON VACATING THE VEHICLE, GASOLINE WAS SEEN DRIPPING FROM THE HOT EXHAUST PIPES UNDER THE RV. THE RV WAS SHUT OFF AND TOWED TO A FORD TRUCK GARAGE. FORD TECHS DISCOVERED GASOLINE UNDER PRESSURE WAS SQUIRTING ONTO THE ENGINE EXHAUST AND WITHIN MINUTES OF LEAVING ON OUR VACATION THE GAS FUMES WOULD HAVE IGNITED AND EXPLODED. THE FIRE WOULD NOW HAVE BE FUELED BY GAS FROM A MELTED HIGH PRESSURE PLASTIC GASOLINE LINE. THEN, AS A RV WITH THE ENGINE LOCATED BETWEEN THE FRONT SEATS, THE FIRE AND EXPLOSION WOULD HAVE PREVENTED ANYONE FROM EXITING THROUGH THE DOOR. THE GASOLINE...

THIS VEHICLE IS AN RV. THE LATCH TO THE ONLY REGULAR EXIT DOOR IS ATTACHED BY A VERY SMALL PIECE OF CAST METAL. THE SPRING IS QUITE STRONG AND WHILE OPENING THE EXIT DOOR, THE HANDLE BROKE OFF. THIS MADE EXIT FROM THE DOOR IMPOSSIBLE. THE ONLY EXIT WAS OUT THE REAR WINDOW. THE VEHICLE WAS STATIONARY AT THE TIME AND I AM FLEXIBLE ENOUGH TO CLIMB THROUGH THE WINDOW, SO THIS WAS NOT A HUGE ISSUE. HAD THERE BEEN AN ISSUE TO THE REAR OF THE VEHICLE HOWEVER, A WINDOW WOULD HAVE HAD TO BE SMASHED TO EXIT.

TL* THE CONTACT OWNS A 2014 FORD F-53. WHILE THE MOTOR COACH WAS PARKED, TWO OF THE SLIDES, AWNINGS, STAIRS, AND THE DRIVER SIDE POWER SEATS FAILED TO ACTIVATE WITHOUT WARNING. THE FAILURES RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED. THE AWNING AND STAIRS WERE REPLACED. THE DRIVER SIDE POWER SEAT AND SLIDES WERE REPAIRED; HOWEVER, THE FAILURES RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER, BUT THE FAILURES WERE UNABLE TO BE DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND ASKED THE CONTACT TO RUN A HOT WIRE FROM THE BATTERY TO THE SLIDE CONTROLLER. THE SLIDES BECAME OPERABLE. THE APPROXIMATE FAILURE MILEAGE WAS 4,000. UPDATED 09/01/2015*LJ THE CONSUMER STATED THE ELECTRICAL SYSTEM FAILURES ARE INSTALLED BY THOR MOTOR COACH CO. NOT FORD. THE FAILURE WASS BROKEN HOT WIRING WITHIN THE COACH BODY....