2003 FORD F-250 SD Fuelpropulsion System Problems

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE FUEL TANK WAS HANGING DOWN. THE CONTACT LOOKED UNDERNEATH THE VEHICLE AND SAW THAT THE FUEL TANK STRAP WAS FRACTURED AND THE FUEL GAUGE WAS DAMAGED. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS 49,000.

THE REAR FUEL TANK STRAP FAILED WHILE TRAVELING ON A STATE HIGHWAY.

1 OF THE TANK STRAPS BUSTED OFF AND THE TANK BEGAN SAGGING AND ALMOST TOUCHING THE GROUND, THUS CAUSING A SEVERE FIRE HAZARD.

TL* THE CONTACT OWNS A 2003 FORD F250 SD. THE CONTACT STATED THAT WHILE DRIVING UP AN INCLINE APPROXIMATELY 45 MPH, THERE WAS A SUDDEN REDUCTION IN THE ENGINE POWER AND THEN STALLED. THE VEHICLE RESTARTED AFTER NUMEROUS ATTEMPTS. A CHEMICAL BURNING ODOR EMITTED OUTSIDE OF THE VEHICLE. THE FAILURE OCCURRED SPORADICALLY AND WHENEVER THE FUEL TANK LEVEL REGISTERED QUARTER OF A TANK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THE FUEL TANK LINING WAS SEVERELY DAMAGED AND THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2003 FORD F-250 SD. THE CONTACT STATED THAT WHILE PERFORMING AN OIL CHANGE, HE NOTICED THAT THE FRAME WAS RUSTED SEVERELY.THE CONTACT PERFORMED A THOROUGH INSPECTION OF THE VEHICLE AND ALSO DISCOVERED THAT THE FUEL TANK STRAPS WERE SEVERELY RUSTED. THE FRONT STRAP WAS COMPLETELY DETACHED FROM THE VEHICLE AND THE SECOND STRAP WAS PARTIALLY HANGING FROM THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND ADVISED HIM THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 11V385000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:MOUNTING). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 125,000.

TL* THE CONTACT OWNS A 2003 FORD F-250 SUPER DUTY. THE CONTACT WAS TRAVELING 80 MPH WHEN THE SMELL OF FUEL EMITTED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC. THE MECHANIC CONFIRMED THAT THE STEEL FUEL LINE WAS CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 62,400 AND THE CURRENT MILEAGE WAS 70,780.