2007 FORD F-150 — Problems, Recalls & Safety Data
N/A
Safety Rating
622
Owner Complaints
7
Recalls
5
Service Bulletins
0
Investigations
Overview of the 2007 FORD F-150
The 2007 FORD F-150 has received a total of 622 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 7 recall campaigns affecting this vehicle, covering issues with EXTERIOR LIGHTING:HEADLIGHTS, ENGINE AND ENGINE COOLING. 5 technical service bulletins have been issued by Ford Motor Company for this model year. The most commonly reported problems involve the Engine (104 complaints), Vehicle Speed Control (49 complaints), and Power Train (46 complaints).
Recalls for the 2007 FORD F-150
NHTSA has recorded 7 recalls for the 2007 FORD F-150, potentially affecting up to 46,457 vehicles.
Recall 09E025000 — EXTERIOR LIGHTING:HEADLIGHTS
| 42,540 vehicles affected
Defect: DOPE, INC. IS RECALLING 42,540 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: DOPE, INC. WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON JULY 28, 2009. OWNERS MAY CONTACT DOPE, INC. AT 1-626-272-1798.
View full details →Recall 08V523000 — ENGINE AND ENGINE COOLING
| 213 vehicles affected
Defect: ROUSH IS RECALLING 213 MY 2007-2008 FORD F-150 TRUCKS ALTERED TO OPERATE USING LIQUID PROPANE INJECTION. THE HYDRO-CARBON PAPER AFFIXED TO THE INSIDE OF THE AIRBOX LID WITH ADHESIVE MAY BECOME DISLODGED DURING OPERATION.
Consequence: THIS FAILURE MAY RESULT IN A LOSS OF PERFORMANCE, ILLUMINATION OF THE MALFUNCTION INDICATOR LAMP (MIL) AND, IN EXTREME CASES, A STALLING OF THE VEHICLE DURING OPERATION WITHOUT NOTICE, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE AIRBOX LID WITH A NEW ONE THAT INCLUDES THE HYDRO-CARBON PAPER WHICH HAS BEEN AFFIXED USING AN ADHESIVE PROMOTER AND GREATER PRESSURE AS RECOMMENDED BY THE MANUFACTURER FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 21,...
View full details →Recall 07E080000 — EXTERIOR LIGHTING:HEADLIGHTS
| 700 vehicles affected
Defect: CERTAIN HEADLAMP ASSEMBLIES IMPORTED AND SOLD AS AFTERMARKET EQUIPMENT BY SONAR AUTO PARTS FOR USE ON 2004-2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
Remedy: SONAR WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL BEGAN ON DECEMBER 14, 2007. OWNERS CAN CONTACT SONAR AT 866-558-4264.
View full details →Recall 07E089000 — EXTERIOR LIGHTING:HEADLIGHTS
| 238 vehicles affected
Defect: CERTAIN SPYDER HEADLAMP REPLACEMENT ASSEMBLIES SOLD FOR USE ON 2004 THROUGH 2007 FORD F150 PICKUP TRUCKS. DURING PRODUCTION, THE HEADLAMPS WERE INTERNALLY MISALIGNED AND THEY FAIL THE PHOTOMETRY REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: THE PURPOSE OF THIS STANDARD IS TO REDUCE TRAFFIC CRASHES AND DEATHS AND INJURIES BY PROVIDING ADEQUATE ILLUMINATION OF THE ROADWAY.
Remedy: SPYDER WILL NOTIFY OWNERS AND OFFER A FULL REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLAMPS. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2007. OWNERS CAN CONTACT SPYDER AT 866-558-4264.
View full details →Recall 07E075000 — EXTERIOR LIGHTING:HEADLIGHTS
| 2,388 vehicles affected
Defect: CERTAIN EAGLE EYES HEADLAMP ASSEMBLIES, P/NOS. FR390-B001L AND FR390-B001R, SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR THE ABOVE LISTED PASSENGER VEHICLES. THE THICKNESS IS UNSTABLE INHIBITING THE PERFORMANCE OF THE UPPER AND LOWER BEAMS WHICH FAILS TO CONFORM TO THE PHOTOMETRIC REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.
Consequence: DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.
Remedy: EAGLE EYES WILL NOTIFY OWNERS AND OFFER REIMBURSEMENT FOR ANY NONCOMPLIANT HEADLIGHTS. THE RECALL BEGAN ON NOVEMBER 6, 2007. OWNERS MAY CONTACT EAGLE EYES AT 1-800-568-1098.
View full details →Recall 07E066000 — EQUIPMENT:ELECTRICAL
| 175 vehicles affected
Defect: CERTAIN CEQUENT 90 DEGREE 7-WAY RIGHT ANGLE ADAPTORS SOLD BY DISTRIBUTORS IN TOW PACKAGES FOR AFTERMARKET SALES TO TOW 5TH WHEEL RV TRAVEL TRAILERS. DUE TO INCORRECT WIRING OF THE HARNESS, THE TRAILER LIGHTS MAY NOT OPERATE PROPERLY.
Consequence: IF THE TRAILER LIGHTS ARE NOT WORKING PROPERLY, A VEHICLE CRASH CAN OCCUR.
Remedy: ALL OF THE DEFECTIVE TOW PACKAGES ARE STILL AT THE DISTRIBUTOR LEVEL AND HAVE NOT BEEN SOLD TO ANY CONSUMERS.
View full details →Recall 07V278000 — FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY
| 203 vehicles affected
Defect: ON CERTAIN TRUCKS BUILT WITH 26 GALLON FUEL TANKS, THE FUEL TANK MAY HAVE A DEPRESSION AT THE SEAM BETWEEN THE TOP AND BOTTOM HALVES OF THE TANK (NOT VISIBLE FROM OUTSIDE THE FUEL TANK). IF A DEPRESSION IS LARGE ENOUGH, FUEL MAY PERMEATE THE FUEL TANK WALL RESULTING IN A FUEL ODOR, OR A "SERVICE ENGINE SOON" INDICATOR LIGHT.
Consequence: IF LEFT UNCORRECTED, A FUEL LEAK COULD EVENTUALLY DEVELOP. A FUEL LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL TANK FREE OF CHARGE. THE RECALL BEGAN ON JUNE 25, 2007. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
View full details →Owner Complaints for the 2007 FORD F-150
622 complaints have been filed with NHTSA for the 2007 FORD F-150. Below is a breakdown by vehicle component.
Most Recent Complaints
After making a sharp right turn tie rod came loose from steering rod. After inspection the threads on the steering rod seem to be too small for the tie rod. The truck has been taken care of and only has 75000 miles on it. The new tie rod I installed was also loose on the steering rod. The threads were not stripped, rusty or damaged in anyway. This truck has never had any work or been damaged. I have never had front end lined up because tires have not had any wear indicating misalignment.
The contact owned a 2007 Ford F-150. The contact stated that when depressing the accelerator pedal while in reverse, the vehicle suddenly accelerated, crossing a field, and crashing into a nearby building, where the vehicle came to a stop. The contact sustained neck injuries, and the front passenger sustained neck injuries as well. The contact did not seek medical attention; however, they intended to do so in the future. The air bags did not deploy. A police report was filed. The rear end of the vehicle was damaged. The vehicle was driven home. The vehicle was taken to Collision Center who diagnosed that the rear of the vehicle needed extensive bodywork and determined the vehicle was totaled. The manufacturer was not informed of the failure. The failure mileage was approximately 300,000. The VIN was not available.
The contact owns a 2007 Ford F-150 The contact stated while driving at an undisclosed speed, the vehicle stalled and jerked. There was no warning light illuminated. The vehicle was restarted; however, the failure recurred. The vehicle was taken to an independent mechanic where it was diagnosed and determined that the transmission had failed and needed to be replaced. The vehicle was repaired; however, the failure recurred, with the check engine warning light illuminated. The vehicle was taken back to the mechanic where it was diagnosed and determined that the spark plugs, and torque converter had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for assistance. The approximate failure mileage was 126,963.
Transmission and rear end jerking when putting in or taking out of park, reverse or drive and now doesn't want to go forward when putting it in drive and I can't get it to shift out and transmission fault light came on and I re set it by taking black cable off battery and put transmission fluid in it and it still does it and also headlights doesn't work on bright and power steering pump makes noise and it's full of fluid I don't know if it is leaking or what small stuff I can deal with but major transmission and engine stuff on truck I can't.
Transmission and rear end jerking when putting in or taking out of park, reverse or drive and now doesn't want to go forward when putting it in drive and I can't get it to shift out and transmission fault light came on and I re set it by taking black cable off battery and put transmission fluid in it and it still does it and also headlights doesn't work on bright and power steering pump makes noise and it's full of fluid I don't know if it is leaking or what small stuff I can deal with but major transmission and engine stuff on truck I can't.
Safety Rating for the 2007 FORD F-150
NHTSA has not yet tested the 2007 FORD F-150 in its New Car Assessment Program.
Technical Service Bulletins for the 2007 FORD F-150
Ford Motor Company has issued 5 technical service bulletins (TSBs) for the 2007 FORD F-150. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
TSB 20-2307 — WHEELS
Some 2003-2020 Expedition/Navigator and 2006-2020 F-150 vehicles equipped with TOD transfer cases may exhibit grinding/clicking/ratcheting noise from the front wheel area. This may be due to partial engagement of the integrated wheel ends (IWE). To correct this condition, follow the Service Procedure steps to remove and cap the vacuum supply...
DORD2Q5Z09 — POWER TRAIN
This SKU is a Transmission Oil Cooler Line. The customer communication requested return of unsold inventory to inspect for the port size being too large. If the port size is too large it will not fit the mating component which would prevent installation, and would therefore have no impact on...
SI-20022 — STRUCTURE:FRAME AND MEMBERS
FORD: SOME 2006-2008 F-150 LARIAT, XLT, AND FX4 VEHICLES (EXCLUDING HARLEY DAVIDSON AND XL) MAY EXHIBIT A WHISTLE NOISE FROM THE GRILLE AREA WHEN TRAVELING AT HIGHWAY SPEEDS OF 65MPH AND GREATER. THIS MAY BE THE RESULT OF A POSSIBLE GAP BETWEEN THE TOP OF THE GRILLE SURROUND TRIM AND...
SI-20022 — STRUCTURE
FORD: SOME 2006-2008 F-150 LARIAT, XLT, AND FX4 VEHICLES (EXCLUDING HARLEY DAVIDSON AND XL) MAY EXHIBIT A WHISTLE NOISE FROM THE GRILLE AREA WHEN TRAVELING AT HIGHWAY SPEEDS OF 65MPH AND GREATER. THIS MAY BE THE RESULT OF A POSSIBLE GAP BETWEEN THE TOP OF THE GRILLE SURROUND TRIM AND...
0719 — FUEL SYSTEM, GASOLINE
EMISSION RECALL. SOFTWARE COULD CAUSE THE CATALYST MONITOR TO STOP FUNCTIONING WHEN CHANGING FUELS. *KB
NHTSA Investigations for the 2007 FORD F-150
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the FORD F-150
- 2002 FORD F-150 — 963 complaints
- 2003 FORD F-150 — 520 complaints
- 2004 FORD F-150 — 2,429 complaints
- 2005 FORD F-150 — 1,363 complaints
- 2006 FORD F-150 — 737 complaints
- 2007 FORD F-150 (current)
- 2008 FORD F-150 — 455 complaints
- 2009 FORD F-150 — 397 complaints
- 2010 FORD F-150 — 1,131 complaints
- 2011 FORD F-150 — 2,939 complaints
- 2012 FORD F-150 — 2,417 complaints
Other FORD Models
- FORD EXPLORER — 42,140 total complaints
- FORD ESCAPE — 34,654 total complaints
- FORD FOCUS — 29,539 total complaints
- FORD FUSION — 28,243 total complaints
- FORD TAURUS — 23,867 total complaints
- FORD WINDSTAR — 19,456 total complaints
- FORD EDGE — 17,247 total complaints
- FORD MUSTANG — 11,551 total complaints