2000 FORD F-150 Engine And Engine Coolingenginegasoline Problems

13 NHTSA complaints on file

Check any vehicle history by VIN - Free vehicle history report

Engine And Engine Coolingenginegasoline Issues in the 2000 FORD F-150

13 engine and engine coolingenginegasoline complaints have been filed with NHTSA for the 2000 FORD F-150. Of these, 1 involved a crash, 0 involved a fire, and 0 resulted in injury.

Complaints

Crashes

Fires

Injuries

Deaths

All Engine And Engine Coolingenginegasoline Complaints

#10161531 | July 5, 2006

BLOWN SPARK PLUG ON MY 2000 FORD F-150 5.4 TRITON. KNOWN TO ONLY HAVE HALF THE REQUIRED THREADS IN THE CYLINDER HEAD FOR THE SPARK PLUG, HAVE HAD NEITHER COMPENSATION OR A RECALL. THIS IS VERY DANGEROUS AS IT HAPPENED TO ME TOWING A BOAT GOING ON TO THE INTERSTATE. DESTROYED THE PLUG, THE COIL PACK (COP STYLE) AND THE INTAKE ELBOW OF MY AFTER MARKET INTAKE SYSTEM. OVER $600 IN DAMAGES. *JB

#10160692 | June 25, 2006

FORD TRITON 5.4L V-8 HEADS. ALUMINUM HEADS ARE SO POORLY ENGINEERED THAT THEY WILL NOT RETAIN THE SPARK PLUGS UNDER NORMAL LOADS. OVER $5,000 IN REPAIR COSTS, FORD REFUSES TO ACKNOWLEDGE ANY PROBLEM. *NM

#10156401 | April 28, 2006 Crash

WAS DRIVING ON FREEWAY FORD F150 PICKUP ENGINE BLOW OUT THE #1 SPARK PLUG, SECOND 6 MTHS AGO SAME ENGINE BLOW OUT THE #4 REAR SPARK PLUG NEAR PASSENGER, NOW HAVE TO REPLACE ENGINE VERY COSTLY. *NM

#10146016 | December 23, 2005

THE PASSENGER SIDE REAR SPARK PLUG BLEW OUT OF THE ENGINE HEAD. THIS TRUCK HAS 54,000 MILES ON IT AND IS VERY WELL MAINTAINED. REPAIR ESTIMATES ARE IN EXCESS OF $3,000.00. THIS HAPPENED IN A WELL TRAVELED AREA AND IT WAS ME AND NOT MY WIFE AND KIDS STRANDED. THERE IS AN OBVIOUS FLAW IN THE HEAD DESIGN THAT FORD HAS SINCE RECTIFIED. IT IS OUTRAGEOUS THAT A $30,000 TRUCK THAT IS WELL MAINTAINED SHOULD HAVE THIS KIND OF FAILURE 18,000 MILES OUT OF FACTORY WARRANTY. *NM

#10107811 | January 24, 2005

ON THE 2000 FORD F-150 WITH THE 4.6 LITER ENGINE, A FAILURE OF THE THREADS IN THEIR ALUMINUM CYLINDER HEADS CAUSES THE SPARK PLUG AND COIL-OVER-PLUG TO BECOME DISLODGED AND THREADS STRIPPED. THE CYLINDER HEAD REQUIRES MAJOR REPAIRS TO BECOME SERVICEABLE ONCE MORE. A SIMPLE STEEL SLEEVE (LIKE A "BIG-SERT") INSTALLED AT THE FACTORY WOULD PROBABLY SOLVE THE PROBLEM AND SAVE MAJOR PROBLEMS FOR THE CONSUMER LATER. ALSO, IF THIS FAILURE WERE TO HAPPEN WHILE VEHICLE WERE IN MOTION, THE SPARK PLUG COMING IN CONTACT WITH THE FUEL RAIL OR AN INJECTOR AND STILL FIRING COULD CAUSE A CATASTROPHIC LOSS AND POTENTIAL ACCIDENTS, INJURY, OR EVEN DEATH. *NM

#10060210 | March 2, 2004

I BOUGHT A USED 2000 F-150 4X4 TRUCK IN OCTOBER 2003. THE VEHICLE HAD 36,000+ MILES. IT CURRENTLY HAS 43,000 MILES. I HAD THE OIL CHANGED AT A FORD DEALERSHIP AND THEY REPORTED THE HEAD GASKET HAS A SEVERE LEAK. I'VE BEEN TOLD BY THE DEALERSHIP WHERE I PURCHASED THE VEHICLE THAT THEY HAD NO RECORD OF THE GASKET LEAKING. THIS WAS NOT A FORD DEALERSHIP. I BELIEVE THE PREVIOUS OWNER WAS AWARE OF THE PROBLEM AND TRADED THE VEHICLE. I REALIZE THIS IS A USED VEHICLE AND PROBLEMS DO ARISE, BUT THIS IS A PROBLEM FORD MOTOR COMPANY IS AWARE OF. SEE MFG. BULLETIN NUMBERS 012110, 0214, 15793. THIS IS MY THIRD FORD TRUCK WITH NO PROBLEMS WITH THE PREVIOUS VEHICLES. THE QUESTION IS, SINCE FORD WAS AWARE OF THIS PROBLEM, SHOULDN'T THEY BE RESPONSIBLE TO HAVE IT REPAIRED WHEN THERE IS SO FEW MILES ON THE TRUCK? PLEASE...

#10007784 | February 19, 2003

SPARK PLUGS THREADS STRIP AND SHOOT PLUG OUT

#10005719 | February 12, 2003

SPARK PLUG EJECTED FROM THE MOTOR WHILE DRIVING APPROXIMATELY 15 MPH. RESULTED IN DRASTIC LOSS OF POWER AND EXTREMELY LOUD EXHAUST LEAK NOISE.

#9005776 | March 8, 2002

ENGINE FAILURE

#8004215 | February 19, 2002

VEHICLE IS LEAKING OIL FROM OTHER PARTS OF ENGINE. DEALERSHIP IS AWARE OF PROBLEM. *AK THE CONSUMER STATED THAT AFTER THE WORK WAS DONE STILL HAD A PROBLEM. *YH

#866923 | August 7, 2000

VEHICLE WILL BEGIN TO HONK AND THEN IT STALLOUT WHILE DRIVING DOWN THE ROAD. SOMETIMES VEHICLE WILL START BACKING UP, AND SOMETIMES IT WILL NOT.DEALER CANNOT DETERMINE CAUSE. COMPUTER HAS BEEN REPLACED AND WIRING HAS BEEN REPAIRED, BUT DEFECT STILLS OCCURS. *AK

#784719 | July 24, 2000

POSSIBLE ENGINE FAILURE IS CAUSING THE VEHICLE TO STALL INTERMITTENTLY WHEN REACHING THE TOP OF A FAIRLY STEEP HILL. DEALER RAN DIAGNOSTIC TEST BUT WERE UNABLE TO DUPLICATE THE PROBLEM.

#720860 | April 11, 2000

MY TRUCK DISPLAYS AN IDLE VIBRATION THROUGHOUT THE CHASIS, I HAVE HAD IT TO THE DEALER 5 TIMES AND THEY HAVE NO FIXED IT, AND NOW ARE SAYING THAT IT IS NORMAL *AK

Other 2000 FORD F-150 Problem Areas

← Back to 2000 FORD F-150 overview