2006 FORD F-150 Engine And Engine Coolingexhaust Systememission Controlcatalytic Convertor Problems
3 NHTSA complaints on file
Engine And Engine Coolingexhaust Systememission Controlcatalytic Convertor Issues in the 2006 FORD F-150
3 engine and engine coolingexhaust systememission controlcatalytic convertor complaints have been filed with NHTSA for the 2006 FORD F-150. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.
3
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
All Engine And Engine Coolingexhaust Systememission Controlcatalytic Convertor Complaints
TWO SEPARATE OCCASIONS I EXPERIENCED A FUEL INJECTOR FAILURE ON MY '06 F-150 WHILE TRAVELING ON I-65 ON 10-10-06 AND ON I-10 ON 10-14-06. I WAS TOLD BY A DEALER IN CULMAN ALABAMA THAT I COULD DRIVE IT ON TO MEMPHIS WITH THE ENGINE LIGHT ON. UPON ARRIVAL IN MEMPHIS DOBBS FORD TOLD ME THERE WAS NOTHING WRONG AND I HAD TO TAKE HIS WORD. ON MY TRIP BACK TO TAMPA THE ENGINE LIGHT CAME ON AGAIN AND I HAD TO TOWED TO AMERICAN FORD IN TALLAHASSEE. THE REPLACED #6 FUEL INJECTOR. LATER, WHILE IN MEMPHIS #5 INJECTOR FAILED AND WAS REPLACED AT LANDERS FORD IN COLLIERVILLE. A FEW DAYS LATER THE ENGINE LIGHT CAME ON AGAIN AND THIS TIME IT WAS THE CATALYTIC CONVERTER, WHICH HAD TO BE REPLACED. *JB
TL*THE CONTACT OWNS A 2006 FORD F-150. THE ENGINE LIGHT ILLUMINATED AND THE VEHICLE BEGAN TO VIBRATE WHILE IN TRAFFIC. THE VEHICLE WAS TOWED TO DEALER, AMERICAN FORD. THE DEALER REPLACED THE # 6 FUEL INJECTOR. AT 9,670 MILES, THE SAME FAILURE RECURRED, AND THE DEALER REPLACED THE # 5 FUEL INJECTOR. AT 9,735 MILES, THE ENGINE LIGHT ILLUMINATED AGAIN. THE DEALER STATED THAT THE CATALYTIC CONVERTER FAILED BECAUSE OF THE FUEL. THE CURRENT MILEAGE IS 10,765, AND FAILURE MILEAGE WAS 7,462.*AK
AFTER ONE WEEK OF OWNERSHIP, ON 9/2/06 THE TRUCK DIESELED WHEN STARTED FOR ABOUT 5 MINUTES BEFORE IDLING. IT COULD NOT BE TURNED OFF. WHEN IT FINALLY IDLED, THE CHECK ENGINE LIGHT WAS LIT, IT IDLED ROUGH, KNOCKED WHEN ACCELERATING OR UNDER A LOAD AND THE GAS MILEAGE DROPPED AS I WAS DRIVING ABOUT 2 MILES PER GALLON. FROM THIS POINT ON, IT WAS HARD TO START. THIS HAPPENED WITH 1000 MILES ON THE TRUCK. IT WAS TAKEN FOR SERVICE AND THE DEALER TOLD US THAT THE CATALYTIC CONVERTER AND OXYGEN SENSOR WAS DEFECTIVE? THIS SEEMS TO BE THE RESULT OF THIS PROBLEM AND NOT THE PROBLEM AS UPSTREAM FUEL/AIR MIXTURE PROBLEMS CAUSE LEANING/RICHING WHICH WILL MANIFEST ITSELF AS CAT OR OXY SENSOR DEFECTS. THESE PARTS WERE REPLACED AND 1 WEEK LATER THE CHECK ENGINE LIGHT HAS RE APPEARED. *NM
Other 2006 FORD F-150 Problem Areas
Engine
74 complaints
Steering
52 complaints
Electrical System
50 complaints
Engine And Engine Cooling
45 complaints
Service Brakes Hydraulic
35 complaints
Air Bags
34 complaints
Fuel System Gasoline
29 complaints
Power Train
28 complaints
Structurebody
27 complaints
Vehicle Speed Control
27 complaints
Fuelpropulsion System
23 complaints
Service Brakes
23 complaints
Unknown Or Other
22 complaints
Engine And Engine Coolingengine
20 complaints
Tires
20 complaints
Suspension
17 complaints
Air Bagsfrontal
11 complaints
Wheels
10 complaints
Service Brakes Hydraulicpedals And Linkages
9 complaints
Visibilitypower Window Devices And Controls
9 complaints
Power Trainautomatic Transmission
8 complaints
Service Brakes Hydraulicpower Assistvacuumhoses Linespiping And Fittings
8 complaints
Engine And Engine Coolingexhaust System
7 complaints
Seat Belts
7 complaints
Structure
7 complaints
Electrical System Instrument Clusterpanel
6 complaints
Exterior Lighting
6 complaints
Structureframe And Members
6 complaints
Exterior Lightingheadlights
5 complaints
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip
5 complaints
Equipment
4 complaints
Service Brakes Hydraulicpower Assist
4 complaints
Suspensionrear
4 complaints
Equipmentapplianceair Conditioner
3 complaints
Power Traindriveline
3 complaints
Power Traindrivelinedifferential Unit
3 complaints
Seats
3 complaints
Service Brakes Hydraulicpower Assisthydraulichoses Linespiping And Fittings
3 complaints
Structurebodydoor
3 complaints
Suspensionfront
3 complaints
Tiressidewall
3 complaints
Tirestreadbelt
3 complaints
Vehicle Speed Controlaccelerator Pedal
3 complaints
Visibilityrearview Mirrorsdevicesexterior
3 complaints
Fuel System Gasolinefuel Injection Systeminjectors
2 complaints
Interior Lighting
2 complaints
Power Traindrivelinecenter Support Bearing
2 complaints
Power Traindrivelinedriveshaft
2 complaints
Steeringelectric Power Assist System
2 complaints
Steeringrack And Pinion
2 complaints
Visibility
2 complaints
Air Bagsfrontaldriver Sideinflator Module
1 complaint
Air Bagsfrontalsensorcontrol Module
1 complaint
Electrical Systemhorn
1 complaint
Electrical Systeminstrument Panelspeedometerodometer
1 complaint
Electrical Systemstarter Assemblysolenoid
1 complaint
Electrical Systemwiringinteriorunder Dash
1 complaint
Electronic Stability Control Esc
1 complaint
Engine And Engine Coolingcooling System
1 complaint
Engine And Engine Coolingexhaust Systemmanifoldheadermufflertail Pipe
1 complaint
Equipment Adaptivemobility
1 complaint
Forward Collision Avoidance Automatic Emergency Braking
1 complaint
Fuel System Diesel
1 complaint
Fuel System Gasolinedelivery
1 complaint
Fuel System Gasolinedeliveryfuel Pump
1 complaint
Fuel System Gasolinestoragetank Assembly
1 complaint
Fuel System Otherdeliveryfuel Pump
1 complaint
Fuel System Otherfuel Injection System
1 complaint
Parking Brakedrivelinehydraulicactuator
1 complaint
Power Trainaxle Assemblyaxle Shaftseal
1 complaint
Power Trainclutch Assembly
1 complaint
Seatsmidrear Assembly
1 complaint
Service Brakes Air
1 complaint
Service Brakes Electric
1 complaint
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipabs Warning Light
1 complaint
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slipcontrol Unitmodule
1 complaint
Service Brakes Hydraulicbrake Fluid Low Warning Lamp
1 complaint
Service Brakes Hydraulicfoundation Componentsdisc
1 complaint
Service Brakes Hydraulicfoundation Componentsdiscrotor
1 complaint
Service Brakes Hydraulicfoundation Componentshoses Linespiping And Fittings
1 complaint
Service Brakes Hydraulicfoundation Componentsmaster Cylinder
1 complaint
Service Brakes Hydraulicpower Assisthydraulic
1 complaint
Service Brakes Hydraulicpower Assistvacuum
1 complaint
Steeringhydraulic Power Assist System
1 complaint
Steeringhydraulic Power Assistpump
1 complaint
Structurebodytailgatehinge And Attachments
1 complaint
Structureframe And Membersunderbody Shields
1 complaint
Suspensionfrontwheel Bearing
1 complaint
Tiresbead
1 complaint
Traction Control System
1 complaint
Vehicle Speed Controlcruise Control
1 complaint
Visibilitydefrosterdefoggerhvac Systemwindshieldelectrical Heating Element
1 complaint
Visibilityglass Siderear
1 complaint
Visibilitywindshield Wiperwashermotor
1 complaint
Visibilitywiper
1 complaint
Wheelsrim
1 complaint