2002 FORD E-150 — Problems, Recalls & Safety Data
N/A
Safety Rating
37
Owner Complaints
3
Recalls
3
Service Bulletins
0
Investigations
Overview of the 2002 FORD E-150
The 2002 FORD E-150 has received a total of 37 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 3 recall campaigns affecting this vehicle, covering issues with VEHICLE SPEED CONTROL, VEHICLE SPEED CONTROL:CRUISE CONTROL. 3 technical service bulletins have been issued by Ford Motor Company for this model year. The most commonly reported problems involve the Fuel System Gasoline (3 complaints), Steering (3 complaints), and Electrical Systemhorn (2 complaints).
Recalls for the 2002 FORD E-150
NHTSA has recorded 3 recalls for the 2002 FORD E-150, potentially affecting up to 8,325,000 vehicles.
Recall 09V399000 — VEHICLE SPEED CONTROL
| 4,500,000 vehicles affected
Defect: FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL...
View full details →Recall 08V051000 — VEHICLE SPEED CONTROL:CRUISE CONTROL
| 225,000 vehicles affected
Defect: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
View full details →Recall 07V336000 — VEHICLE SPEED CONTROL
| 3,600,000 vehicles affected
Defect: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON...
View full details →Owner Complaints for the 2002 FORD E-150
37 complaints have been filed with NHTSA for the 2002 FORD E-150. Below is a breakdown by vehicle component.
Most Recent Complaints
My power steering and brakes went out as I was driving. I was making a turn in town, and I almost collided with another car at the intersection. I pushed the brakes as hard as I could, but it didn't slow down, the car just eventually rolled to a stop on its own. The exact cause is unknown, but it seems like it was a failure in the power steering pump. After turning off the van and turning it back on again a minute later, it started driving normally again.
My power steering and brakes went out as I was driving. I was making a turn in town, and I almost collided with another car at the intersection. I pushed the brakes as hard as I could, but it didn't slow down, the car just eventually rolled to a stop on its own. The exact cause is unknown, but it seems like it was a failure in the power steering pump. After turning off the van and turning it back on again a minute later, it started driving normally again.
The contact owns a 2002 Ford E-150. The contact stated while driving at approximately 75 MPH, he smelled a burning odor in the passenger cabin. The contact stated that he turned the A/C on to help clear the cabin. The contact stated that he noticed smoke was being emitted from the driver's side rear tire and wheel well. The contact stated that the tire separated from the rim and the vehicle dropped to the road. The contact stated he had not noticed any warning lights. The contact stated that he managed to pull over and saw smoke emitted from the rotor and brake pads. The contact stated that the rim was almost destroyed. The contact observed that there was fluid leaking from the rotor and brake pads and had started to burst into flames. The contact stated that he was able to smother the flames with a blanket. The contact stated that he had the vehicle towed to an independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 228,000.
The contact owns a 2002 Ford E-150. The contact stated while driving at approximately 75 MPH, he smelled a burning odor in the passenger cabin. The contact stated that he turned the A/C on to help clear the cabin. The contact stated that he noticed smoke was being emitted from the driver's side rear tire and wheel well. The contact stated that the tire separated from the rim and the vehicle dropped to the road. The contact stated he had not noticed any warning lights. The contact stated that he managed to pull over and saw smoke emitted from the rotor and brake pads. The contact stated that the rim was almost destroyed. The contact observed that there was fluid leaking from the rotor and brake pads and had started to burst into flames. The contact stated that he was able to smother the flames with a blanket. The contact stated that he had the vehicle towed to an independent mechanic. The vehicle was not diagnosed and was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 228,000.
IN A PARKING LOT, I WENT TO TURN LEFT, HEARD A LOUD CLUNK AND THE VAN JUST WENT STRAIGHT. LOST ALL STEERING CONTROL. LUCKILY THIS HAPPENED IN A PARKING LOT AND NOT ON THE ROAD AT HIGHER SPEED. IF THIS HAD OCCURRED AT SPEED, I WOULD HAVE HIT ONCOMING TRAFFIC , OR GONE OFF THE ROAD INTO WHO KNOWS WHAT. TWO SEPARATE MECHANICS HAVE DIAGNOSED A COMPLETE FRAME FAILURE WIHICH ALLOWED THE STEERING BOX TO DETACH FROM THE FRAME. THE FRAME IS NOT REPAIRABLE. IF THIS IS A COMMON PROBLEM WITH THE 2002 FORD E150 FRAME PEOPLE ARE GOING TO GET HURT OR KILLED!!!
Safety Rating for the 2002 FORD E-150
NHTSA has not yet tested the 2002 FORD E-150 in its New Car Assessment Program.
Technical Service Bulletins for the 2002 FORD E-150
Ford Motor Company has issued 3 technical service bulletins (TSBs) for the 2002 FORD E-150. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
18735 — EXTERIOR LIGHTING:HEADLIGHTS
HEADLIGHT ADJUSTMENT - CHASSIS CAB INCOMPLETE VEHICLES. *TT
18250 — POWER TRAIN
INTERMITTENT CLUNK ON 3-2 DOWNSHIFT DURING COASTDOWN/TIP-IN. OASIS. TO INCLUDE 2005 F-150, E-SERIES AND EXPEDITION. *TT
17104 — ENGINE AND ENGINE COOLING:ENGINE
TICKING/TAPPING NOISE WITH THE ENGINE WARMED UP AND THE TRANSMISSION IN GEAR AT IDLE. 2003 E150 INCLUDED. *TT
NHTSA Investigations for the 2002 FORD E-150
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the FORD E-150
- 1997 FORD E-150 — 122 complaints
- 1998 FORD E-150 — 81 complaints
- 1999 FORD E-150 — 115 complaints
- 2000 FORD E-150 — 61 complaints
- 2001 FORD E-150 — 52 complaints
- 2002 FORD E-150 (current)
- 2003 FORD E-150 — 31 complaints
- 2004 FORD E-150 — 36 complaints
- 2005 FORD E-150 — 24 complaints
- 2006 FORD E-150 — 22 complaints
- 2007 FORD E-150 — 15 complaints
Other FORD Models
- FORD F-150 — 45,660 total complaints
- FORD EXPLORER — 42,140 total complaints
- FORD ESCAPE — 34,654 total complaints
- FORD FOCUS — 29,539 total complaints
- FORD FUSION — 28,243 total complaints
- FORD TAURUS — 23,867 total complaints
- FORD WINDSTAR — 19,456 total complaints
- FORD EDGE — 17,247 total complaints