2009 FORD F-150 Engine And Engine Cooling Problems

The contact owns a 2009 Ford F-150. The contact stated that while starting the vehicle, there was an abnormal rattling noise detected. The check engine warning light was flashing on and off. The vehicle failed to start. The vehicle was taken to the local dealer where it was diagnosed that the failure was due to a faulty cam phaser. Additionally, the contact was informed that the timing chain and engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred him to the NHTSA Hotline for assistance. The approximate failure mileage was 185,000.

ON NOW 4 OCCASIONS, I HAVE HAD AN ACCELERATOR STUCK IN WIDE OPEN CONDITION. ON 3 OF THEM, IT INVOLVED PASSING AT HIGHWAY SPEEDS, AND ON THE LATEST (10/22/16), IT HAPPENED ON A HARD ACCELERATION IN CITY CONDITIONS WHILE ACCELERATING FROM SLOW TO FASTER SPEED. IN EACH EVENT, PRESSING ON THE BRAKE DID HOLD BACK SPEED, BUT FULL ACCELERATION RESUMED IF BRAKE WAS RELEASED AT ALL. VERY LUCKY TO HAVE AVOIDED ACCIDENT / DEATH!

I HAVE TAKEN MY TRUCK TO FORD AND IT HAPPENS WHEN I,M PULLING IN TO PARK OR BACKING UP IN A SPACE TO PARK, THE TRUCKS ENGINE STARTS TO SHAKE AND THAN STALL, WHEN FORD PUT THE THING TO ATTACH UNDER YOUR STEERING WHEEL IT DID NOT SHOW ON THE SCREEN, I HAD A PRIVATE MECH. DO THE SAME THING AND HE COULD NOT FIND IT EITHER. I DO THINK THIS IS A SAFETY PROBLEM BECAUSE MY TRUCK HAS ALSO GONE DEAD IN THE ROAD WAITING FOR THE LIGHT TO CHANGE AND STALL...NOW IT IS HAPPENING A LOT , I TALK TO THE FORD DEALER A STATES THAT IT IS NOW OUT OF WARRANTY . THE PROBLEM STARTED EVEN WHEN THE WARRANTY WAS STILL GOOD ON THE TRUCK. *TR

WHILE DRIVING 60 MPH, I LEFT OFF THE ACCELERATOR TO SLOW DOWN TO 45 MPH THE POSTED SPEED LIMIT AHEAD. AT 45 MPH, I SLIGHTLY TOUCHED THE ACCELERATOR TO MAINTAIN THE 45 MPH SPEED LIMIT, THE RPM'S WENT OVER 4000 AND WOULD NOT STOP. I APPLIED THE BRAKE, BUT THE ENGINE KEPT THE RPM'S BETWEEN 4000 AND 4200. I STOMPED ON THE BRAKE WITH BOTH FEET AND THE UN-INTENDED ACCELERATION STAYED AT THE HIGHER RPM. I COULD HEAR THE ANTI-LOCK BRAKES ENGAGE TO HELP SLOW THE TRUCK DOWN, BUT THE ENGINE LABORED OVER 4000 RPM. I WAS CONCERNED WITH NOT BEING ABLE TO STOP THE TRUCK, SO I SHIFTED THE TRANSMISSION INTO NEUTRAL AND COASTED TO THE BERM OF THE ROAD WITH THE ENGINE STAYING AT A VERY HIGH RPM. ONCE I CAME TO A COMPLETE STOP, I SHIFTED THE TRUCK INTO PARK AND THE RPM'S WERE OVER 6000. I...

THE CHECK ENGINE LIGHT STARTED GOING ON AND OFF PERIODICALLY. AFTER THREE VISITS TO THE DEALER THEY DETERMINED THAT THERE ARE NO MECHANICAL PROBLEMS. THEY RESEARCHED AND DETERMINED THERE IS A COMPUTER PROGRAM PROBLEM WITH THE MAIN COMPUTER THAT CAUSES THE LIGHT TO GO ON. THEY TOLD ME THAT I WOULD HAVE TO PAY TO GET AN UPDATE TO THE COMPUTER PROGRAM THAT WOULD CORRECT THIS PROBLEM. IT COST ME THREE VISITS AND A $85 BILL TO FIND OUT THE PROBLEM IS WITH THEIR COMPUTER PROGRAM. THEY KNOW THERE IS A PROBLEM WITH THEIR PROGRAM AND THEY WANT THE VEHICLE OWNER TO PAY OVER $200 TO FIX IT. HOW DO THEY FIGURE THAT IS THE OWNER'S FAULT? *TR

I EXPERIENCED UNINTENDED ACCELERATION WHILE BACKING UP. I HAD JUST STARTED THE ENGINE AND PLACED IT IN REVERSE AND THEN TAPPED THE ACCELERATOR LIGHTLY TO START MOVING. THE VEHICLE THEN STARTED TO ACCELERATE RAPIDLY BACKWARDS. LUCKILY MY FOOT WAS OFF THE ACCELERATOR FOR I WAS IN A SCHOOL PARKING LOT AND ON A SLIGHT INCLINE SO I WAS RIDING THE BRAKE LIGHTLY. I HAD MY RIGHT FOOT FULLY ON THE BRAKE PEDAL AND COULD BARELY KEEP IT SLOWED. I PLACED THE ENGINE IN NEUTRAL AND THE TACH SHOWED A STEADY 4000 RPM, AGAIN MY FOOT WAS STILL OFF THE ACCELERATOR. I THEN TURNED OFF THE ENGINE AND RESTARTED AND ALL SEEM NORMAL. I TOOK IT TO THE DEALER AND THEY COULD NOT DUPLICATE OR SHOW ANY COMPUTER CODE ERRORS.