2008 FORD F-150 Suspension Problems

TOOK VEHICLE IN FOR ENGINE REPAIR. TECHNICIAN DISCOVERED BOTH FRONT COIL SPRINGS BROKEN. ALMOST NEW TIRES WORN BALD ON THE INNER EDGE. ONLINE RESEARCH INDICATES THIS HAS BEEN A MAJOR COMMON PROBLEM ON THE 04-08 F-150, WITH NO RELIEF FROM FORD.

LEFT FRONT COIL SPRING BROKEN . FOUND BROKEN DURING ALIGNMENT INSPECTION FEBRUARY 12,2019 . ODOMETER 73750 .

TOOK TRUCK IN FOR MAINTENANCE. WAS CALLED OVER BY MECHANIC. HE SHOWED ME THE WHOLE FRAME OF THE TRUCK IS RUSTED OUT. THE TRUCK HAS 100,000 MILES AND BODY IS CLEAN FOR ITS AGE. LOCAL DEALERSHIP QUOTED $6,000.00 TO REPAIR. A SMALL AUTO COLLISION SHOP QUOTED +$3,000.00. BOTH AGREED THIS SHOULD NEVER HAVE HAPPENED. THIS IS A SERIOUS RISK THAT COULD RESULT IN BODILY INJURY OR DEATH. VEHICLE IS NO LONGER SAFE TO DRIVE ON THE ROAD. SEVERAL OTHER MANUFACTURES HAVE HAD THE SAME ISSUE AND HAVE TAKEN CORRECTIVE ACTION TO REPAIR OR REIMBURSE FOR THE EXPENSE. IT IS DOCUMENTED OUT ON THE INTERNET THAT IT IS AN ISSUE. THERE ARE 16 OTHER COMPLAINTS ON THIS CAR COMPLAINT SITE FOR THE SAME ISSUE. I HAVE BEEN ADVISED/SUGGESTED REPORTING THE ISSUE TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA).

I OWN A 2008 FORD F150. IN THE YEAR OF 2014 I BEGAN TO HEAR A NOISE FROM THE FRONT END OF THE VEHICLE. THE NOISE WAS HEARD WHEN GOING OVER BUMPS AND MAKING TURNS. ON AUGUST 14, 2014 THE VEHICLE WAS SERVICED AND REPAIRED FOR FRONT SWAY BAR END LINKS. IN THE YEAR OF 2016 THE NOISE RETURNED WITH THE SAME SYMPTOMS. ON APRIL 5, 2016 THE VEHICLE WAS SERVICED AND REPAIRED FOR FRONT SWAY BAR END LINKS. IN THE SAME YEAR THE NOISE RETURNED WITH THE SAME SYMPTOMS. ON SEPTEMBER 10, 2016 THE VEHICLE WAS TAKEN IN FOR AN OIL CHANGE AND I INFORMED THE SERVICE ADVISOR ABOUT THE NOISE. HIS RESPONSE WAS, 'HIS MECHANICS WOULD NOT BE ABLE TO CHECK THE ISSUE DUE TO MINIMUM STAFFING'. DECEMBER 17, 2016 THE VEHICLE WAS SERVICED AND REPAIRED FOR FRONT SWAY BAR END LINKS. I WAS CONCERNED ABOUT THIS REOCCURRING...

BOTH FRONT COIL SPRINGS BROKE FROM CORROSION.

R R LEAF SPRING BROKEN. VEHICLE HAS NEVER BEEN ABUSED OR DRIVEN ROUGH. I FIRET NOTICED IT WHEN I WOULD HIT A BUMP IN THE ROAD, SOUNDED LIKE SPARE TIRE RACK WAS LOOSE. AFTER LOOKING ON THE INTERNET I FOUND THAT THERE WERE OTHERS THAT HAVE EXPERIENCED THE SAME PROBLEM. THE CENTER LEAF OF THE THREE SPRINGS BREAK GENERALLY IN THE MIDDLE OF THE LEAF.

I HAVE A 2008 F-150. AS I WAS TAKING AN EXIT OFF THE HIGHWAY, THE STEERING WHEEL LOOKED UP & I COULDN'T TURN THE WHEEL & ENDED UP ON THE GRASSY AREA OF THE EXIT.. THE PROBLEM IS THE LOWER STEERING SHAFT U-JOINT BINDS UP & LOCKS. THERE IS A DESIGN FLAW IN THE U-JOINT, THERE IS NO WAY TO GREASE OR LUBE THE U-JOINT. I HAVE NOTIFIED FORD MANY TIMES WITH NO ANSWERS OR RESPONSE. ON THE FORD FORUM SITE, THERE ARE THOUSANDS OF F-150 OWNERS WHO HAVE OR HAD THE SAME PROBLEM WITH TRUCKS WHO'S WARRANTY'S JUST ENDED & HAD TO PAY $500 PLUS TO FIX IT, THERE ARE SOME WHO CRASHED BECAUSE THEY COULDN'T TURN THE WHEEL. I WAS LUCKY BUT IT'S A MAJOR PROBLEM FORD WOULDN'T CORRECT TIL SOMEBODY DIES. I PD.$30,000 FOR THIS TRUCK & OWE $16,000 AND SHOULDN'T HAVE TO PAY $500+ TO BE...

IT FELT AS IF STEERING WAS BINDING WHEN MAKING A TURN. IT WOULD SUDDENLY BREAK FREE AND OVERSTEER WAS A PROBLEM. WHEN COMING OUT OF A TURN THE WHEEL WOULD NOT CENTER ON ITS OWN, BUT HAD TO BE TURNED BACK TO THE STRAIGHT AHEAD POSITION. SPOKE WITH A FORD DEALER AND THEY WANTED AN EXORBITANT CHARGE TO JUST LOOK AT THE VEHICLE AND PROFESSED THEY HAD NOT HEARD OF THE PROBLEM BEFORE. I WENT ON THE INTERNET AND FOUND AT LEAST TWO HUNDRED (200) REFERENCES TO THE EXACT ISSUE. IT WAS THE LOWER STEERING SHAFT UNIVERSAL JOINTS THAT HAD SEVERELY CORRODED. I LUBED THE JOINTS AND THINGS WENT BACK TO NORMAL FOR A FEW DAYS AND THE BINDING RETURNED. I INSTALLED A NEW LOWER SHAFT - FORD PART8L3ZB767B- AND THE TRUCK STEERS LIKE NEW. THE ORIGINAL PART ENDED IN A AND THE B REPRESENTS AN UPDATED VERSION. OBVIOUSLY FORD...

ON MY WIFE'S 2008 F150 QUAD CAB TRUCK AT 37000 MILES, I NOTICE THAT THE TIRES ON THE FRONT OF THE TRUCK WHERE WEARING ON THE INSIDE, SO WITH A TRIP PLANNED FOR FLORIDA, I SET UP FOR OUR LOCAL DEALER TO DO AN ALIGNMENT. SHE DROP OFF HER TRUCK AT THE SERVICE DEPARTMENT AND WENT ON HER WAY, WITHIN 30 MINUTES SHE GOT A CALL FROM THE SERVICE MANAGER. HE INFORMED HER THAT THE UPPER BALL JOINTS WOULD NEED TO BE REPLACED. THE DEALER SAID THAT SINCE THE TRUCKS WARRANTY (THE TRUCK HAS 38000 MILES ON IT) HAD RAN OUT THEY COULD NOT REPLACE THE LOOSE BALL JOINTS. BUT THEY PUT A NEW SET OF TIRES ON AND CHARGED US FOR AN ALIGNMENT. THIS TRUCK HAS NEVER BEEN OFF ROAD AND IT NEVER INDICATED THAT THERE WAS A PROBLEM WITH THE FRONT END AT ALL. I HAVE BEEN TO...