1995 FORD EXPLORER Suspension Problems

THE STEERING COLUMN AND ALL THE PARTS ASSOCIATED WITH THE STEERING OF THE VEHICLE WERE AFFECTED WHEN THE BOLTS THAT HOLD THE CLAMPS THAT SECURE THE BUSHINGS TO THE STEERING COLUMN BEGAN TO LOOSEN. I EXAMINED THE AREA CAREFULLY AND NOTICED THAT BECAUSE THE BOLTS LOOSENED, THE CLAMPS WERE GIVEN TOO MUCH PLAY. WITHIN A SHORT WHILE, A MONTH OR TWO, THE ENTIRE STEERING COLUMN AND THE SHIFTER WERE COMPLETELY SECURED BY ONE BROKEN CLAMP THAT HELD ITS PLACE BECAUSE OF THE BUSHINGS AND A LOOSE BOLT. THE OTHER CLAMP WAS ALSO BROKEN BUT WAS LAYING ON THE FLOOR BOARD. IT WASN'T AN EXPENSIVE FIX. I CUSTOMIZED A METAL CLAMP FOR EACH OF THE TWO PLACES THE WENT. THEY ARE THE SAME CLAMPS THE ELECTRICIANS USE TO SECURE CABLES AND WIRES TO THE WALLS AND CEILINGS. I USED THE ONES MADE FROM BRONZE. THEY ARE MORE PLIABLE TO SHAPE FOR...

TL* THE CONTACT OWNS A 1995 FORD EXPLORER. THE CONTACT STATED THAT THE SWAY BAR WAS FRACTURED. THE VEHICLE WAS TAKEN TO INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE LINK ROD NEEDED TO BE REPLACED. THE FAILURE RECURRED TWICE OVER A ONE YEAR PERIOD. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

I HAVE A 1995 FORD EXPLORER AND THE DEALER REFUSES TO HONOR SOME OF THE RECALLS THAT HAVE BEEN ORDERED FOR MY VEHICLE THE RECALLS ARE LISTED BELOW RECALL DATE: MAR 15, 1995 MODEL AFFECTED: 1995 FORD EXPLORER SUMMARY: THE INNER TIE ROD ASSEMBLIES WERE IMPROPERLY MANUFACTURED AND CAN FRACTURE CAUSING SHAKING OR SHIMMY AT LOW SPEEDS. DEALERS WILL INSPECT THE INNER TIE RODS AND REPLACE THE SUSPECT TIE RODS. POTENTIAL UNITS AFFECTED: 49300 RECALL DATE: MAR 15, 1995 MODEL AFFECTED: 1995 FORD EXPLORER SUMMARY: IN SOME OF THE VEHICLES, BRAKE TUBES WERE MISROUTED BETWEEN THE MASTER CYLINDER AND THE HYDRAULIC CONTROL UNIT AND RESULTS IN EXCEEDING THE ALLOWABLE STOPPING DISTANCES AS REQUIRED BY FMVSS NO. 105, "HYDRAULIC BRAKE SYSTEMS." IN ADDITION, SEALS WITHIN THE MASTER CYLINDER COULD BE ABRADED BY THIS CONDITION OVER TIME RESULTING IN AN INTERNAL LEAK AND A FURTHER REDUCTION IN BRAKE PERFORMANCE. REMEDY: DEALERS WILL...

FRONT DRIVER'S SIDE SWAY BAR LINK FRACTURED. THE LINK HAD ALREADY BEEN REPLACED AS PART OF THE NOV. 28, 2000 NHTSA RECALL 00V402000, WHICH WAS PERFORMED BECAUSE, "UNDER CERTAIN CONDITIONS, A FRONT SWAY BAR LINK CAN FRACTURE." *TR

CONSUMER'S CONCERN OVER THE HANDLING BY FORD MOTOR COMPANIES OF THE CRUISE CONTROL DEACTIVATION SWITCH RECALL.*MR ONE NOV 11, 2003 THE CONSUMER TOOK THE VEHICLE TO THE DEALER BECAUSE THE BRAKE LIGHT ILLUMINATED, BRAKE FLUID WAS LEAKING AND THE CRUISE CONTROL NO LONGER FUNCTIONED. THE DEALER QUOTED THE CONSUMER $5000 TO FIX THE VEHICLE. THE CONSUMER DECLINED THE REPAIR, PURCHASED THE PART HIMSELF AND REPLACED IT HIMSELF. THE CONSUMER RECENTLY HEARD ABOUT THE RECALL AND CONTACTED THE MANUFACTURER TO SEE IF HE COULD RECOVER THE MONEY HE SPENT TO REPLACE THE FAULTY PARTS. THE MANUFACTURER INDICATED THAT THE CONSUMER'S VEHICLE WAS NOT INCLUDED IN THE RECALL. THE CONSUMER'S VEHICLE ALSO EXPERIENCED STALL DURING ACCELERATION, EXCESSIVE TIRE WEAR, PULLING TO THE RIGHT AND TRANSMISSION FAILURE.

FORD MOTOR COMPANY OFFERED TO REIMBURSE THE CONSUMER FORTY FIVE DOLLARS FOR REPAIRS DONE INSTALLING THE FRONT SWAY BAR LINKS. FORD MOTOR COMPANY WOULD ONLY DO THIS IF THE CONSUMER EXECUTED AND DELIVERED A GENERAL RELEASE FOR ANY AND ALL CLAIMS THAT SHE MAY HAVE HAD AGAINST THEM. * PH *JB

FRONT STABLIZER AND SWAY BAR HAVE BROKEN IN THE PAST 4 YEARS, FRONT TIRES CAN NOT BE ALIGNED AND WEAR OUT FASTER BECAUSE OF THIS FAILURE. *AK CONSUMER STATES FRONT STABALIZER LINKS WERE REPLACED DUE TO ON GOING COMPLICATIONS, BOTH FRONT WHEELS BEARING HUB ASSEMBLY FAILED, THE FRONT BRAKE PADS AND ROTORS WERE REPLACED, AND THE FRONT BALL JOINTS HAVE SOME PLAY. *YH

CONSUMER WAS INVOLVED IN AN ACCIDENT, WHEN CALLING MANUFACTURER,HE WAS INFORMED ABOUT RECALL 00V402 AND WAS TOLD THAT IF THE MISSING LINK HAD CAUSED VEHICLE TO CRASH COMPANY WOULD REPLACE, VEHICLE,HOWEVER CONSUMER RECEIVED A LETTER STATING THAT VEHICLE WAS TOO DAMAGED FOR INSPECTION.

THE CONSUMER REQUESTED REIMBURSEMENT FOR THE TWO SWAY BARS THAT WERE REPLACED PRIOR TO RECALL NOTICE 00V-402. NLM

PRIOR TO RECALL 00T-005 AND 00V-402 THE VEHILCE EXPERIENCED SUDDEN LOSS OF CONTROL, THE CONSUMER BELIEVES THE SWAY BAR LINKS MALFUNCTIONED CAUSING THE LOSS OF CONTROL AND THAT THE TIRE ALSO BLEWOUT DURING THIS ACCIDENT, THE CONSUMER SUFFERED A BUSTED AND SWOLLEN LIP AND BODY ACHES (FIRESTONE). NLM

THE SWAY BAR LINK FAILED PRIOR TO RECALL NOTICE 00V-402, THE CONSUMER REQUEST REIMBURSEMENT. NLM

THE VEHICLE BEGAN EXPERIENCING HANDLING PROBLEMS DUE TO BROKEN SWAY BARS WHICH FAILED PRIOR TO RECALL NOTICE 00V-402 AND CAUSED THE TIRES TO WEAR, THE CONSUMER REQUESTS REIMBURSEMENT. NLM

THE FRONT STABILIZER BARS FAILED PRIOR TO RECALL NOTICE 00V-402 . NLM

SWAY BAR LINK FAILED PRIOR TO RECALL 00V402, DEALER WOULD NOT REIMBURSE CONSUMER FOR PRIOR RECALL REPAIR EXPENSES, CONSUMER IS REQUESTING REIMBURSEMENT. *SLC

OWNER RECEIVED RECALL NOTICE (00V-402) IN DECEMBER, ARRIVED AT DEALERSHIP FOR APPOINTMENT ON 1/24/01, TOLD NO PARTS AVAILABLE. CJ

CONSUMER HAD RECALL 00V402 COMPLETED ON VEHICLE AND IS REQUESTING REIMBURSEMENT. *SLC

WHILE TRAVELING SWAY BAR LINKS BROKE. RECALL 00V402000/ MANUFACTURER'S RECALL 00S47 FOR STABILIZER BAR DIDN'T COVER LOWER BALL JOINT THAT BROKE. DEALER WOULDN'T COVER WHAT WAS CAUSED BY RECALL. *AK

CONSUMER RECEIVED MANUFACTURER'S RECALL 00S47 FOR SWAY BAR LINK. CONTACTED DEALER, MATHIEW FORD IN WINCHENDON, MA TELE#9782970001, DEALER REFUSED TO DO RECALL REPAIRS BECAUSE VEHICLE HAD A SALVAGE TITLE. CONSUMER WAS STILL DRIVING VEHICLE. DEALER CLAIMED HE WAS BEING TOLD BY FORD MANUFACTURER NOT TO PERFORM RECALL. *AK CONSUMER IS REQUESTING REIMBURSEMENT FOR REPAIRS. *SLC

RECALL 00V402000/ STABILIZER BAR LINK STUD; HAD MADE AN APPOINTMENT FOR 25 JANUARY, 2001 ON 2 JANUARY 2001, AT 6 PM. CONSUMER WAS INFORMED RECALL WAS NOT DONE DUE TO NO PARTS. LEFT VEHICLE UNTIL JANUARY 26, 2001, STILL NO PARTS. DEALER THEN TOLD CONSUMER SHE COULD LEAVE VEHICLE FOR A WEEK IN CASE PARTS CAME IN. SHE THEN CALLED FORD COMPANY WHERE SHE WAS TOLD THAT SHE WOULD JUST HAVE TO WAIT. *AK

FLIPPED 1995 LIMITED EXPLORER 5 TIMES IT IS TOTALED

ACTUALLY HAD TWO VERY SIMILAR SITUATIONS ALTHOUGH ONE WAS ON ICE AND THE OTHER DUE TO HYDROPLANING. WAS TRAVELING ON INTERSTATE IN BOTH INSTANCES AT BELOW SPEED LIMIT AND CAR SEEMED TO FLOAT OFF TO THE RIGHT AND THEN GO INTO UNCONTROLLABLE SPINS BOTH INSTANCES WERE NEARLY IDENTICAL WITH THE LAST ONE RESULTING IN CAR CAREENING INTO DITCH AND STRIKING GUARDRAIL I DO NOT FEEL I WAS TRAVELING AT HIGH RATE OF SPEED IN EITHER INSTANCE BUT AM NOT FRIGHTENED TO RIDE IN VEHICLE DURING ANY KIND OF INCLEMENT WEATHER. THANKS DANIEL. *AK( DOT NUMBER: TIRE SIZE: 15 )

ALREADY HAVING PROBLEMS WHEN PURCHASED, CAR PULLED RIGHT,ROTATE TO BACK FIXED PULL. *AK( DOT NUMBER: TIRE SIZE: P235/75R15 )

PE00 020; CONSUMERT WAS TRAVELING ABOUT 75MPH ON HIGHWAY AND FELT HEAVY VIBRATION INSIDE OF VEHICLE . HE WENT TO PULL OVER ONTO THE SHOULDERS. AND VEHICLE TOOK A 270 DEGREE SPINN OUT. THEN, VEHICLE HIT A ROAD SIGN, AND IT FLIPPED INTO A DITCH. THERE WERE MINOR SKRATCHES. *AK

ONGOING PROBLEM WITH VEHICLE VIBRATING WHILE TRAVELING AT 45 MPH ON UP. FIRESTONE REPLACED TIRES, AND THE DEALER REPLACED THREE OF THE WHEELS, AND BALANCED THE TIRES. HOWEVER, PROBLEM IS REOCCURRING. *AK

WHILE DRIVING AT A LOW SPEED VEHICLE SHIMMIES AND SHAKES. IT IS NOTICED MORE AT LOW SPEEDS. ALSO, WHEN IT'S WINDY OUTSIDE CONSUMER DOESN'T HAVE A LOT OF CONTROL OF THE STEERING WHEEL. *AK

SUSPENSION SYSTEM FAILURE, CAUSING INSTABILITY.