2005 FORD ESCAPE Electrical System Problems

WAS DRIVING DOWN THE HWY AND THE ENGINE SHUTS DOWN .THE PROBLEM THE PCM THAT CONTROLS THE ENGINE GOES OUT. FORD KNOWS THIS BUT THEY DONT FEEL ITS A SAFTY ISSUE. I DONT KNOW ABOUT YOU BUT DRIVING AND HAVING YOUR CAR SHUT OFF SCARES ME. THANK GOD THE TRACTOR TRAILOR WAS ABLE TO GET TO THE OTHER SIDE.THE REPAIR WILL COST 2500 DOES NO GOOD IF NOBODY MAKES THEM FIX THE PROBLEM. *TR

THE CHECK ENGINE LIGHT CAME OUT ON DASHBOARD,I TOOK THE CAR TO DEALER,AND I WAS TOLD THAT THE FUEL RAIL PRESSURE NEEDED TO BE CHANGED,FEW MONTHS AGO I TOOK MY CAR TO THE DEALER AND THEY DID A COMPLETE DIAGNOSE AND NOTHING WAS WRONG,I SEARCH ABOUT THIS PROBLEM,AND FOUND OUT THAT SO MANY OWNERS OF THE SAME TYPE OF CAR HAVE EXACTLY THE SAME COMPLAINT,IT SEEMS THAT FORD MOTOR HAD THE SAME PROBLEM WITH OTHER TYPE OF CARS ON THE SAME ITEM(FUEL RAIL PRESSURE) AND HAD A RECALL ON THESE CARS,WHY NOT ON FORD ESCAPES??? *TR

THE ENGINE CONTROL MODULE ON MY 2005 FORD ESCAPE FAILED, ALONG WITH THE COILS. THIS HAPPENED WHILE SITTING IN A BUSY INTERSECTION. *TR

MY WIFE WENT TO ON A TRIP AND THE VEHICLE STARTED TO MISFIRE, WENT TO A FORD DEALER, MECHANIC IDENTIFIED THE PROBLEM; IGNITION COIL #4 FAILED. SHE ASKED WHAT NEEDED DONE TO FIX PROPERLY SO SHE WOULD BE SAFE AND HAVE NO MORE TROUBLE. HE SAID TO REPLACE COIL, PLUGS, AND WIRES. THAT WAS DONE. ON THE WAY HOME IT HAPPENED AGAIN, CAR SHUT OFF W/O WARNING ON I95 @65 MPH. PROBLEM PERSISTED AND FINALLY WOULD NOT START AND HAD TO BE TOWED. MY MECHANIC DISCOVERED FORD SRB 09-2-6. A PROBLEM IDENTIFIED BY FORD BUT NOT MADE PUBLIC. I CONTACTED DEALER; HE WAS AWARE OF SRB BUT DID NOT ACT ON IT OR INFORM US ABOUT IT. WE ARE NOW FACED WITH A BILL 2X LARGER THAN IT WOULD HAVE BEEN IF DEALER WOULD HAVE FOLLOWED SRB. HE PUT MY WIFE AT RISK (NEARLY HAD A FEW ACCIDENTS) AND FORD...

MY WIFE GOT INTO HER ESCAPE TO RETURN HOME AND IT WOULD NOT RUN PROPERLY. IT WAS MISSING BADLY AND LACKED ADEQUATE POWER TO PULL ITSELF. I TOOK MY ESCAPE TO THE REPAIR SHOP AND WAS APPAULED BY THEIR FINDINGS. I AM GOING TO QUOTE DIRECTLY FROM THE DIAGNOSTIC REPORT I RECEIVED. "SOME ESCAPE/MARINER VEHICLES BUILT ON OR BEFORE 10/3/2005 , EQUIPPED WITH A 3.0L ENGINE MAY EXHIBIT A MALFUNCTION INDICATOR LAMP (MIL) ON WITH TWO OR MORE DIAGNOSTIC TROUBLE CODES (DTC'S) FOR COIL ON PLUG (COP) PRIMARY CIRCUIT FAULTS (P0351-P0356). THIS MAY BE DUE TO THE COP AND POWERTRAIN CONTROL MODULE (PCM) REACTING TO RADIO FREQUENCY INTERFERENCE FROM THE SPARK PLUGS." MY REPAIR TECHNICIAN TOLD ME THAT THIS WAS A COMMON PROBLEM WITH VEHICLES LIKE MINE. AFTER SEARCHING THE WEB, I FOUND ONE PERSON WHOSE ESCAPE DIED WHILE ON THE INTERSTATE AND DURING HEAVY TRAFFIC AND PLENTY OF OTHERS...

THE FIRST ISSUE I HAD WITH MY CAR WAS IN DECEMBER OF 2010. I IMMEDIATELY TOOK MY CAR TO A REPAIR PLACE AND THEY TOLD ME THAT THE COILS AND THE PLUGS WERE OUT AND THAT THEY NEEDED TO BE REPLACED. I ASSUMED THAT THIS WAS JUST TIME TO GET THIS REPAIRED BECAUSE MY CAR WAS RIGHT OVER THE 100,000 MILE MARK. EVERYTHING SEEMED FINE UNTIL MAY OF 2011 WHEN THE PROBLEM RETURNED. THIS TIME I TOOK MY CAR TO A FORD SERVICE CENTER. THIS TIME I NOTICED THAT MY CAR WOULD RUN OK UP TO ABOUT 35 MPH AND THEN AFTER THAT SPEED IT WOULD START JERKING. IF I TAKE MY FOOT OFF THE GAS IT STOPS, BUT IF I LEAVE MY FOOT ON THE GAS AND CONTINUE TO ACCELERATE, THE CAR SHUTS OFF COMPLETELY. I HAVEN'T TAKEN MY CAR ANYWHERE THAT I HAVE TO DRIVE OVER 45MPH BUT...

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE ATTEMPTING TO DECELERATE AT 55 MPH, THE VEHICLE LOST ALL POWER. THE CONTACT NOTICED THAT THE CHECK ENGINE, OIL, AND ABS WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS ADVISED THAT THE COILS AND PCM FAILED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT AND THE FAILURE MILEAGES WERE 100,000. THE VIN WAS UNAVAILABLE.

DASHBOARD BACK LIGHTING FAILED CAUSING LEFT SIDE DASH BLACKOUT OF TEMPERATURE GAUGE & LEFT SIDE OF SPEEDOMETER. RADIO BACK LIGHTING FAILED CAUSING A BLACKOUT OF THE LEFT SIDE RADIO BUTTONS. *TR

IN MY 2005 FORD ESCAPE XLT V6 3.0L ON 11/16/11, I WAS DRIVING EAST BOUND ON I55 TOWARDS CHICAGO AT APPROXIMATELY 55 MPH WHEN THE ENGINE STARTED BAD MISFIRING AND THE COMPLETELY DIED (NO POWER OR ENGINE). WITH NO POWER STEERING AND NO BRAKES, I ATTEMPTED TO STEERED TOWARD THE SHOULDER. I WAITED ABOUT 10 MINUTES AND TRIED TO RESTART AND WAS UNABLE. I HAD THE VEHICLE TOWED TO ROESCH FORD 333 W GRAND AVE BENSENVILLE, IL 60106. I WAS ADVISED BY THE SERVICE MANAGER THAT THE ENGINE WAS MISFIRING ON 4 OF THE 6 CYLINDERS AND THAT THEY WOULD NEED TO REPLACE THE PCM, 6 COILS, 6 PLUGS AND CALIBRATE, TOTAL $2,114.21. I DECIDED TO DO SOME RESEARCH ONLINE AND FOUND NUMEROUS PEOPLE EXPERIENCING THE SAME PROBLEM. THERE ARE MULTIPLE TSB: TSB 05-11-1,TSB 09-02-06 TSB 09-02-06 AND TSB 10-18-10. THE PROBLEM IS: THE WRONG SPARK PLUGS WERE INSTALLED AT...

MY 2005 FORD ESCAPE WAS BOUGHT NEW. THE FIRST SITUATION OCCURRED IN 2007. CAR STARTED MISFIRING ON MAJOR NYC HIGHWAY AT 50 MILES AN HOUR AT NIGHT AND FINALLY STALLED OUT. MADE IT TO SIDE OF HIGHWAY AND WAITED FOR TOW TRUCK. THAT SITUATION COST ME A NEW COMPUTER COILS AND WHATEVER ELSE WAS NECESSARY IN ORDER TO REPAIR CAR ADDING UP TO 1300. AFTER THAT AND AT THE PRESENT TIME, NOVEMBER 20011 I HAVE EXPERIENCED SEVERAL STALLINGS ON HIGHWAYS LEAVING ME IN UNSAFE SCENARIOS THAT COULD HAVE BEEN EXTREMELY DANGEROUS. I HAVE REPLACED COUNTLESS COILS, PLUGS, HAD CATALYTIC CONVERTER ISSUES, ALONG WITH ALARM TRIPPING, THE INTERIOR LIGHTS GOING OFF FOR NO REASON AND NOW AFTER A TRIP FROM NY TO VA MY CAR LET ME DOWN AGAIN. DELAYING MY TRAVEL HOME AND HAVING TO STAY IN VA FOR REPAIR FINDING OUT I NEED ANOTHER COMPUTER. MAJOR DISAPPOINTMENT AND A...

THE PCM MODULE ON THE FORD ESCAPE DIES DURING OPERATION. WHILE DRIVING IN MID TRANSIT THE CAR DIED, AND WOULD NOT RESTART IN THE MIDDLE OF THE ROAD. I HAVE HEARD OTHER STORIES OF PEOPLE DRIVING ON THE HIGHWAY, AND HAVING THIS PROBLEM HAPPEN TO THEM GOING 60,70, AND EVEN 80 MPH. MINE WAS ONLY GOING ABOUT 30, AND NO CARS WERE BEHIND ME. THE MODULE HAS BEEN REPLACED TWICE, AND COULD BE EXTREMELY DANGEROUS IF DIED ON A BUSY HIGHWAY OR INTERSTATE. *TT

ON SEVERAL AT LEAST 12 OCCASIONS, WHILE DRIVING BETWEEN 30-65 MPH THE CAR (2005 FORD ESCAPE) STUBBLES AND THE THEFT LIGHT APPEARS. IN ONE CASE WE WERE ABOUT TO PASS A VEHICLE ON A TWO LANE HIGHWAY AND HAD TO BRAKE AND SWERVE SUDDENLY TO AVOID A HEAD-ON COLLISION. VEHICLE HAS BEEN TAKEN TO FORD SEVERAL TIMES AND NO CODES WERE FOUND AND THEY HAVE STILL NOT ADDRESSED THE PROBLEM. I DID SOME RESEARCH WHICH APPEARS THAT THE PCM IS LIKELY DAMAGED DUE TO A RF ISSUE WITH THE INCORRECT SPARK PLUGS BEING INSTALLED ON THE EARLY MANUFACTURED 2005 FORD ESCAPES. UNFORTUNATELY FORD WILL NOT DOING ANYTHING UNTIL THE COMPUTER ACTUALLY IS DESTROYED, WHICH ALSO FRIES THE COILS (APPROX. $3,000). DEALERSHIPS WILL NOT DO ANYTHING FOR US AND THE CORPORATE OFFICE TOLD US THE SAME. WE NOW HAVE A LOW MILEAGE VEHICLE THAT CANNOT BE TRUSTED SAFELY THAT CANNOT BE...

I AM A WEDDING PHOTOGRAPHER AND WHILE TRAVELING ABOUT 4.5 HOURS AWAY FROM HOME TO SHOOT A WEDDING I HAD PROBLEMS ABOUT 2 HOURS INTO MY TRIP. I WAS ON INTERSTATE 20 JUST OUTSIDE OF COLUMBIA, SC. I WAS IN THE LEFT HAND LANE BEHIND A SEMI TRUCK, THERE WAS ANOTHER SEMI TRUCK IN THE RIGHT LANE BESIDE ME AND BEHIND ME I HAD A LARGE VAN. I WAS GOING ABOUT 65-70 WHEN SUDDENLY, THE CAR LOST ALL POWER INCLUDING THE STEERING AND ALL THE WARNING LIGHTS BLINKED ON. I SOMEHOW REGAINED CONTROL OF THE CAR BY SHIFTING IN NEUTRAL AND RESTARTING. I HATE TO THINK WHAT WOULD HAVE HAPPENED HAD I NOT BEEN ABLE TO REACT AS FAST AS I DID AS THE VAN BEHIND ME HAD TO SLAM ON HIS BREAKS TO KEEP FROM HITTING ME. ONCE THE SEMI TRUCK WAS CLEARED OF THE RIGHT LANE I GOT...

2005 FORD ESCAPE WAS DRIVING DOWN THE ROAD AND THE CAR CUT OUT, CAUSING A MAJOR SAFETY CONCERN. IT WAS TAKEN TO THE GARAGE TO BE REPAIRED. THE DIAGNOSTIC TEST SAID IT WAS THE COILS. THE COILS WERE REPAIRED AND THE CAR CONTINUED TO MISFIRE. IT WAS LATER KNOWN THAT THE COMPUTER WAS FRIED AND NEEDED TO BE REPLACED. AFTER SOME INTERNET RESEARCH, IT APPEARS THAT THIS IS A VERY COMMON PROBLEM WITH THE FORD ESCAPE. *TR

EMAIL FROM THE OFFICE OF CONGRESSMAN REID RIBBLE ON BEHALF OF CONSTITUENT, RE PROBLEMS WITH HER 2005 FORD ESCAPE *TGW THE CONSUMER STATED THE VEHICLE STALLED WHILE DRIVING ON THE HIGHWAY. *JB

WE WERE DRIVING FROM PA TO GA FOR A WEDDING IN MY 2005 FORD ESCAPE. I HAVE 65,000 MILES ON MY ESCAPE. THE ENTIRE CAR LOST ALL POWER...NO POWER STEERING, GAS, ABS, ETC. ALL OF THE WARNING LIGHTS IN THE CAR CAME ON AND WE LOST EVERYTHING GOING 75 ON A HIGHWAY IN N.C. WE WERE ABLE TO GET TO A SERVICE STATION WHO THEN REPLACED 2 COILS AND 2 SPARK PLUGS. THEN THEY REALIZED THAT THE ENTIRE COMPUTER WAS DEAD, THE "PCM". FORD SAID THEY WERE ON BACKORDER SO IT WOULD BE ABOUT A WEEK, AS THEY "MOVED US TO THE FRONT OF THE LINE". WE HAD TO RENT A CAR FOR A WEEK WHILE WE WAITED FOR THE PART...FINISHING OUR TRIP TO GA FOR THE WEDDING, THEN BACK UP TO PA THE NEXT DAY (OUR HOME). WE HAD TO GO BACK TO N.C. IN THE RENTAL CAR (ANOTHER...

E.C.M. WENT OUT, AND IN MY RESEARCH TO FIND A REMANUFACTURED BRAIN I DISCOVERED ALOT OF COMPLAINTS ABOUT THIS PART. I ALSO FOUND OUT THAT THE PART FOR MY CAR IS NOT AVAILABLE AS REMANUFACTURED. MY CAR IS A 2005 FORD ESCAPE SPORT. THE COST FOR THIS PART IS VERY EXPENSIVE... *TR

WHILE DRIVING OUR 2005 FORD ESCAPE, WE WERE ON THE HIGHWAY, IN THE ACCELERATION LANE, TRAVELING APPROXIMATELY 45 MILES AN HOUR ACCELERATING UP TO 55, THE VEHICLE SUDDENLY SHUTTERED, AND THEN DIED, THE CHECK ENGINE, OVERDRIVE, ABS, AND AIRBAG LIGHTS ILLUMINATED ON THE CONSOLE. I HAD TO HIT THE HAZARD LIGHTS AND PUT THE VEHICLE INTO NEUTRAL NARROWLY AVOIDING BEING HIT BY A TRACTOR TRAILER TRUCK. I WAS ABLE TO MANEUVER THE VEHICLE TO THE SHOULDER. I ATTEMPTED TO RESTART THE VEHICLE AND WHILE IT RESTARTED IT WAS MISFIRING AND CHECK ENGINE LIGHT WAS ON. THE VEHICLE WAS UNABLE TO MOVE UNDER ITS OWN POWER. WE WERE ON THE SIDE OF A HIGHWAY WITH OUR 4 YEAR OLD DAUGHTER IN THE CAR DURING MORNING RUSH HOUR. THANKFULLY WE WERE NOT HIT AND KILLED BY THIS FORD ENGINE FAILURE. *TR

THE PROBLEM IS WHEN DRIVING 2005 FORD ESCAPE THE ENGINE CUTS OUT. WHEN DRIVING ON INTERSTATE 5 AT 60 MPH THE ENGINE WILL SHUT OFF AND THEN START BACK UP. THE THEFT LIGHT LIGHTS UP WHEN THIS HAPPENS. ALSO, AT ANY SPEEDS THE ENGINE WILL CUT OUT. EXAMPLE IS WHEN AT STOP SIGN AT INTERSECTION OR CROSS STREET, WHILE IN DRIVE AND PROCEEDING ACROSS INTERSECTION THE CARS ENGINE AND ALL ELECTRICAL WILL TURN OFF. I WILL THEN HAVE TO SHIFT CAR INTO NEUTRAL AND RESTART CAR AND THEN SHIFT INTO DRIVE AND PROCEED ACROSS INTERSECTION HOPEFULLY WITHOUT GETTING HIT FROM OTHER CARS. THIS HAS HAPPENED WITH A CAR FULL OF GRANDCHILDREN ON SEVERAL OCCASIONS. THE CARS ENGINE CUT OUT HAPPENS AT GREATER OCCURRENCES WHEN DRIVING UP INCLINES.

I HAVE HAD RECENT PROBLEMS WITH A ROUGH RUNNING ENGINE ON MY 2005 FORD ESCAPE. HAD THE PROBLEM DIAGNOSED AS A FAULTY PCM COMPUTER. REPAIR SHOP TRIED TO GET THE COMPUTER REBUILT, BUT COULD GET NO HELP. FORD INFORMED US THAT COMPUTERS ARE ON BACKORDER FOR 2 TO 3 MONTHS. FORD RELEASED A BULLETIN DESCRIBING THE NEED TO REPLACE ALL SPARK PLUGS AND IGNITION COILS TO PREVENT PCM DAMAGE. IT SEEMS TO ME FORD HAS ADMITTED TO THIS PROBLEM, YET OFFERS NO HELP. MANY OTHER OWNERS HAVE STARTED TO SEE THE SAME PROBLEM. THE PROBLEM SEEMS TO BE OCCURRING IN MANY MORE 2005 MODELS, RESULTING IN MANY VERY COSTLY REPAIRS. *TR

IN DECEMBER 2010, MY 2005 FORD ESCAPE LIMITED STARTING MISFIRING AT 79,000 MILES AND THE SERVICE EMISSIONS SYSTEM MESSAGE CAME ON. I TOOK IT TO A FORD DEALERSHIP AND THEY COULDN'T GET THE LIGHT TO COME BACK ON OR ANY ERROR CODES TO APPEAR. THE NEXT DAY, THE MISFIRING HAPPENED AGAIN AND THE FORD DEALERSHIP DIAGNOSED IT AS A BAD PRC COMPUTER. FORD REPLACED THE MAIN COMPUTER, UNDER WARRANTY, AT ABOUT 79,900 MILES. THE MISFIRE WENT AWAY FOR ABOUT 3 WEEKS AND THEN RECURRED AT 82,000 MILES. THIS TIME, THE CAR DRAMATICALLY LOST POWER, WILL NOT PROPERLY SHIFT INTO GEAR, SHAKES WHEN IDLING AND MAXES OUT AT ABOUT 30 MPH ON ANY HILL. THE SERVICE EMISSIONS MESSAGE AND CHECK ENGINE LIGHT ARE CONSTANTLY ON. I TOOK IT TO THE SAME FORD DEALERSHIP AND THEY STATED THE COIL PACKS ARE ALL MISFIRING AND CAUSING THE MAIN COMPUTER TO FRY. THEY STATED...

TL*THE CONTACT OWNS A 2005 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 55 MPH THE COMPUTER SHUT DOWN CAUSING THE VEHICLE TO STALL. THE VEHICLE WOULD NOT RESTART AND WAS TOWED TO AN AUTHORIZED MECHANIC WHO STATED THAT THE COMPUTER BURNED ITSELF OUT AND SHOULD BE REPLACED. THE REPAIR WILL INCLUDE REPLACING THE COMPUTER, SIX COIL PACKS AND SIX SPARK PLUGS AT A COST TO THE CONTACT OF $2000. THERE WERE NO RECALLS OR WARRANTIES FOR THE REPAIR. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 110,000.

TL*THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING 45 TO 50 MPH THE VEHICLE STARTED TO HESITATE AND THEN IT STALLED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO TOOK THE VEHICLE TO THE DEALER. THE DEALER REPLACED THE COMPUTER DUE TO THE COMPUTER SINCE IT BURNED OUT AND THE IGNITION KEYS WERE ALSO REPLACED. THE CONTACT WAS RESPONSIBLE FOR THE REPAIR COST OF $1000. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE BECAUSE THE WARRANTY WAS NOT VALID. THE FAILURE MILEAGE WAS 61,000. UPDATED 04/07/11*LJ THE MECHANIC STATED THE PROBLEM BECAUSE THE LOW VOLTAGE SPARK PLUGS WERE THE ORIGINAL EQUIPMENT INSTALLED. UPDATED 04/25/11

1ST TIME(2008)53,972 MILES, STILL UNDER WARRANTY, CHECK ENGINE LIGHT CAME ON, WAS RUNNING ROUGH TOOK IN DIAGNOSED AS FAULTY COIL, REPLACED COIL & SPARK PLUG FOR $741.00 2ND TIME CHECK ENGINE LIGHT ON, RUNNING ROUGH, MISSING, PARKED CAR FOR LITTLE BIT THEN CAR STARTED UP & RAN FINE, TOOK INTO SERVICE & THEY COULDN'T FIND ANYTHING WRONG BUT SUGGESTED WE REPLACE ALL COILS & SPARK PLUGS THIS TIME FOR $1500.00 W, CHARGED US $70.00 WE CHOSE TO HAVE OUR MECHANIC CHECK IT @$40.00 & HE COULDN'T GET ANY READINGS REGARDING REPLACING COILS,- 3RD TIME CHECK ENGINE LIGHT CAME ON AUTO MISFIRING, RUNNING ROUGH, ENGINE QUIT WHILE DRIVING AT 50MPH, WAS ABLE TO COAST CAR OFF OF HIGHWAY & PARK IT ON SIDE OF ROAD. CALLED OUR MECHANIC & HE CAME OVER AND DIAGNOSED CAR AS FAULTY PCM $200.00 HAD CAR TOWED AT OUR EXPENSE BACK TO FORD WHERE THEIR TECHS...

WHILE DRIVING ON US HIGHWAY IN THE EVENING, 2005 FORD ESCAPE XLT SUDDENLY STARTED VIBRATING, CHECK ENGINE LIGHT LIT AND THEN ALL OTHER LIGHTS ON THE DASH FLASHED AS VEHICLE LOST POWER BUT WAS ABLE COAST TO A STOP ON THE SHOULDER OF THE ROAD. THIS WAS A DANGEROUS SITUATION AS VEHICLE SUDDENLY STOPPED WHILE TRAVELING AT HIGHWAY SPEEDS WITHOUT ANY INDICATION TO THE VEHICLES FOLLOWING THIS VEHICLE THAT IT WAS GOING TO SUDDENLY DECREASE SPEED AND STOP. FORTUNATELY VEHICLE FOLLOWING WAS ABLE TO PASS SAFELY. VEHICLE WOULD NOT START AND WAS TOWED TO DEALERSHIP. CODE P0353 WAS INDICATED AND TSB 10-18-10 WAS USED TO SERVICE VEHICLE. ALL 6 COPS WERE REPLACED ALONG WITH PCM. VEHICLE STILL DID NOT OPERATE PROPERLY AND ON INSPECTION BY TECH, CATALYTIC CONVERTER WAS FOUND TO BE PLUGGED AND WAS REPLACED. PRIOR TO THIS INCIDENT, VEHICLE WAS OPERATING NORMALLY AND HAD APPROX. 45,000 MILES ON...

2005 FOR ESCAPE LIMITED EDITION WAS PASSING ANOTHER CAR ON A TWO LANE ROAD WHEN THE ENGINE COMPLETELY SHUT DOWN AND CHECK ENGINE LIGHT CAME ONE. HAD TO ALMOST STOP GOING THE WRONG WAY ON A TWO LANE ROAD SO THE CARS GOING THE SAME DIRECTION AS ME COULD PAS SO I COULD GET BACK IN THE CORRECT LANE AND PULL OVER TO THE SIDE OF THE ROAD. HAD THE CODES CHECKED AND TWO OF THE 6 COILS WERE SHOWING UP AS HAVING ISSUES. CODE WERE P0352 PO354 THERE IS A TSB FROM FORD TSB 10-18-10. I HAVE REPLACED THE COILS AND THE ISSUE STILL IS THROUGH THE CODES FOR THE COILS. ACCORDING THE TSB THERE COULD BE INTERFERENCE WITH THE PCM FROM THE COILS AND PLUGS. THE CONSEQUENCES OF THIS ISSUE IS THAT IF I HAD NOT BEEN OBSERVANT AND CAUGHT THIS BEFORE ANOTHER CAR COMING AT ME WAS...

SMART JUNCTION BOX FAILURE. PART# 5L8Z15604GA THIS PART CONTROLS MANY OF THE ELECTRONIC ELEMENTS OF THE VEHICLE; DIRECTIONAL SIGNALS, HAZARD LIGHTS INSTRUMENT PANEL, HORN, LOCKS, WINDOWS, SECURITY SYSTEM. VARIOUS ELECTRICAL ELEMENTS FAIL INTERMITTENTLY BECAUSE OF THIS DEFECTIVE PART. THE PART IS ON BACK-ORDER AND CONTINUES TO BE PUSHED TO A LATER DATE. AS OF 11/16, THE PART IS ON BACK-ORDER UNTIL JAN 17, 2011. I HAVE SEEN OTHER COMPLAINTS ABOUT THIS ISSUE, AND SEE THAT THE PART HAS BEEN ON BACK-ORDER SINCE (AT LEAST) AUGUST 2010. THERE IS OBVIOUSLY A HIGH DEMAND FOR THIS PART, OR IT IS BEING REDESIGNED AND FORD IS TRYING TO AVOID A RECALL. *TR

I AM WRITING IN CONCERNS TO A SERIOUS SAFETY ISSUE THAT FORD MOTOR COMPANY HAS FAILED TO ADDRESS. I AM AN OWNER OF A 2005 FORD ESCAPE WHICH I PURCHASED NEW IN NOVEMBER OF 2004. I HAVE BEEN WAITING TWO MONTHS TO HAVE A FAULTY ELECTRICAL PART, THE SMART JUNCTION BOX, REPLACED. SINCE AUGUST 23RD MY VEHICLE HAS BEEN UNSAFE TO OPERATE WITHOUT THIS PART AS MY TURN SIGNALS, HEAD LIGHTS, AND HAZARD LIGHTS ARE INOPERABLE, AS WELL AS POWER WINDOWS, INTERIOR AND DASH LIGHTS, POWER LOCKS, RADIO AND CLOCK DISPLAY AND MY ABILITY TO UNLATCH THE REAR DOOR. AFTER RESEARCHING THE INFORMATION MYSELF I WAS FORCED TO WAIT ANOTHER WEEK TO BE SCHEDULED TO HAVE MY VEHICLE SCHEDULED FOR REPAIR. ON SEPT. 7TH THE FORD MECHANIC CONFIRMED THE PART I TOLD HIM I NEEDED WAS CORRECT AND SAID PART WAS ON BACK ORDER AND SHOULD BE AVAILABLE IN TWO...

I OWN A 2005 FORD ESCAPE AND HAVE NUMEROUS ISSUES SINCE I PURCHASED THE VEHICLE IN NOVEMBER 2004. THE TRANSMISSION HAS BEEN REPLACED AND ONE COIL PACK. THROUGHOUT THE TIME I HAVE OWNED THE VEHICLE THE THEFT LIGHT COMES ON AND TRIED TO SHUT THE VEHICLE DOWN WHILE I WAS DRIVING (40+MPH). IT CLEARED FOR A LITTLE WHILE AFTER THE TRANSMISSION WAS REPLACED, THEN IT RETURNED. FORD CHANGED ONE IGNITION COIL AND SAID THAT IF WE CHANGED THE SPARK PLUGS IT WOULD PROBABLY FIX THE THEFT SHUT DOWN PROBLEM. WELL WE CHANGED THE SPARK PLUGS AND THE VEHICLE CONTINUED TRYING TO SHUT DOWN THE VEHICLE WHILE I WAS DRIVING(40+MPH). NOW THE VEHICLE WILL NOT START AT ALL. THERE IS JUICE FROM THE BATTERY, ALL THE LIGHTS AND RADIO COME ON, BUT THE CAR REFUSES TO TURN OVER. WE HAVE CHECKED EVERYTHING POSSIBLE, INCLUDING: THE BATTERY, FUSES, AND HAVING IT TESTED...

MY WIFE WAS GOING TO THE BANK IN OUR 2005 FORD ESCAPE WITH 39150 MILES. SHE HEARD A NOISE AND STOPPED TO SEE IF SHE HAD A FLAT. EVERYTHING SEEMED OK SO SHE CONTINUED ON. BEFORE GOING ONE BLOCK THE DASH WARNING LIGHTS CAME ON SO SHE DROVE AROUND THE BLOCK AND PARKED THE CAR IN THE GARAGE. UPON EXITING SHE NOTICED SMOKE COMING FROM THE HOOD AREA. WHILE SHE WAS TRYING TO CALL ME AT WORK, MORE SMOKE BEGAN POURING OUT, SHE HEARD A POP AND FLAMES AND SMOKE BEGAN COMING OUT. A NEIGHBOR SAW WHAT WAS GOING ON AND CALLED 911. THANKFULLY THE PROMPT RESPONSE OF THE FIRE DEPT. LIMITED THE DAMAGE TO THE VEHICLE AND THE HOME ONLY SUFFERED SMOKE DAMAGE. WE ARE CURRENTLY LIVING IN A MOTEL WHILE THE HOUSE GETS CLEANED. THE ESCAPE WAS A TOTAL LOSS. UPDATED 11/03/10*JB *TR

WHILE DRIVING 50 MPH WITHOUT WARNING THE VEHICLE SHUT OFF BY ITSELF. IF IT WERE NOT 5:30 IN THE MORNING I MAY HAVE CAUSED AN ACCIDENT OR BEEN KILLED. I WAS ABLE TO RESTART IT, BUT THE ENGINE LIGHT CAME ON AND IT RAN VERY HARD. IT THEN GAVE ME A SERVICE EMISSIONS WARNING. THE MECHANIC STATES THAT ALL 6 SPARK PLUGS AND 6 COILS NEED REPLACED AND THAT THE COMPUTER SYSTEM WAS FRIED (SMV).FURTHERMORE, HE STATED THAT IT WAS AN ERROR IN MANUFACTURING IN REGARDS TO THE SPARK PLUG INSTALLATION. I NOW FIND THAT THIS IS A COMMON PROBLEM WITH THE 2005 FORD ESCAPES BUT NO RECALLS OR NOTICES HAVE BEEN MADE. *TR

VEHICLE FIRE ON 2005 FORD ESCAPE (VIN [XXX]) ON 3/23/2010, I NOTICED THE VEHICLE SUDDENLY (WHEN DRIVING) BEGAN TO RUN ROUGH. (LIKE A SPARK PLUG HAD FAILED). WE IMMEDIATELY PULLED INTO A GAS STATION AND INSPECTED THE ENGINE COMPARTMENT (FOR BROKEN BELTS AND THE LIKE) NO OBVIOUS ISSUE WAS OBSERVED. WHEN I STARTED THE VEHICLE AGAIN, I NOTICED THE CHECK ENGINE LIGHT WAS ON. IMMEDIATELY I DROVE THE VEHICLE HOME AND CONTACTED A SERVICE GARAGE. I WAS ON MY WAY TO TAKE THE VEHICLE INTO SERVICE WHEN I NOTICED AN ELECTRICAL SMELL. I PULLED INTO THE NEXT GAS STATION, OPENED THE HOOD, AND NOTICED A SMALL FIRE LOCATED AT THE #1 CYLINDER COIL PACK. I USED THE GAS STATION FIRE EXTINGUISHER TO PUT OUT THE FIRE. CAR WAS TOWED THE REST OF THE WAY TO THE GARAGE. CAR HAD BEEN DRIVEN NO MORE THAN 10 MILES AFTER FIRST SIGN OF...

CAR WAS DRIVING FINE, PARKED FOR SEVERAL HOURS AND THEN IT WOULD NOT START. TOWED TO A SHOP AND ALL COILS WERE OUT. AFTER MORE DIAGNOSIS, THE SPARK PLUGS, THE COILS (POCS) AND THE POWERTRAIN COMPUTER MODULE HAD TO BE REPLACED FOR A TOTAL COST OF $2600 ON A 5 YEAR OLD CAR WITH 63,000 MILES ON IT. MOST LIKELY THE SPARK PLUG RF CAUSED THE PCM TO CRASH. HAD TO REPLACE THE PLUGS, COILS AND PCM INCLUDING SOFTWARE AND PROGRAMMING. I HAVE READ ON SEVERAL COMPLAINT BLOGS THAT FORD KNOWS OF THE PROBLEMS (DEFECTIVE PLUGS) AND HAS ISSUED 2 TSB, 05111 AND 0926. PROBLEM SHOULD BE UNDER THE EMISSION WARRANTY, BUT FORD SAYS IT IS A IGNITION PROBLEM. I THINK IT IS FORD'S PROBLEM AND THEY SHOULD BE COMPELLED TO REPAIR THE PROBLEM. I HAVE READ NUMEROUS COMPLAINTS ON BLOGS FOR THIS PROBLEM WHERE THE CAR JUST STOPS REGARDLESS...

TL* THE CONTACT OWNS A 2005 FORD ESCAPE. WHILE DRIVING 65 MPH THE VEHICLE STALLED WITHOUT AND PRIOR WARNINGS. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY. THE MECHANIC REPLACED THE PCM, IGNITION COIL, AND THE SPARK PLUGS. TWO WEEKS AFTER THE REPAIR, ALL OF THE ELECTRICAL COMPONENTS, INCLUDING THE PARTS THAT WERE REPLACED HAD MELTED. THE CURRENT AND FAILURE MILEAGES WERE 110,000.

I WAS DRIVING ON THE NEW YORK STATE THRUWAY AT ABOUT 65MPH. MY CAR RAPIDLY DECELERATED AND ALL THE PANEL LIGHTS LIT UP. THERE WAS NO CRASH, BUT THAT WAS JUST LUCK- HAD I BEEN IN HEAVY TRAFFIC AT THE TIME OF THE INCIDENT I PROBABLY WOULD HAVE BEEN REAR ENDED. WHAT ULTIMATELY FAILED IS MY POWER TRAIN CONTROL MODULE ( PCM) ON MY 2005 FORD ESCAPE. TURNS OUT THERE IS A TECHNICAL SERVICE BULLETIN DESCRIBING THE FAILURE I EXPERIENCED; REFER TO FORD'S BULLETIN 09-2-6, WHICH SUPERCEDES 05-11-1. I GOT LUCKY, AS I SAID, BECAUSE I JUST HAPPENED TO BE IN A BREAK IN TRAFFIC, WHICH UP TO THAT POINT HAD BEEN BUMPER TO BUMPER. THE RAPID DECELERATION WAS THE RESULT OF LOSING 3 CYLINDERS, SO IT OCCURRED WITHOUT THE BENEFIT OF BRAKE LIGHTS COMING ON. RAPID DECELERATION, WITHOUT BRAKE LIGHTS, IN HEAVY TRAFFIC, DUE A PROBLEM WHICH FORD KNEW...

I WAS ON MY WAY TO CONNECTICUT FROM MAINE ON 12/24/08. I NOTICED THAT WHILE WE WERE TRAVELING ON THE HIGHWAY THE CAR STARTED RUNNING ROUGH AND SKIPPING. I IMMEDIATELY PULLED OVER TO THE BREAKDOWN LANE WHERE THE CAR STALLED. THE CAR WOULD START BUT NOT KEEP RUNNING. CALLED AAA AND HAD TO HAVE THE CAR TOWED TO THE NEAREST FORD DEALERSHIP IN PLAINFIELD CT. VEHICLE COULD NOT BE IMMEDIATELY REPAIRED DUE TO THE HOLIDAY. THE CAR WAS REPAIRED ON DEC. 26, 2008. THE DEALERSHIP REPLACED THE POWER CONTROL MODULE AND ALSO REPLACED 2 IGNITION COILS # 2 AND 3. COULD NOT SAVE PCM BECAUSE THERE WAS A CORE CHARGE FOR IT, BUT I DO HAVE THE IGNITION COILS. VEHICLE HAD 38,711 MILES WHEN THIS HAPPENED. THEN ON MAY 17, 2009 THE #5 COIL FAILED AND HAD TO BE REPLACED. I STILL HAVE THAT COIL ALSO. THE DEALER SAID THAT...

FROM ONE DAY TO ANOTHER THE CAR STARTED SHAKING WHEN IT WAS AT A STOP OR LIGHT AND THE ENGINE LIGHT TURNED ON, THE A/C STOPPED WORKING AND CD PLAYER TOO. I TOOK IT TO THE DEALER AND I WAS TOLD THAT THE COMPUTER NEEDED TO BE CHANGED AND IT WOULD COST ME ABOUT $2000 AND THIS DOES NOT INCLUDE THE A/C OR CD PLAYER. I ASKED IF IT COULD BE RESET OR SOMETHING CHEAPER COULD BE DONE AND I WAS TOLD THAT NO. THE GUY THERE SAID HE DID NOT KNOW WHY THIS HAPPENS BUT IT DOES AND HE SAID THAT HE SEES THIS KIND OF SITUATION EVERY TWO MONTHS WITH THE FORD ESCAPES. I THINK THAT IF IT HAS HAPPENED TO SO MANY PEOPLE AND WE HAVE TO PAY OVER $2000 TO REPAIR IT, IT IS NOT FAIR FOR US AS CONSUMER BECAUSE I HONESTLY DO NOT HAVE...

THERE WERE NO EVENTS LEADING UP TO THE BREAKDOWN. THE CAR SIMPLY QUIT RUNNING. IT HAD FIRE BUT WOULD NOT TURN OVER. WE HAD NO PROBLEMS PRIOR TO THIS. WE TOOK IT TO THE FORD DEALER. THE FIRST PROBLEM THEY TOLD US WAS THAT THE CHIP IN THE KEY WAS BAD. THE HAD A NEW KEY MADE. FROM THERE, IT WAS THE PCM COMPUTER AND THEN A SECOND COMPUTER AND THEN 3 POWER PACKS. THEY ALSO REPLACED THE PLUGS AND WIRES AND MISC. OTHER PARTS. *TR

ABOUT 6 WEEKS AGO, MY WIFE CALLED ME AT WORK TO REPORT HER 2005 ESCAPE "MADE A FUNNY NOISE" WHEN SHE TRIED TO START IT. WHEN I GOT HOME THAT AFTERNOON, I WENT TO INVESTIGATE IT. WHEN I PUT THE KEY IN AND TURNED IT ON, IT EXPLODED. THE INTAKE MANIFOLD DISENTERGRATED AND SCHRAPNEL FROM IT SEVERED WIRING HARNESS, KNOCKED PARTS OFF ETC. HAVING 39K MILES ON IT I HAD IT TOWED TO A LOCAL TOP RATED MECHANIC. AFTER THE MECHANIC REPAIRED THE MECHANICAL DAMAGE, HE SENT IT TO BEACH FORD FOR A PCM ISSUE. THEY REPLACED THE PCM (UNDER FORD WARRANTY, ADMITTING THAT THE COMPUTER WAS ?FRIED? AND THIS HAS BEEN A PROBLEM WITH OTHER ESCAPES) BUT ABSOLVES ANY KNOWLEDGE OR RESPONSIBILITY AS TO WHY THE EXPLOSION OCCURRED IN THE FIRST PLACE BECAUSE A ?THIRD PARTY PERSON? REPAIRED THE CAR BEFORE BEACH FORD SAW IT. A ?MIKE? AT FORD...

DT*: THE CONTACT STATED WHILE THE AIR CONDITIONER WAS ON, THERE WAS A HESITATION WHILE ACCELERATING DURING A LEFT HAND TURN. THE DEALERSHIP WAS UNABLE TO DETERMINE A PROBLEM, BUT REPLACED A CHIP. FIVE WEEKS LATER, THE PROBLEM RETURNED AND THE VEHICLE WAS TAKEN TO THE DEALERSHIP. THE DEALERSHIP WAS UNABLE TO DETERMINE THE PROBLEM, BUT REPROGRAMMED THE COMPUTER TO THE LATEST SPECIFICATIONS. THE DEALERSHIP STATED BECAUSE IT WAS A FOUR CYLINDER ENGINE, THERE WOULD BE A HESITATION WITH THE AIR CONDITIONER ON. *AK

I HAVE A 2005 FORD ESCAPE. WHEN BRINGING THE CAR TO A STOP IN TRAFFIC IT SOMETIMES JUMPS AHEAD FOR SEVEARL FEET BEFORE I'M ABLE TO BRING IT TO A FULL STOP. I HAVE OWNED THE CAR FOR TEN MONTHS AND THIS HAS OCCURRED ON FIVE SEPARATE OCCASIONS. I HAVE HAD THE CAR INSPECTED BY THE LOCAL FORD DEALER ON SEVERAL DIFFERENT OCCASIONS. THEY HAVE TRIED BUT ARE UNABLE TO DETERMINE THE CAUSE. BELIEVE ME, IT HAS NOTHING TO DO WITH PUTTING THE FOOT ON THE WRONG PEDAL, ETC. ETC. AT THIS POINT I'M UNABLE TO DETERMINE WHETHER THE PROBLEM RESULTS FROM ACCELERATION FROM THE MOTOR OR SLIPPAGE IN THE BRAKING SYSTEM. *AK

CONSUMER COMPLAINED ABOUT A COMPUTER PROBLEM. WHEN PUTTING VEHICLE IN REVERSE IT WENT FORWARD, AND WHEN PUTTING IT IN DRIVE IT DID NOTHING. CONSUMER TOOK VEHICLE TO REPAIR SHOP 3 TIMES, BUT MECHANIC COULD NOT FIND ANYTHING WRONG. WHEN VEHICLE WAS PUT ON THE COMPUTER IT SHOWED NO ERROR MESSAGE, NOTHING WAS WRONG. CONSUMER TURNED THE VEHICLE OFF AND THEN TURNED IT BACK ON, AND IT WORKED FINE. CONSUMER SHOULD NOT HAVE TO DO THIS BECAUSE THIS WAS A NEW VEHICLE, 2005 MODEL. THEREFORE, CONSUMER FELT THAT THERE WAS A MALFUNCTIONED COMPUTER IN THE VEHICLE. *AK