2004 FORD EXCURSION Engine Problems

TOTAL LOSS OF ENGINE POWER MASSIVE AMOUNT BLACK SOOT EXITING EXHAUST WHILE DRIVING RECALL # 05V270000 WAS NOT PERFORMED ON VEHICLE ( I AM THE ORIGINAL OWNER) NEVER RECEIVED NOTICE IN MAIL AND DEALER SOMEHOW MISSED THIS "WORK" AND FORD SHOULD HAVE FOLLOWED THROUGH ON THIS SITUATION. OTHER REPAIRS DONE TO THIS VEHICLE TO "FIX" THIS PROBLEM WAS TO DRAIN THE FUEL TANK (ALGAE IN FUEL WAS THE EXCUSE-NO ALGAE) FUEL PUMP AND FILTER RAIL (NOT PROBLEM) TWO TURBOCHARGERS WERE REPLACED DUE TO EXCESSIVE SOOTING (ONE WARRANTY ONE AT MY EXPENSE) EGR VALVES AND A CAM SENSOR (FORD KNOWS THE PROBLEMS EXIST BECAUSE FORD DISCOUNTINUED THE 6.0 LITRE MOTOR) THIS PROBLEM HAS OCCURED MULTIPLE TIMES OVER MY OWNERSHIP.

TL* THE CONTACT OWNS A 2004 FORD EXCURSION. WHILE DRIVING, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT PLACED THE GEAR INTO NEUTRAL, WHILE IN TRAFFIC, AND RESTARTED THE VEHICLE. AFTERWARDS, THE VEHICLE WAS ABLE TO DRIVE NORMALLY. THE VEHICLE WAS TAKEN TO FUTURE FORD LINCOLN (LOCATED AT 650 AUTOMALL DR, ROSEVILLE, CA 95661, (888) 656-7577) WHERE A WIGGLE TEST WAS PERFORMED BECAUSE A FAILURE CODE COULD NOT BE FOUND. THE INJECTION CONTROL PRESSURE WAS REPLACED WITH A USED PART. THE CONTACT STATED THAT THE VEHICLE WAS WORSE AFTER THE REPLACEMENT OF THE USED PART AND THE STEERING WHEEL BECAME DIFFICULT TO STEER. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER WHO STATED THAT A WIRE HARNESS WAS NEEDED TO REPAIR THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 05V270000...

VEHICLE ENGINE EJECTS SPARK PLUG FROM CYLINDER HEAD. *TR

REPEATEDLY EJECTS SPARK PLUGS FROM CYLINDER HEAD. *TR

ON 11/26/13 DRIVING BACK FROM ATLANTA HEADING SOUTH LEAVING THE FLORIDA WELCOME CENTER ON I-75, 4 MILES NORTH OF JENNINGS ON I-75 SOUTH JENNINGS. LEAVING THE WELCOME CENTER THE VEHICLES ENGINE LOST POWER WHILE TRYING TO MERGE BACK INTO TRAFFIC WITHOUT ANY PRIOR INDICATION OF A PROBLEM. THE LOSS OF POWER CAUSED US TO HAVE TO DIVERT FROM THE LANE UNTIL WE COULD GAIN MORE SPEED. THE VEHICLE HAD NO ACCELERATING POWER ABOVE 40 MPH EVEN WITH THE GAS PEDAL DEPRESSED ALL THE WAY TO THE FLOOR. THERE WERE NO CHECK ENGINE LIGHTS ON OR ANY ABNORMAL INDICATORS. I CALLED THE FORD CUSTOMER CARE CENTER ON 12/12/13 AND THEY ACKNOWLEDGE THEY HAVE A PROBLEM WITH THE ERG FAILING DUE TO COLLECTING CARBON AND SOOT BUILD UP. THEY HAVE NOT ISSUED ANY SERVICE BULLETINS TO OWNERS LETTING THEM KNOW THERE IS AN ISSUE OR HAVE ISSUED A MAINTENANCE PROGRAM TO TRY...

WHILE DRIVING THE VEHICLE, IT WILL GO INTO A REDUCE POWER MODE OR SOMETIMES STALL. THIS HAS HAPPENED AT VARIOUS SPEEDS, FROM AROUND TOWN TO HIGHWAY DRIVING. VERY DANGEROUS CONDITION WHEN TRYING TO MAKE LEFT TURNS AND POWER IS LOST OR ENGINE STALLS. ALSO ENGINE FAILS TO START OR STARTS AND STALLS RIGHT AWAY ON OCCASION. CALL FORD CUSTOMER RELATIONS AND DEALER AND THEY TELL ME MY VIN IS NOT COVERED UNDER THE RECALL. I AM EXPERIENCING THE SAME SYMPTOMS BUT I AM NOT COVERED. DON'T WANT TO SPEND MORE MONEY AT DEALER IF THEY DON'T KNOW WHAT IS HAPPENING AND HOW TO FIX IT. *TR

TL* THE CONTACT OWNS A 2004 FORD EXCURSION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 TO 45 MPH, THE VEHICLE STALLED WITHOUT ANY WARNING. THE VEHICLE WAS LATER TOWED TO A DEALER. AFTER DIAGNOSIS, THE CONTACT WAS INFORMED THAT THE PROBLEM MAY BE THE FUSE NEAR THE TRANSMISSION. THE VEHICLE WAS REPAIRED. APPROXIMATELY THREE MONTHS LATER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN BACK TO THE DEALER. AFTER DIAGNOSIS, THEY ADVISED HER THAT THE FUSE FAILED AGAIN DUE TO THE BRACKET CHAFING THE WIRES. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 89,000. THE CURRENT MILEAGE WAS APPROXIMATELY 90,000. THE VIN WAS UNAVAILABLE.