1993 FORD EXPLORER Suspensionfront Problems

THE WHOLE '!@#$% FRONT END OF MY 93 EXPLORER KEEPS FALLING APART AFTER FIXING IT TWICE AND IT IS STARTING TO DO IT AGAIN. I CANT KEEP TIRES ON IT AT ALL. *TR

MULTIPLE FAILURES, CONTINUALLY BRAKE PROBLEMS. THE VEHICLE ALSO OVERHEATED, THERMOSTAT REPLACED SEVERAL TIMES. A/C COMPRESSOR MALFUNCTION, ETC. *BF A BLOWOUT RIPPED THE RUNNING BOARD ASSEMBLY, THE ABS LIGHT WAS INTERMITTENT AND THE MECHANIC COULD NOT FIGURE OUT WHY, THE BRAKES LOCKED UP ON THE VEHICLE AND VIOLENTLY SKIDDED TO A STOP, THE EXHAUST WAS REPLACED TWICE, THERE WAS A NOISE THAT LINGERED ON IN THE FRONT END AND A LOUD CREAKING SOUND. *SC

THE PROBLEM FIRST DISPLAYED ITSELF AT 8000 MILES, I CONTACTED THE DEALER AND WAS TOLD TO BRING IT IN. ON 7/14/93 THEY DID A FRONT END ALIGNMENT. WHEN I PICKED IT UP I QUESTIONED THE UNUSUAL TIRE WEAR ON THE FRONT, THEY TOLD ME THERE WAS NOTHING THEY COULD DO, ABOUT THIS. THIS CONDITION PERSISTED AND I AGAIN CONTACTED THE DEALER AND WAS TOLD TO BRING IT IN ON 10/19/193. THEY PERFORMED ANOTHER FRONT END ALIGNMENT AND ROTATED THE TIRES DUE TO THE EXTERME WEAR. THE PROBLEM CONTINUED I AGAIN CALLED THE DEALER AND WAS ADVISED TO BRING IT IN ON 2/11/94 AT WHICH TIME ANOTHER REALIGNMENT WAS PERFORMED AND A PART REPLACED. THE PROBLEM ONLY BECAME WORSE I AGAIN CONTACTED THE DEALER AND WAS STALLED REPEATEDLY. IN DESPERATION I CONTACTED THE FORD REP IN ATLANTA (MATT DARNELL) AND REQUESTED HIS ASSISTANCE. AGAIN I WAS STALLED ALMOST IGNORED, THE PROBLEM...

NO SUMMARY

NO SUMMARY

THE VEHICLE HAS A SEVERE VIBRATION/SHAKING PROBLEM WITH THE FRONT SUSPENSION. I HAVE HAD IT CHECKED WITH NO PROBLEMS ACCORDING TO MY LOCAL DEALER IN BLACKFOOT, ID. THE TIRES ARE BRAND NEW AND THEY ARE BALANCED PROPERLY. FORD HAS REFUSED TO FIX THIS PROBLEM SINCE THE WARRANTY HAS EXPIRED. I WROTE THEM A LETTER EXPLAINING THAT IT IS A SAFETY ISSUE AND NOT A WARRANTY ISSUE BUT THEY BLEW IT OFF AS AN EXPIRED WARRANTY ISSUE. FORD HAS ADMITTED TO THE DEFECT THROUGH PUBLISHING OF A TSB # 96-4-15. IT RESOLVES A VIBRATION/SHAKING PROBLEM WITH MY MODEL AT VARIOUS SPEEDS OF WHICH MY PROBLEM EXISTS AT 60-75 MPH. IT VIOLENTLY SHAKES THE FRONT END TO MAKE IT DIFFICULT TO BRAKE HEAVILY AND MAINTAIN CONTROL ON ALL ROAD SURFACES. THE FIX IS A NEWLY REDESIGNED LEFT AND RIGHT ENGINE MOUNT AND AN ADDITION OF A LATERAL SHOCK ABSORBER INSTALLED IN THE...

CONSUMER WAS DRIVING APPROXIMATELY 35MPH WHEN CRASHED INTO A GAURDRAIL. MECHANIC REPLACED FENDER/BUMPER/RADIATOR/GRILL/ RADIALAND RADIAL SUPPORT/BALL JOIN, AND INSTALLED LIFT KIT. HOWEVER, VEHICLE STILL VIBRATED, EVEN MORE WHEN DRIVING WITH 4 WHEEL DRIVE. ALSO, WHEN MAKING A TURN STEERING LOCKED UP IN 4 WHEEL DRIVE. CONSUMER THEN REPLACED ALL FOUR TIRES. VEHICLE STILL VIBRATED. MECHANIC SAID THE RADIUS ARM WAS BENT, AND REPLACED IT. ALSO, REPLACED THE SPRINGS SHOCKS/ ABS SENSORS/ REAR SHIELD AND BEARINGS. *AK

WHILE DRIVING AT HIGHWAY SPEEDS, VEHICLE VIBRATES BADLY AND CONSUMER CAN LOSE CONTROL OF VEHICLE. DEALER SAID HAD TO REPLACE A BUSHING, BUT NOW THEY ARE SAYING NEEDS TO HAVE A NEW "KIT". PLEASE PROVIDE FURTHER INFORMATION AND VIN#.

NO SUMMARY

VIBRATION, SOMETIMES SEVERE, AT APPROXIMATELY 50 MPH AND FASTER. FORD DEALER AWARE OF THE PROBLEM, BUT SAY THEY CANNOT REPAIR. DEALER HAS SUGGESTED THAT TIRES AND SHOCKS BE REPLACED, WHICH I HAVE DONE BUT TO NO AVAIL. HAD FRONT END ALIGNED, LEFT CAMBER SHIM INSTALLED, RADIUS ARM BUSHINGS REPLACED, TIRES BALANCED AND RE-BALANCED, FRONT RIGHT TIRE REPLACED BUT THE PROBLEM STILL PERSISTS. VIBRATION BECOMES SEVERE AT HIGHER SPEEDS. NOT SAFE. I HAVE CONTACTED THE FORD MOTOR COMPANY CUSTOMER SERVICE REP., BUT THEY TELL ME TO SEE THE DEALER! GETTING THE RUN-AROUND. VEHICLE IS ONLY 5 YEARS OLD WITH ONLY 68000 HIGHWAY MILES. THIS SHOULD NOT HAPPEN! I HAVE SPENT APPROXIMATELY $1,000 TO REPAIR THE PROBLEM WITHOUT SUCCESS. PLEASE HELP ME! I AM CONCERNED THAT, WITH ALL OF THE VIBRATION, SOMETHING WILL LOOSEN WHILE I'M DRIVING WITH MY WIFE AND CHILDREN CAUSING AN ACCIDENT. I FEEL THIS IS A DESIGN FLAW...

FRONT END SUSPENSION CONTINUALLY VIBRATES REPLACEMENT OF THE SHOCKS DID NOT REMEDY VIBRATION.

DRIVER EXPERIENCING SHIMMY AND VIBRATION FROM VEHICLE AT 65 MPH. THE TIRES WERE CHANGED OUT, ROTATED BALANCED AND THE PROBLEM HAS NOT BEEN RESOLVED.

VEHICLE VIBRATES.

VEHICLE PULLS WHEN APPLYING BRAKES. *SD

THERES NO CAMBER ADJUSTMENT. TT THIS CAUSES EXCESS TIRE CUPPING AND WEAR. *SLC

THE VEHICLE PULLING TO THE RIGHT SIDE CAN NOT FIND THE THE PROBLEM. TT

THE VEHICLE PULLING TO THE RIGHT SIDE CAN NOT FIND THE THE PROBLEM. TT

VEHICLE VIBRATES AT 60MPH, CANNOT FIX FRONT END. TT CONSUMER HAS REPLACED TIRES AND VIBRATION IS STILL PRESENT. *SLC

VEHICLE VIBRATES 20 TO 65 MPH; VIBRATES MORE WHEN APPLYING BRAKES. VEHICLE PULLS VERY HARD TO RIGHT, SOMETIMES TO LEFT; POSSIBLY CAUSED BY FAULTY ENGINE MOUNTS.

PURCHASE NEW HAD TO REPLACE THE ROTOR, FRONT END ALIGNMENT WEAR OUT THE FRONT TIRE . TT

THE VEHICLE SHAKES AT SPEEDS EXCEEDING 55MPH, THE DEALER CANNOT FIND PROBLEM, MFG HAS A SERVICE BULLETIN OUT, BUT NO REMEDY. TT

THE FRONT END JUST EXPLODED FOR NO REASON. PLEASE DESCRIBE. TT

NOISE WHEN GOING OVER BUMPS OR TURNING VEHICLE.

VIBRATION OF FRONT END AT SPEED BEYOND 65 MPH. TT

VEHICLE VIBRATES WHEN GOING OVER 60 MPH. TT