2000 FORD F-250 SD Electrical System Problems

APPROXIMATELY 1 HOUR AFTER BEING PARKED IN PARKING STALL AT MY RESIDENCE, NEIGHBORS NOTICED FIRE COMING FROM THE HOOD AND UNDERNEATH THE VEHICLE (THE FIRE ORIGINATED ON THE DRIVER'S SIDE).THEY ATTEMPTED TO PUT OUT THE FIRE AND CALLED 911. SAN JOSE FIRE DEPARTMENT RESPONDED TO THE CALL AND FINISHED PUTTING OUT THE FIRE. THE VEHICLE HAD VISIBLE BURNT WIRING, RIGHT SIDE FENDER DAMAGE FROM HEAT (INSIDE AND OUTSIDE) AND THE RIGHT DRIVER'S SIDE TIRE SUSTAINED DAMAGE DUE TO MELTING DEBRIS FALLING ON TIRE. THE FIRE DEPARTMENT TOOK A REPORT OF THE INCIDENT. AS I HAVE RELAYED THIS EVENT TO OTHERS, THEY HAVE MENTIONED THAT THIS IS PROBABLY A "RECALL FIRE" AND THAT I SHOULD REPORT THIS INCIDENT. *TR

TL* THE CONTACT OWNS A 2000 FORD F-250 SD. THE CONTACT STATED THAT HE HEARD A CLICKING NOISE AND THE LIGHTS ON THE INSTRUMENT PANEL FLICKERED ON AND OFF. ONCE HE TURNED THE HEATER CONTROL OFF, THE FLICKERING STOPPED BUT RECURRED WITHIN A FEW MINUTES. THE CONTACT PARKED THE VEHICLE AND WHEN HE RETURNED, THE VEHICLE WAS ATTEMPTING TO START INDEPENDENTLY. HE REMOVED THE POSITIVES AND NEGATIVES FROM THE SOLENOID TO CORRECT THE FAILURE. HE THEN REATTACHED AND THE FAILURE RECURRED. IN ADDITION, SMOKE WAS EMITTING FROM THE VEHICLE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS APPROXIMATELY 218,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 217,000.

I HAD A SPARK PLUG BLOW OUT OF THE CYLINDER HEAD, AS MANY OTHER PEOPLE HAVE. THIS IS A MANUFACTURING DEFECT, AND THEY KNOW IT, SINCE THEY CHANGED THE DESIGN. THERE SHOULD BE A RECALL FOR THIS, SINCE IT IS A SAFETY ISSUE, AND IF I CANNOT FIX IT, IT WILL COST ME $2400 FOR A NEW CYLINDER HEAD. *TR

OCCASIONAL ENGINE STALL WHEN WINDSHIELD WIPER IS TURNED ON OR ON INTERMITTENT SETTING. OCCASIONAL STALLS WHEN STEERING IS TURNED QUICKLY LEFT TO START TURNING FROM STANDING POSITION AT INTERSECTIONS. FORD SERVICE DEPARTMENT WAS UNABLE TO FIND CAUSE OR MAKE CORRECTIONS. *JB

VEHICLE DIED SUDDENLY AND FAILED TO RESTART. CPS WAS REPLACED, VEHICLE RAN. *JB

WHILE DRIVING MY 2000 F-250 FORD PICK UP TRUCK EQUIPED WITH THE 7.3 LITER DIESEL ENGINE, THE ENGINE SUDDENLY STOPPED RUNNING, WITHOUT ANY WARNING SIGNS. THIS OCCURED WHILE I WAS ENTERING A CIRCLE INTERSECTION, FORTUNATELY VERY EARLY IN THE MORNING BEFORE ANY RUSH HOUR TRAFFIC. WHEN THE ENGINE SHUT DOWN I LOST BOTH THE POWER STEERING AND THE POWER BRAKING SYSTEMS. I WAS STARTING MY TURN TO ENTER THE CIRCLE AND AT FIRST THOUGHT THAT I HAD A FRONT FLAT TIRE AS THE VEHICLE BARELY RESPONDED TO MY EFFORTS TO GRADUALLY TURN TO THE RIGHT. THEN, WHEN I TRIED TO STOP IT TOOK AT LEAST TWO TO THREE TIMES THE DISTANCE TO COME TO A STOP, AS IT USUALLY DOES, EVEN WITH GREATLY INCREASED PRESSURE TO THE BRAKE PEDAL. IF THER HAD BEEN A VEHICLE IN FRONT OF ME OR ANOTHER SORT OF OBSTRUCTION I COULD HAVE EASILY HIT IT....

MY CPS IN MY 2000 7.3L TRUCK FAILED. *JB

MY COMPLAINT IS ABOUT THE CPS (CAMSHAFT POSITION SENSOR) ON THE FORD 7.3L POWER STROKE ENGINES. IT SEEMS THAT MOST/ALL VEHICLES EQUIPPED WITH THIS SENSOR HAVE EXPERIENCED FAILURE, WHICH RESULTS IN THE VEHICLE STALLING. I BELONG TO SEVERAL FORUMS AND NEARLY EVERYONE HAS HAD A PROBLEM WITH THAT SENSOR AND IT IS "RULE OF THUMB" TO CARRY ONE IN YOUR GLOVE BOX FOR WHEN IT GOES BAD. THIS HAS BECOME SUCH A PROBLEM THAT YOU CAN NOW BUY THE SENSORS ON EBAY, PEOPLE HAVE BOUGHT THESE BY THE TRUCKLOAD TO SELL SINCE THEY KNOW OF THE PROBLEM. WHY SHOULD WE CONSUMERS HAVE TO WORRY ABOUT SUCH AN IMPORTANT COMPONENT OF THE ENGINE FAILING? WE SPEND 20-30-40K DOLLARS ON THESE VEHICLES AND CAN BE LEFT STRANDED ON THE SIDE OF THE ROAD DUE TO THIS ONE PART FAILING OVER AND OVER AGAIN. PLEASE, SOMEONE DO SOMETHING ABOUT THIS!!!*JB

DRIVING HOME AT ABOUT 55MPH NOTICED A VERY BAD HESITATION IN 5.4L ENGINE AND APPARENT MISFIRE. AFTER PULLING OVER AND SHUTTING ENGINE OFF, NOTICED # 3 COIL BROKEN AND SPARKPLUG LAYING BY FUEL RAIL. SPARK PLUG SHOT OUT OF CYLINDER HEAD DUE TO POOR ENGINEERING BY FORD. 1999-2002 F250 5.4L HEADS ONLY HAVE 4 THREADS THAT HOLD SPARK PLUGS.*AK

ON MY WAY HOME FROM WORK I HEARD AN UNUSUAL NOISE EMINATING FROM UNDER THE HOOD OF MY 2000 FORD F-250 SUPER DUTY, 6.8 (V-10) TRUCK. I THOUGHT IT WAS AN XHAUST MANIFOLD LEAK. I PULLED ONTO A GRAVEL ROAD, LIFTED THE HOOD AND CLIMBED UP TO LOOK TO SEE WHAT I COULD FIND. IMAGINE MY SUPRISE TO SEE A LEFT BANK SPARK PLUG, #8 CYLINDER, LYING AGAINST THE FUEL RAIL AND THE COIL FIRING AGAINST THE HEAD. I LIMPED HOME, WONDERING ALL THE WHILE HOW MUCH FUEL WAS POURING INTO THE OIL PAN! I USED A STRONG FLASH LIGHT TO PEER INTO THE SPARK PLUG HOLE AND FOUND TO MY SUPRISE, VERY LITTLE IF ANY THREADS TO CONTIAN THE SPARK PLUG. I THEN USED A 90 DEG. PICK TO "FEEL" THE THREADS. NONE. I CALLED JOE MACHENS FORD IN COLUMBIA, MO. TO SEE IF THIS MIGHT BE A COMMON...