2008 FORD F-250 SD Engine And Engine Coolingexhaust System Problems

2008 F250 SUPER DUTY DIESEL EXPLODED (NEIGHBORS' DESCRIPTION) WHILE PARKED. WE HAD JUST RETURNED FROM TOWING A SKID LOADER BACK FROM A JOB SITE AND APPROXIMATELY HALF AN HOUR LATER, NEIGHBORS CALLED TO SAY THAT OUR TRUCK HAD EXPLODED. THE FIRE DEPT WAS ON THE SCENE WHEN WE ARRIVED AND THE VEHICLE APPEARS TO BE A TOTAL LOSS. WE HAD OWNED AND USED THE TRUCK FOR 9 DAYS AND IT HAD PERFORMED WITHOUT PROBLEM DURING THAT TIME WHICH INCLUDED A 400 MILE TRIP FROM THE POINT OF PURCHASE IN PA TO OUR HOME LOCATION IN COLUMBUS OH. NO DAMAGE TO PROPERTY OTHER THAN TO THE VEHICLE ITSELF. *TR

DRIVING AROUND AND DIESEL FUEL SMELL CAME INTO THE CAB OF THE TRUCK AND SMOKE FROM ENGINE COMPARTMENT. THIS TRUCK HAS A 6.4L JOB 1 DIESEL. WE HAD THE TRUCK TOWED TO THE FORD DEALERSHIP BECAUSE DRIVING IT MAKES ME SICK TO MY STOMACH AND LIGHT HEADED. FORD TELLS US IT WILL HAPPEN EVERY 100-600 MILES AND LAST 10-40 MINUTES EACH TIME DURING REGENERATION. FORD SAYS THIS IS A 'NORMAL OPERATION CHARACTERISTIC OF THE VEHICLE'. THE DEALERSHIP REFERENCED TSB 09-16-9 AND TOOK THE TIME TO HIGHLIGHT CERTAIN AREAS. #1 - I WAS NOT IN COLD AMBIENT TEMPERATURE AT THE TIME THE SMOKE WAS COMING FROM THE ENGINE COMPARTMENT AND #2 - THIS IS NOT A BRAND NEW TRUCK ALTHOUGH WE DO HAVE LOW MILEAGE. HOW CAN THIS BE CONSIDERED NORMAL IF IT HAD NEVER HAPPENED BEFORE AND NOW MAKES ME SICK WHEN I DRIVE THE TRUCK? THE SMELL IS STILL...

I HAVE A 2008 F-250 S/D MANUFACTURED 02/08 AT THE KENTUCKY PLANT. THIS VEHICLE WAS PURCHASED NEW IN APRIL 2009 AND NOW HAS JUST UNDER 8000 MILES ON THE ODOMETER. I HAVE TWICE EXPERIENCED UNCONTROLLED INVOLUNTARY ACCELERATION WITH THIS VEHICLE. THE COMMON ELEMENTS OF THIS HAVE BEEN THAT IT OCCURRED AFTER A PERIOD OF EXTENDED DRIVING AT ABOUT 70 MPH, USING CRUISE CONTROL, JUST AFTER AN EXHAUST CLEANING CYCLE, AND WHEN I OVERRODE THE CRUISE CONTROL TO ACCELERATE TO PASS A VEHICLE IN FRONT OF ME. WHEN PULLING BACK IN TO THE TRAFFIC LANE, THE VEHICLE CONTINUES TO ACCELERATE AND CAN BE CONTROLLED ONLY BY MAINTAINING HEAVY PRESSURE ON THE BRAKES UNTIL A SAFE LOCATION CAN BE FOUND TO PULL OFF THE ROAD AND CUT OFF THE IGNITION. A RESTART IN NEUTRAL WILL RESULT IN AN IMMEDIATE RUN-UP IN RPM WHICH REQUIRES A SHUT DOWN OF THE IGNITION. THERE ARE...

SUDDEN INTENSE INTENSE SMOKE FROM TAILPIPE AT TIME OF EXHAUST CLEANING FROM MY 2008 FORD F250 DIESEL PICKUP (FORD CONSIDERS NORMAL OPERATION OF SYSTEM) WHILE ENTERING A TOLL PLAZA CREATED A SUDDEN AND UNSAFE CONDITION FOR OTHER DRIVERS BEHIND ME. THE SMOKE WAS SO HEAVY I COULD NOT SEE VEHICLE BEHIND WHILE PASSING THROUGH A TOLL PLAZA. THE LANE I WAS IN UTILIZES A TRANSPONDER TO COLLECT TOLL WHILE TRAFFIC IN THAT LANE NORMALLY DOES NOT STOP. IF A VEHICLE HAD BEEN STOPPED THE DRIVERS BEHIND ME WOULD NOT HAVE BEEN ABLE TO REACT IN TIME. IT WAS ALSO POSSIBLE THAT THEIR VISIBILITY OF THE STRUCTURES OF THE TOLL PLAZA ITSELF WERE SUFFICIENTLY DIMINISHED THAT A COLLISION WITH THE STRUCTURE WAS POSSIBLE. I PASS THROUGH THREE TOLL PLAZAS EACH WAY, TO AND FROM WORK, 5 DAYS A WEEK. *TR

IN HOT TEMPERATURE THE TRUCK STARTS BLOWING OUT WHITE/GRAY SMOKE THEN QUITS RUNNING. SET FOR 1 TO 1.5 HRS IT WILL START AND GO ABOUT 30 TO 40 MILES THEN QUIT AGAIN. IT HAS BEEN IN THE SHOP 2 TIMES NOW AND THEY CANNOT FIND THE PROBLEM. IT SAYS THAT IT IS AN OVER TEMPERTURE MODULE BUT IT HAS BEEN CHANGED AND IT STILL HAS THE SAME PROBLEM. *TR