2005 FORD F-250 Electrical System Problems

Electrical system fails every day. It affects the engine, transmission, radio, windows, gauges. Wiring issue causes the radio to just go out, windows stop working, all gauges stops working, the transmission doesn't shift right, engine doesn't run right. Yes vehicle is available for inspecting. Engine cuts off and won't start back, leaves you stranded side the road. Truck stalls in front of other vehicles. Windows won't roll down when it's 100 degrees inside truck. Fuel gauge doesn't let you know when there's no fuel again leaving you stranded beside the road. Other gauge don't work could cause more damage. Yes it has been inspected my mechanic and he said there are wiring issues. No warning lamps or anything now but the wrench light has came on allot. There is a wiring recall on this year truck but said mine doesn't fall under that recall and I don't know why because...

Wrench light comes on, but truck goes into limp loses power very dangerous don't know if it's going to cause me to be rear-ended, steering goes back and forth right to left can't hardly hold it in road

The back bed rails rot/rust very quickly and trying to buy new beds run 4500$ along with o2 sensors ir intake sensors go out of blue no reasoning let alone the power steering lines rusting very very quickly

The contact owns a 2005 Ford F-250. The contact stated while driving at various speeds, the vehicle loss motive power. The vehicle was later restarted and the vehicle operated as designed. The vehicle was taken to the local dealer who replaced the fuel injection control module however, the failure recurred. The manufacturer was notified of the failure and the contact was informed that the vehicle was not included in NHTSA campaign number 05V270000 (Electrical System). The contact indicated that the vehicle had experienced the same failure listed in the recall. The failure mileage was 36,000.

WHEN DRIVING, THE TRUCK WILL DIE. SOMETIMES TRUCK CAN BE RESTARTED OTHER TIMES HAD TO HAVE IT TOLLED. WE HAVE REPLACED FUEL PRESSURE REGULATOR, REGULATOR, START SWITCH R&R INSTRUMENT CLUSTER, ALTERNATOR, BATTERIES AND THE PROBLEM STILL EXIST. HAVE TAKEN IT TO A FORD DEALER AND THEY CAN NOT FIND THE PROBLEM. THEY SAY IT IS NOT COVERED ON RECALL 05V270000

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING 70 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE CONTACT STATED THAT THE BRAKE PEDAL HAD TO BE PUMPED SEVERAL TIMES AND THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. ADDITIONALLY, THE VEHICLE STALLED WITHOUT ANY WARNING INDICATORS ILLUMINATING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BATTERY, ALTERNATOR, AND FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 162,000.

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE THE ACCELERATOR PEDAL WAS DEPRESSED, THE VEHICLE FAILED TO OPERATE AND STALLED. THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL INJECTION CONTROL MODULE AND INJECTION CONTROL PRESSURE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V27000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,100. UPDATED 06/21/16*LJ

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, BUT THE FAILURE PERSISTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,000.

TL* THE CONTACT OWNS A 2005 FORD F-250. WHILE DRIVING APPROXIMATELY 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE RESTARTED AFTER MULTIPLE ATTEMPTS; HOWEVER, THE FAILURE RECURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE ICP PRESSURE SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2005 FORD F250. THE CONTACT STATED THAT THE VEHICLE WAS HESITANT UPON START-UP. THE FAILURE WAS RECURRING. THE STARTER WOULD TURN OVER BUT THE ENGINE WOULD NOT ENGAGE. THE BATTERY WAS REPLACED TWICE BUT TO NO AVAIL. ADDITIONALLY, BLACK SMOKE WAS EMITTING FROM THE VEHICLE AND THE VEHICLE WOULD STALL SPORADICALLY. THE VEHICLE WAS TO BE INSPECTED, DIAGNOSED AND REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 109000.

MY 2005 FORD F-250 SUPERDUTY 6.0L DIESEL, FIRST INCIDENT WAS MAY OF 2007, AT 16,000 MILES MY TURBO CHARGER WENT BAD WHEN I WAS TRAILERING MY HORSES IN VERMONT, FORCED TO STOP AT UNKNOWN DEALERSHIP WHO "CLEANED" SOMETHING SO I WOULD MAKE IT BACK TO MY HOME. AGAIN ON THE DRIVE HOME I LOST THE TURBO. IT HAD TO BE REPLACED AT THE DEALERSHIP, COLUMBIA FORD, CT THE NEXT DAY. I WAS TOLD I HAD TO DRIVE MY TRUCK HARD AND EVERYDAY IN ORDER TO PREVENT THE PROBLEM FROM OCCURRING AGAIN. IN MARCH 2010 BROUGHT MY TRUCK TO MONACO FORD, THE MOTOR HAD TO BE REMOVED DUE TO "ALL OF THE GASKETS AND SEALS IN THE MOTOR LEAKING, AS WELL AS THE TURBO CHARGER BEING BAD AGAIN. THIS OCCURRED AT 24,500 MILES. THE SIDE WALLS OF MY TIRES ARE PEELING, THE RUNNING BOARD ON THE DRIVERS SIDE IS FALLING OFF,...