2006 FORD F-150 Engine And Engine Cooling Problems

The contact owns a 2006 Ford F-150. The contact stated that while driving at various speeds, the vehicle lost motive power with an abnormal popping sound coming from the engine compartment. The failure occurred more often while attempting to accelerate or driving uphill. The vehicle occasionally stalled during the failure. The contact released the accelerator pedal slowly and the vehicle then started driving normally. There were no warning lights illuminated. The vehicle was taken to the dealer where it was diagnosed and determined that the cam phaser had failed and needed to be replaced. The vehicle was not repaired due to the cam phaser part no longer being manufactured. The contact stated that the part was no longer in production because the replacement part was defective and failed to fix the vehicle. The contact was informed by the dealer that a newer version of the cam phaser needed to be...

I TRIED TO START MY TRUCK, BUT IT WOULDN'T START. IT TURNED OVER PERFECTLY BUT WOULD NOT START. IT HAD STARTED TWICE EARLIER IN THE DAY. THE FUEL PUMP DRIVER MODULE, LOCATED ABOVE THE SPARE TIRE ON THE FRAME OF THE TRUCK, HAD CORRODED AND FAILED.

THE RIGHT EXHAUST MANIFOLD STUDS HAD BROKEN APPROXIMATELY 5/5/2012, IN WHICH THEY DID NOT TELL ME THE FULL EXTENT OF THE DAMAGES. THEY JUST TOLD ME THE MANIFOLD WAS LEAKING AND THE COST TO REPAIR IT. THIS CAUSED THE MANIFOLD TO WARP AND LEAK. THE DEALER WOULD NOT REPAIR IT UNDER THE EXTENDED WARRANTY. APPROXIMATELY ONE YEAR LATER I CALLED THE WARRANTY COMPANY AND FOUND OUT IT WAS ACTUALLY COVERED. WHEN I HAD TAKEN IT IN, IN MAY 2012 THE DEALER WANTED TO CHARGE 1500.00 FOR THE REPAIRS. THE REPAIRS WERE FINALLY MADE IN MAY OF 2013 TO THE EXHAUST MANIFOLD, BUT NOT TO THE CATALYTIC.CONVERTER WHICH STARTED CAUSING PROBLEMS IN JANUARY OF THIS YEAR. THIS LEAK MAY HAVE CAUSED THE RIGHT CATALYTIC CONVERTER TO FAIL ALSO, BUT HAVE FOUND MANY FORUMS STATING THAT FAILURE OF THE CATALYTIC CONVERTERS ARE A COMMON PROBLEM ON THESE PICK UPS. AT THIS TIME...

VEHICLES MISFIRING AND STUMBLING DURING MODERATE ACCELERATIONS AND CRUISING WHEN A LOAD IS PUT ON MOTOR. ( GOING UP A HILL, SLIGHT INCLINE AND PASSING). SPARK PLUGS WERE UNABLE TO BE REMOVED FOR REPLACEMENT. THE SPARK PLUGS WERE NOT OF GOOD QUALITY AND WOULD NEED TO BE REPLACED MORE OFTEN THAN USUAL. THE MANUFACTURER WAS MADE AWARE, HOWEVER NO ASSISTANCE WAS PROVIDED. $1249.00 TO CHANGE ONE SPARK PLUG. *TR

ON JULY 1, 2012, MY 2006 FORD F-150 SUPER CREW TRUCK CAUGHT ON FIRE WHILE SITTING IN MY DRIVEWAY. THE TRUCK HAD BEEN SITTING UNTOUCHED FOR A WEEK WHEN IT CAUGHT ON FIRE WITHOUT ANY EXPLANATION. FIRE INVESTIGATORS WERE UNABLE TO DETERMINE THE CAUSE OF THE FIRE BECAUSE THE TRUCK WAS APPROXIMATELY 90% BURNED. *TR

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT TOOK THE VEHICLE FOR A ROUTINE OIL CHANGE WHEN HE WAS ADVISED BY THE MECHANIC THAT FOUR OF THE SPARK PLUGS WERE UNABLE TO BE REMOVED FOR REPLACEMENT. THE SPARK PLUGS WERE NOT OF GOOD QUALITY AND WOULD NEED TO BE REPLACED MORE OFTEN THAN USUAL. THE MANUFACTURER WAS MADE AWARE, HOWEVER NO ASSISTANCE WAS PROVIDED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE CURRENT AND FAILURE MILEAGE WAS 72,000.

WHILE PULLING VEHICLE INTO GARAGE THE VEHICLE SUDDENLY ACCELERATED. I DID NOT HAVE A FLOOR MAT ON THE FLOOR. THIS IS ABOUT THE FOURTH TIME THIS HAS HAPPENED SINCE I BOUGHT THE VEHICLE NEW. I TOOK THE VEHICLE TO THE FORD DEALER APPROXIMATELY 2 YEARS AGO AND THEY COULD NOT DUPLICATE OR DETERMINE THE PROBLEM. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE TRAVELING 40 MPH, THE VEHICLE ATTEMPTED TO STALL AND WOULD NO LONGER ACCELERATE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE FAILURE WAS CAUSED BY A BAD SPARK PLUG DESIGN. THE CONTACT WAS ALSO INFORMED THAT THE SPARKS HAD FRACTURED EACH TIME THEY ATTEMPTED TO REMOVE THE SPARK PLUGS. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 52,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HIM THAT THE SPARK PLUGS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000.

THE NUMBER 3 SPARK PLUG WAS BLOWN OUT OF THE CYLINDER HEAD. THIS IS THE SECOND OCCURRENCE OF THE SAME SPARK PLUG. THE FIRST INCIDENT OCCURRED ON 10/21/2011 AT 82781 MILES. THE FIRST REPAIR WAS COMPLETED BY MIKE NAUGHTON FORD IN AURORA CO. THE MECHANIC INSTALLED A SLEEVE INTO THE CYLINDER HEAD TO REINSTALL A NEW SPARK PLUG. THE MECHANIC EXPLAINED THAT THIS IS A KNOWN PROBLEM BECAUSE THE CYLINDER HEAD ONLY HAS 3-4 THREADS FOR THE SPARK PLUG TO SCREW INTO. *TR

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE DEALER PERFORMED A DIAGNOSTIC AND LOCATED THE FAILURE AS THE ENGINE LOCKING DUE TO DEFECTIVE PARTS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 128,183.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE HAVING ROUTINE MAINTENANCE PERFORMED ON THE VEHICLE, THE DEALER ADVISED HIM THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 52,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING 55 MPH THERE WAS A KNOCKING AND BANGING NOISE IN THE ENGINE WHICH CAUSED THE VEHICLE TO MALFUNCTION. THE VEHICLE WAS THEN DRIVEN HOME. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 66,000. RVK

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING HIGHWAY SPEEDS, THE WRENCH WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE THEN DECELERATED, LOST POWER AND STALLED. THE DEALER AND THE MANUFACTURER WERE CONTACTED BUT DENIED ANY ASSISTANCE WITH REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 52,000.

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT THE ENGINE EXHIBITED AN ABNORMAL NOISE WHILE DRIVING AT ANY SPEED OVER 30 MPH. THE VEHICLE WAS TAKEN TO THE LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE NUMBER SEVEN AND EIGHT SPARK-PLUGS. THE MECHANIC ADVISED THAT THE SPARK PLUGS HAD SEPARATED FROM THE HOLDER AND CAUSED A PIECE OF THE SPARK PLUG TO PENETRATE THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 116,000. UPDATED 10/27/11*LJ UPDATED 12/06/2011 *LN

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT WAS DRIVING 70 MPH WHEN THE VEHICLE EXHIBITED A LOUD, ABNORMAL NOISE FROM UNDER THE HOOD FOLLOWED BY THE VEHICLE STALLING. THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AS THE NUMBER SEVEN SPARK PLUG HAVING RELEASED FROM THE COIL HEAD CAUSING THE COIL ASSEMBLY TO FAIL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 83,000.

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20-55 MPH, THERE WAS EXCESSIVE HESITATION WITH AN INTERMITTENT ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED A SPARK PLUG FRACTURED WITHIN THE ENGINE AND IT WOULD NEED A TUNE-UP. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

TO START OUT, IT SHOULD NOT COST $1249.00 TO CHANGE ONE SPARK PLUG... DUE TO FORD'S DESIGN FLAW ON THEIR MOTOR CRAFT SPARK PLUGS WHICH CAUSES TH EM TO BREAK EXTREMELY EASY, I AM BEING CHARGED TO TEAR DOWN MY ENTIRE ENGINE TO RETREIVE ONE SPARK PLUG!!! THIS IS FORD'S FAULT AND I FEEL THEY SHOULD BE HELD LIABLE FOR THE COST OF REPAIR. I HAVE BEEN TOLD BY SEVERAL MECHANICS THAT FORD DESIGNED THEIR MOTOR CRAFT PLUGS TO BREAK!! FORD IS ALSO THE ONLY ONE WHO CAN FIX THE PROBLEM. IT WAS NOT UNTIL I PAID OVER $400.00 TO CHANGE 2 COIL PACKS THAT I WAS HIT WITH THIS PRICE. THIS F-150 WOULONLY DO 30-35 MPH ON THE INTERSTATE HIGHWAY...I COULD HAVE BEEN KILLED IF I WAS HIT FROM BEHIND!! THESE SPARK PLUGS SHOULD BE RECALLED AND I SHOULD BE REIMBURSED! MY TRUCK IS STILL AT THE FORD DEALERSHIP...

SPARK PLUGS ARE SNAPPING OFF BECAUSE OF HEAT IN THE ALUMINUM HEAD.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE HAVING A TUNE-UP PERFORMED AT THE DEALER, ONE OF THE SPARK PLUGS BECAME LODGED IN THE CYLINDER HEAD. THE DEALER ADVISED THAT THE CYLINDER HEAD WOULD BE SENT OUT TO HAVE THE SPARK PLUG MACHINED OUT. THE VEHICLE WAS LEFT WITH THE DEALER WHERE THE CONTACT WAS AWAITING REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 91,000.

OVER A PERIOD OF 3 MONTHS, I WAS EXPERIENCING A ROUGH IDLE, LOSS OF POWER WHEN ACCELERATING ON FLAT SURFACES AS WELL AS CLIMBING HILLS. I TOOK IT TO A MECHANIC WHO SAID IT WAS 2 BAD COIL PACKS. THEY FIXED IT AND 2 WEEKS LATER SAME INCIDENT OCCURRED AND THEY REPLACED IT. DURING THIS TIME, I COULD ALWAYS SMELL THE ODOR OF GASOLINE. AFTER THE LARGE EXPENSE I WAS ASSUMING, I CALLED THE FORD DEALER WHERE I BOUGHT MY 2006 F-150 LARIAT. THE SERVICE MANAGER OF 22 YEARS APPARENTLY NEVER HEARD OF THE COIL PACK GOING BAD ALONG WITH THE SPARK PLUGS BREAKING DUE TO THIS. AFTER ARGUING FOR A WEEK WITH THEM, THEY FINALLY AGREED TO PAY FOR THE REPLACEMENT OF ALL 8 COIL PACKS. DURING THIS SEQUENCE, A COIL PACK WAS GOING BAD WEEKLY AND I HAD TO CONTINUALLY HAVE IT IN THE SHOP. FORD NEEDS TO...

2006 FORD F150 WITH 39,000 MILES ACTING FUNNY. TOOK IT TO GARAGE AND WAS CATALYTIC CONVERTER. STATED THEY WOULDN'T COVER IT BECAUSE I DROVE TO GARAGE. *TR

WHAT A SHOCKER, I GO TO THE FORD DEALER FOR THE 100K TUNE UP FOR MY F-150 KING RANCH ORIGINAL COST $450. ALMOST TWO WEEKS LATER, TRUCK STILL ISN'T FINISHED COST IS AT $3, 500 STILL CAN GO. THEY DON'T KNOW YET UNTIL THEIR FINISHED PUTTING EVERYTHING BACK TOGETHER. 7 OF THE 8 PLUGS BROKE, TWO WOULD NOT COME OUT. FINALLY, THEY GOT ONE OF THE TWO OUT. THE ONE IS SEIZED UP PRETTY GOOD. THE HAD TO TAKE THE HEAD OFF AND WAITING ON THE OUTCOME. I'M UP IN ARMS ON WHAT TO DO. I DON'T HAVE AN EXTRA $3, 000 LAYING AROUND TO PAY FOR THIS PLUS THE PRICE CAN STILL GO UP. HOW CAN THEY NOT TELL YOU THIS UP FRONT AND KEEP PADDING THE PRICE AND NOT KNOWING WHAT ITS GOING TO COST UNTIL YOU PICK YOUR VEHICLE UP. PLEASE CONTACT ME, I WOULD LIKE TO...

OEM SPARKPLUG IN 2006 F-150 KING RANCH (3-VALVE ENGINE). EXPERIENCED PREMATURE PLUG FAILURE AND RESULTING HIGH REPLACEMENT COSTS DUE TO DEFECTIVE SPARKPLUG DESIGN. PLUG FAILURE RESULTED IN SLUGGISH ENGINE PERFORMANCE THAT LED TO A NEAR ACCIDENT. *TR

TL*THE CONTACT OWNS A 2006 FORD F150. WHILE DRIVING APPROXIMATELY 15 MPH, THERE WAS AN UNEXPECTED REDUCTION IN THE ENGINE POWER. THE CONTACT CONTINUED TO DRIVE TO HIS RESIDENCE WITH AN EXCESSIVE LOSS OF ENGINE POWER DURING ACCELERATION. THE VEHICLE WAS TOWED FROM THE RESIDENCE TO AN AUTHORIZED DEALER WHERE THEY STATED THE ENGINE WOULD NEED TO BE REPLACED AS A RESULT OF DEFECTIVE FUEL INJECTORS. THE ESTIMATED REPAIR COST WAS $8,000. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000.

TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THEY HAD TO REPLACE THE IGNITION COILS FIVE TIMES IN LESS THAN ONE YEAR. THE FAILURE CAUSED THE SPARK PLUGS TO CRACK AND HAVE TO BE REPLACED. THE SPARK PLUGS THAT CRACKED WERE ON TWO SEPARATE CYLINDERS. THE FAILURE CAUSED FUEL TO BE SPILLED ONTO THE ENGINE WHICH COULD CAUSE PROBLEMS WITH THE CATALYTIC CONVERTER. THE CONTACT STATED THAT THE VEHICLE WOULD SPUTTER AT TIMES WHEN HE TRIED TO ACCELERATE TO PASS SOMEONE. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THERE WAS NO REMEDY FOR THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 21,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 49,000.

TL-THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE ACCELERATING OR DECELERATING, THE VEHICLE SUDDENLY HESITATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THERE WERE ONLY TWO QUARTS OF OIL IN THE ENGINE INSTEAD OF THE SEVEN IT WAS SUPPOSED TO CONTAIN; THE DEALER COULD NOT FIGURE OUT WHY THE VEHICLE WAS LOSING SO MUCH OIL. THE DEALER ALSO STATED THAT THE TIMING CHAIN CAUSED THE VEHICLE TO HESITATE. THE FAILURE MILEAGE WAS APPROXIMATELY 23,400 AND THE CURRENT MILEAGE WAS 23,423. UPDATED 01/13/11*LJ THE CONSUMER STATED IT WAS DIFFICULT TO ET THE VEHICLE OUT OF 4-WHEEL DRIVE. ALSO, THE TIMING CHAIN WAS MAKING A SCRAPING NOISE DUE TO LACK OF OIL. UPDATED 03/31/11

I HAVE A 2006 F150 WITH THE 5.4 ENGINE. I HAVE NEVER REPLACED THE SPARK PLUGS AND THE TRUCK HAS 144K MILES. I AM NOW STUCK WITH ~$1800 TO PULL THE CAB TO GET TO THE HEADS TO GET THE PLUGS OUT. 2 MECHANICS CANNOT GET IT OUT NORMALLY. I AM TOLD THAT A FIX FOR STRIPPING THE HEADS IS WITH A SLEAVE THAT I CANNOT GET OUT OF CYLINDER #8. I WAS NEVER INFORMED TO HAVE THE PLUGS CHANGED AT 80KTO 100K MILES. I WOULD NOT HAVE KNOWN ANYTHING ABOUT THIS. I THINK THE FIX IS A POOR DESIGN AND I WAS DESIGNED TO COVER ANOTHER PLUG ISSUE. I AM WONDERING WHY 2 WRONGS DO NOT MAKE A RIGHT AND I AM WONDERING WHAT RECOURSE I HAVE. I HAVE PURCHASED OR TRADED 3 NEW TRUCKS AND CURRENTLY DRIVE A MUSTANG, ALL PURCHASED IN THE LAST 4 YEARS. I AM...

MY VEHICLE IS SHOWING EXTREME HESITATION IN ACCELERATION WHEN ENTERING A HIGHWAY OR PASSING ANOTHER VEHICLE. DURING THESE PROCESSES, MY VEHICLE WILL START BACKFIRING AND MISSING. THE "CHECK ENGINE" LIGHT COMES ON AT THIS TIME. I TOOK MY VEHICLE TO TWO DIFFERENT STATE LICENSED MECHANICS, AND CHAPMAN FORD DEALERSHIP IN PHILADELPHIA. ALL THREE TOLD ME THE PLUGS SHOULD HAVE LASTED 100,000 MILES OR BETTER AND THAT THEY HAVE HAD PROBLEMS WITH THE DESIGN OF THE ENGINE AND THESE PLUGS ARE VERY COMPLICATED TO REPLACE. SPECIAL TOOLS WOULD BE NEEDED TO REPLACE THEM. THEY ALSO SAID IT IS VERY COMMON THESE PLUGS WOULD BREAK OFF WHEN BEING REMOVED. THE COST TO REPLACE THE PLUGS WOULD BE APPROXIMATELY $400 TO $550, WITH AN ADDITIONAL COST IF ANY PLUGS BREAK. THE DEALERSHIP TOLD ME THERE IS NO RECALL WHEN THERE SHOULD BE. THIS IS A MAJOR PROBLEM AT THE EXPENSE OF THE OWNER,...

CERTAIN FORD MAKES, MODELS AND MOTORS ARE KNOWN FOR EJECTING SPARK PLUGS WHICH DESTROYS THE IGNITION COIL AND IS A FIRE HAZARD. THEY ARE ALSO KNOWN FOR THE SPARK PLUG BREAKING WHILE TRYING TO REMOVE THEM WHICH IS A FINANCIAL BURDEN ON THE CUSTOMER AS WELL AS A RISK THE MOTOR WHILE TRYING TO RESOLVE THE ISSUE. THERE ARE TSB'S ON THIS. I NEVER RECEIVED A LETTER FROM FORD TO GIVE ME THE HEADS UP ON THIS AND LEARNED AFTER THE FACT OF ATTEMPTING TO GET A TUNE UP.........NOW STUCK WITH TWO BROKEN SPARK PLUGS STUCK IN THE MOTOR AND HAVE NO IDEA HOW MUCH THIS IS GOING TO COST ME IN THE END. I AM WITHOUT MY TRUCK WHILE WE WAIT FOR A TOOL THAT WILL HOPEFULLY REMOVE THE BROKE OFF SLEEVES. IF IT DOESN'T WORK I WILL HAVE TO HAVE THE HEAD PULLED AND WHO KNOWS IF IT...

MY 2006 FORD F-150 HAD A SPARK PLUG BROKE OFF AND NOW THE ONLY WAY TO FIX THIS IS TO REMOVE THE HEAD APPROX 3000.00 TO CORRECT. FORD SAYS THEY ARE AWARE OF THE PROBLEM BUT THEY REFUSE TO DO ANYTHING ABOUT IT. THE VEHICLE ONLY HAS 45,000 MILES AND THE TRUCK IS NOW NON DRIVABLE. WHY AREN'T THEY BEING HELD ACCOUNTABLE FOR SOMETHING WHEN THEY KNOW IT IS A PROBLEM WITH THIS STYLE VEHICLE. *TR

I PURCHASED A FORD F-150 IN 2006. I AM AT MY 100,000 MAINTENANCE AND THE SPARK PLUGS HAVE TO BE CHANGED. I SPOKE WITH A REPRESENTATIVE AT THE FORD REPAIR SHOP WHO TOLD ME THAT I WOULD HAVE TO BRING MY TRUCK IN 24 HOURS EARLY TO SOAK THE PLUGS BECAUSE THEY WILL BREAK IN THE MOTOR AND I WILL HAVE TO PAY TO HAVE THEM REMOVED. I FOLLOWED THERE INSTRUCTIONS ON MONDAY MORNING AND TOOK THE TRUCK TO THEM. THEY CALLED AND INFORMED ME THAT THEY WOULD HAVE TO TAKE THE HEAD OFF MY MOTOR TO REMOVE THE PLUGS AT A CONSIDERABLE EXPENSE TO ME. IT DOES NOT SEEM FAIR TO ME THAT IF FORD MECHANICS PUT FORD PLUGS INTO THERE FORD TRUCKS AND WHEN THERE FORD MECHANICS TRY TO REMOVE THE FORD PLUGS FROM THE FORD VEHICLE THEY BREAK AND I HAVE TO PAY FOR THE DAMAGES. *TR

I'M AN OWNER OF A 2006 FORD F-150 5.4 ENGINE. I HAVE HAD 3 ENGINE FAILURES WITH THIS TRUCK THE FIRST ONE WAS AN INJECTOR. SECOND WAS A TIMING SOLENOID. THIRD WAS A COIL. I HAD OVER 100,000 KMS. I HAD MY PLUGS CHANGED. THE MECHANIC ENDED UP BREAKING OFF 6 PLUGS IN THE ENGINE. THIS IS A VERY EXPENSIVE REPAIR, IT SHOULD ONLY BE REGULAR MAINTENANCE. I HAVE DONE A GREAT DEAL OF RESEARCH AND HAVE FOUND IT IS A VERY WIDESPREAD PROBLEM. I FEEL OWNERS SHOULD BE COMPENSATED. ANY ADVICE I CAN RECEIVE WOULD BE HELPFUL THANKS IN ADVANCE. *TR

TL*THE CONTACT OWNS A 2006 FORD F150. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED. THE FAILURE OCCURRED IN JANUARY 2009, JUNE 2009 AND AGAIN IN OCTOBER 2009. THE FAILURE BECAME MORE FREQUENT AND PROGRESSIVELY WORSE OVER TIME. THE VEHICLE WOULD COMPLETELY SHUT DOWN WITH NO WARNING LIGHTS; SHE WOULD BE ABLE TO RESTART AFTER THREE ATTEMPTS. SHE TOOK THE VEHICLE TO THE DEALERSHIP AND WAS TOLD THAT THEY COULD NOT DUPLICATE THE FAILURE. SHE CALLED THE MANUFACTURER WHO STATED THAT SHE SHOULD TAKE THE VEHICLE BACK TO THE DEALER. THE VEHICLE HAS NOT BEEN REPAIRED TO-DATE. THE CURRENT MILEAGE WAS APPROXIMATELY 74,000. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.

SPARKPLUG POPPING OUT WHILE DRIVING 60 MPH ON HIGHWAY ,THOUGHT IT WAS A BLOW OUT OF MY TIRE HAD TO QUICKLY MOVE OVER TO THE RIGHT AND EXIT .FOUND OUT IT WAS THE SPARKPLUG . LATER AFTER A FEW PHONE CALLS TO DEALERS AND MECHANICS THIS IS A PROBLEM THAT HAPPENS REGULARLY AND THAT FORD KNOWS ABOUT THIS PROBLEM. THIS SHOULD NEVER HAPPEN. I FEEL CHEATED AND I WOULD HAVE NEVER BOUGHT THIS TRUCK F-150 AT ALL IF I NEW ABOUT THIS. AFTER ALL THIS I WILL CONTACT THE MEDIA AND LOCAL PAPERS TO LET PEOPLE KNOW ABOUT THIS PROBLEM. I ALSO FOUND OUT IF WILL START A FIRE IF I KEPT DRIVING. *TR

2006 FORD F150 80,000KM IN FOR SERVICE THE DEALER CALLED AND INDICATED WHILE REMOVING THE PLUGS 6OUT OF 8 BROKE A COMMON ISSUE WITH THE 5.4 TRITON 3VALVE ENGINE. QUOTE $2000 OR POSSIBLY MORE. I PURCHASED THE TRUCK FOR OVER $50,000 AND NOW IT WILL NOT RUN AND HAS SAT FOR 2 MONTHS, THE FORD DEALER ALSO HAS THREE OTHER TRUCKS WITH THE SAME ISSUE THEY HAVE ADVISED TO TAKE THE TRUCK ELSEWHERE???? ALL SHOPS IN MY CITY ARE REFUSING THIS ENGINE TO WORK ON WHAT TO DO I'M STRANDED BY THE MANUFACTURER TO WHOM I HAVE BEEN A LOYAL CUSTOMER. AS I RESEARCH THIS ISSUE IT HAS BECOME SO WIDESPREAD I DON'T UNDERSTAND WHY FORD MOTOR COMPANY HAS NOT BEEN TAKEN TO TASK OVER THIS VERY SERIOUS ISSUE. *TR

MY 2006 F 150 HAS SHUT OFF TWICE ON ME WHILE DRIVING ON THE FREEWAY. AND AFTER BARELY AVOIDING THE SEMI BEHIND ME I MANAGED TO PULL OFF THE SIDE OF THE FREEWAY AND TURNED THE KEY OFF , AFTER WAITING ABOUT A MINUTE I TURNED THE KEY ON AND THE CAR RAN FINE FOR ABOUT THREE MONTHS AND THEN IT HAPPENED AGAIN ON THE FREEWAY.THE LIGHT COMES ON TO SIGNIFY THAT THE PROBLEM IS THE ELECTRONIC THROTTLE CONTROL, BUT I CALLED AROUND A FEW PLACES AND THEY ALL SAY THE SAME THING ,THEY CANT DO ANYTHING UNLESS THE CHECK ENGINE LIGHT IS ON. DOES SOME ONE HAVE TO DIE IN ORDER FOR FORD TO FIX THIS PROBLEM.. IS IT WORTH LOSING A LIFE OVER? *TR

2004AND 2006 FORD F250 AND 150 SPARKS PLUGS BLOW OUT AND COSTLY REPAIR ON FACTORY INSTALL PLUGS. *TR

TL*THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT NOTICED AN UNIDENTIFIED WARNING INDICATOR ILLUMINATE ON THE INSTRUMENT PANEL. THE VEHICLE STALLED, BUT WAS ABLE TO BE RESTARTED IMMEDIATELY. SHE TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT IT WOULD COST $700 TO REPAIR THE VEHICLE. THE MANUFACTURER DID NOT ASSIST. SHE IS IN THE PROCESS OF HAVING THE VEHICLE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 40,000.

FORD TRUCK LOSSES THROTTLE CONTROL. THE VEHICLE GOES INTO IDLE AND THROTTLE IS NOT RESPONSIVE. I HAD TO COAST TO THE SIDE OF THE ROAD IN TRAFFIC TO PREVENT AN ACCIDENT. *TR

2006 SUPERCREW 4X4 F150 THAT BEGAN MISSING AND SHAKING BADLY ALONG WITH RICH SMELL OF GASOLINE THIS MORNING. WAS TAKEN INTO SHOP WHERE IT LATER HYDROLOCKED AND WAS NOW UNABLE TO START. ASSESSMENT BY FORD TECHNICIAN FOUND THE ENGINE TO HAVE A FAULTY INJECTOR ON CYLINDER 6 THAT WAS STUCK IN THE OPEN POSITION ALLOWING FUEL TO DUMP DIRECTLY INTO CYLINDER UNTIL FULL AND THE PISTON WAS UNABLE TO MOVE ANYMORE APPARENTLY RESULTING IN SOME BENT RODS ACCORDING TO TECHNICIAN. WAS ADVISED THAT ENGINE WAS BLOWN AND NEEDED $9500 FOR REPLACEMENT ENGINE SINCE VEHICLE WAS JUST OUT OF WARRANTY AT 56,000 MILES. FOUND OUT THAT MANY OF THE 2005 MODELS OF THIS VEHICLE HAD RECALLS ON THE SAME INJECTORS MAKING THIS TYPE OF REPAIR COVERED, BUT MY VIN DOES NOT SHOW THIS RECALL SINCE IT A 2006 MODEL. THIS BOTHERS ME BECAUSE MY TRUCK WAS ACTUALLY SHOWN TO BE MANUFACTURED...

UPON STARTING OF THE VEHICLE THERE WAS A LOUD POP FOLLOWED BY SMOKE ENTERING THE CAB THROUGH VENTS AND THEN COMPLETE LOSS OF BRAKES, DEALER SAID IT WAS A PROBLEM WITH THE INTAKE MANIFOLD. *TR

SPARK PLUG BROKE INSIDE OF ENGINE WHILE REPLACING. AFTER FURTHER INVESTIGATION I FOUND THAT THIS IS A WELL KNOWN PROBLEM THAT FORD HAS REFUSED TO RECALL EVEN THOUGH THEY HAVE CHANGED MECHANICAL PROCEDURES FOR REPLACING PLUGS AT THE DEALERSHIP. I AM NOW STUCK WITH A BIG BILL BECAUSE FAULTY MANUFACTURING. *TR

RANDOM STALLING, LOOSES POWER AND COMPLETELY SHUTS DOWN EVERYTHING. 2006 FORD F150. *TR

TL*THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 40 MPH, THE CONTACT HEARD A RATTLING NOISE UNDERNEATH THE VEHICLE. THE DEALER STATED THAT THE A/C COMPRESSOR WAS SEPARATING. THE DEALER MADE THE REPLACEMENT, HOWEVER, THE NOISE CONTINUED. THE CONTACT TOOK THE VEHICLE TO THE DEALER, BUT THEY WERE UNABLE TO DETERMINE THE CAUSE OF FAILURE. IN ADDITION, THE VEHICLE FAILED TO START. AS OF SEPTEMBER 24, 2007, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE FAILURE MILEAGE WAS 495 AND CURRENT MILEAGE WAS 23,900.