2008 FORD F-350 SD Engine And Engine Coolingexhaust System Problems

TL* THE CONTACT OWNS A 2008 FORD F-350 SD. THE CONTACT STATED THAT EXHAUST FUMES EMITTED INSIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO INDICATED THAT THE EXHAUST FILTER WAS POORLY DESIGNED. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. UPDATED 07/03/14 MA THE CONSUMER STATED THE FUMES IN THE VEHICLE CAN CAUSE ONE TO FEEL ILL. UPDATED 07/11/2014 *JS

WHILE DRIVING MY 2008 F350 SUPERDUTY DIESEL POWERED TRUCK AT 45MPH FOR APPROX 4 MILES, RECEIVED MESSAGE "EXHAUST DRIVE COMPLETE" IMMEDIATELY FOLLOWED BY "STOP SAFELY NOW" AND COMPLETE POWERDOWN OF ENGINE. THE TRUCK DECELERATED SO FAST THAT DESPITE MY FLOORING THE THROTTLE, THE CAR BEHIND ME ALMOST COLLIDED. THE TRUCK LOST SO MUCH POWER THAT I COULD NOT SAFELY PULL OFF ROAD AND WAS IN A RURAL AREA BETWEEN TWO BLIND CURVES. THE WHOLE INCIDENT HAPPENED IN LESS THAN 30 SECONDS AND LEFT TRUCK COMPLETELY VULNERABLE TO WHATEVER TRAFFIC CONDITIONS WERE AT THE TIME OF INCIDENT. AFTER GETTING OVER TO SIDE OF ROAD, TRUCK STALLED ON SLIGHT RISE AND DID NOT HAVE THE POWER TO MOVE, HOWEVER WHEN I SHUT TRUCK DOWN, MY 5FT8IN 200LB BODY WAS ABLE TO PUSH THE 8000 LB VEHICLE OVER THE HUMP. ENGINE WOULD NOT CRANK OVER AFTER INCIDENT AND WAS NOT ALLOWED TO RESTART...

08 F350 WITH 70,000MILES ON IT. WE TOW A TRAILER DAILY WITH THIS VEHICLE. APPROXIMATELY 10 TIMES PER DAY IT STATES "CLEANING THE EXHAUST FILTER". ON SEPT. 29, 2010, IT SAID "CLEANING EXHAUST FILTER AND STOP SAFELY NOW" AND SHUT OFF IMMEDIATELY. WHILE I WAS IN THE MIDDLE OF ROAD. LUCKILY A FRIEND WAS DRIVING BY AND TOWED ME OUT OF THE LANE OF TRAFFIC. PRIOR TO THIS OUR VEHICLE HAD FOUR RADIATORS PUT INTO VEHICLE BECAUSE PLASTIC PARTS KEPT BREAKING. THE EXHAUST SENSOR WAS REPLACED PRIOR TO THIS INCIDENT. THE CODE FOR THIS WAS THE EXHAUST SENSOR. IF I WAS ON FOUR LANE HIGHWAY WHEN THE VEHICLE SHUT DOWN I'D BE DEAD. I DIDN'T HAVE ANY TIME TO PULL OFF ROAD. SOMETHING MUST BE DONE ABOUT THIS. FORD IS NOT STANDING BEHIND THIS. TRUCK IS STILL AT DEALER. I'VE BEEN WITHOUT VEHICLE SINCE SEPT. 29, 2010. THEY REFUSE TO...

LOSES POWER WHILE DRIVING CAN NOT GET ANY SPEED ALMOST GOT HIT ON INTERSTATE SINCE IT DROPPED SPEED FROM 70 TO 40 FUEL PUMP REPLACED STILL AT DEALERS HAS BEEN THERE FOR 3 WEEKS HAD IT IN THE SHOP A FEW MONTHS AGO FOR COOLING SYSTEM THIS IS SUPPOSED TO BE A HEAVY DUTY TRUCK THERE IS A NUMBER OF PROBLEMS WITH THESE TRUCKS . WITH 73 BULLETINS ON THEM I THINK IT IS A SAFETY ISSUE !!!!!!!!! *TR

DIESEL PERTICULATE FILTERS. *TR

REGARDLESS OF SPEED, EXCESSIVE WHITE SMOKE BLOWING OUT OF EXHAUST COMPLETELY OBSTRUCTING OWN REAR SIGHT AS WELL AS BLINDING FOLLOWING VEHICLES. IT HAS HAPPENED 4 TIMES, VEHICLE CURRENTLY AT 36, 000 KM. PERSONAL BELIEF IS THAT THIS HAS LED TO ENGINE NEEDING TO BE REPLACED WHICH FORD WILL NOT WARRANTY. NOTHING HAS BEEN DONE AS FORD REPORTS THEY CANNOT FIND THE PROBLEM. *TR

I LEASED A 2008 F350 6.4 LITER IT WAS SMOKING OUT OF THE TAILPIPE OFTEN SO I CALLED THE DEALER AND THEY SAID IT WAS NORMAL OVER THE NEXT FEW MONTHS IT GOT WORSE THEN I HAD THE OIL CHANGED AT THE DEALER AND THE SMOKE CHECKED THEY SAID IN THE PAPER WORK IT WAS UNDETERMINED 1 MONTH LATER I LOST ALL POWER AND THE TRUCK DIED THE OIL CAP WAS NOT PUT ON AND THERE WAS OIL EVERYWHERE SINCE THEN THE SMOKE HAS GOTTEN WORSE SO I STARTED TO GO TO A SMALL MECHANIC THAT WORKS ON MY OTHER TRUCKS WELL SINCE THIS INCIDENT THE SMOKE IS MORE OFTEN LIKE TWO TIMES A WEEK FOR 10 MIN SON I BROUGHT IT TO THE DEALER TWO WEEKS AGO THEY HAD IT FOR 3 DAYS AND THEN THEY CALLED ME AND SAID I HAD TO PROVE THAT I HAD THE OIL...