1992 FORD E-150 — Problems, Recalls & Safety Data
N/A
Safety Rating
86
Owner Complaints
4
Recalls
0
Service Bulletins
1
Investigation
Overview of the 1992 FORD E-150
The 1992 FORD E-150 has received a total of 86 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 4 recall campaigns affecting this vehicle, covering issues with VEHICLE SPEED CONTROL, VEHICLE SPEED CONTROL:CRUISE CONTROL. The most commonly reported problems involve the Vehicle Speed Control (7 complaints), Engine And Engine Cooling (3 complaints), and Engine And Engine Coolingengine (3 complaints).
Recalls for the 1992 FORD E-150
NHTSA has recorded 4 recalls for the 1992 FORD E-150, potentially affecting up to 8,354,052 vehicles.
Recall 09V399000 — VEHICLE SPEED CONTROL
| 4,500,000 vehicles affected
Defect: FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL...
View full details →Recall 08V051000 — VEHICLE SPEED CONTROL:CRUISE CONTROL
| 225,000 vehicles affected
Defect: FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
View full details →Recall 07V336000 — VEHICLE SPEED CONTROL
| 3,600,000 vehicles affected
Defect: ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON...
View full details →Recall 92V123000 — EQUIPMENT:OTHER:LABELS
| 29,052 vehicles affected
Defect: THE TIRE CERTIFICATION LABELS INCORRECTLY IDENTIFY THE VEHICLE TIRE REQUIREMENTS AS P235/75R15 SL (STANDARD LOAD), RATHER THAN AS P235/75R15 XL (EXTRA LOAD).
Consequence: THE CERTIFICATION LABELS ON THE AFFECTED VEHICLES DO NOTCOMPLY WITH FMVSS 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THANPASSENGER CARS." INCORRECT TIRE SELECTION COULD RESULT IN SUDDEN FAILURE OFA TIRE WHILE THE VEHICLE IS IN MOTION, AND RESULT IN A VEHICLE ACCIDENT.
Remedy: CORRECT TIRE INFORMATION LABELS AND INSTALLATION INSTRUCTIONS WILL BE MAILED TO THE OWNERS OF THESE VEHICLES. OWNERS WILL BE INSTRUCTED THAT DEALERS CAN INSTALL THE LABEL PROVIDED IF THEY PREFER.
View full details →Owner Complaints for the 1992 FORD E-150
86 complaints have been filed with NHTSA for the 1992 FORD E-150. Below is a breakdown by vehicle component.
Most Recent Complaints
THIS 1992 FORD ECONOLINE VAN DISPLAYS A DRIVERS SIDE AIR BAG WARNING LIGHT ON THE MAIN INSTRUMENT PANEL.
I WAS TRAVELING HOME TO CAMDEN, TN FROM WEST FRANKFORT, IL WITH MY CHILDREN ON HWY 69. CRUISE CONTROL WAS ENGAGED. WHEN ENTERING A LOWER SPEED ZONE, I ATTEMPTED TO SLOW THE VEHICLE, BUT AFTER ATTEMPTING TO SLOW THE VEHICLE, UPON RELEASING THE BRAKE, THE VEHICLE WOULD INCREASE IN SPEED AGAIN AND THE ENGINE CONTINUED TO RUN HIGH. I KNEW THERE WAS A MAJOR PROBLEM WHEN I WAS GOING UPHILL AND THE VEHICLE WAS INCREASING IN SPEED RELATIVELY QUICKLY. I PRESSED HARD ON THE BRAKES, BUT THE BRAKES WERE VERY HARD TO PRESS. I KNEW WE WERE IN TROUBLE AT THIS POINT BECAUSE I HAD JUST REPLACED ALL FOUR BRAKES THE WEEK BEFORE, SO I KNEW THE BRAKES WERE FINE. I SHIFTED THE VEHICLE INTO NEUTRAL, ENGAGED THE EMERGENCY BRAKE, AND MANAGED TO PULL THE VEHICLE OFF TO THE SHOULDER IN FRONT OF A BP GAS STATION IN MURRAY, KY. I TURNED OFF THE CAR, WAITED ABOUT ONE MINUTE AND STARTED IT AGAIN, BUT THE VEHICLE WAS RUNNING HIGH, AS THOUGH THE ACCELERATOR WAS STUCK. A FRIEND CAME TO HELP ME AND WE MANAGED TO GET THE VEHICLE RUNNING AGAIN AND I TRAVELED HOME THE NEXT DAY. THE SAME THING HAPPENED AGAIN ON 10/14/2011. I WAS TRAVELING TO WORK WITH A CO-WORKER AND I PUT THE VEHICLE INTO CRUISE (FOR THE FIRST TIME SINCE THE SEPTEMBER INCIDENT). SUDDENLY, UPON TRYING TO SLOW DOWN TO MAKE A RIGHT HAND TURN, THE VEHICLE BRAKES BECAME VERY HARD TO PRESS, THE ENGINE RAN HIGH, AND THE SPEED BEGAN TO INCREASE. I IMMEDIATELY KNEW THAT THE SAME THING WAS HAPPENING AS BEFORE, SO I IMMEDIATELY LOOKED FOR A SAFE PLACE TO PULL OVER (NO GOOD SHOULDERS ON A WINDY COUNTRY ROAD), PUT THE VEHICLE IN NEUTRAL, ENGAGED THE EMERGENCY BRAKE, STOPPED AND TURNED OFF THE VEHICLE. WHEN I TURNED IT BACK ON, IT WAS RUNNING HIGH STILL. I TURNED IT OFF, SHOOK THE ACCELERATOR PEDAL VIGOROUSLY AND THE VEHICLE RAN LIKE NORMAL. I HAVE NOT USED THE CRUISE CONTROL SINCE AND HAVE REMAINED WITHOUT INCIDENT. *TR
I WAS TRAVELING HOME TO CAMDEN, TN FROM WEST FRANKFORT, IL WITH MY CHILDREN ON HWY 69. CRUISE CONTROL WAS ENGAGED. WHEN ENTERING A LOWER SPEED ZONE, I ATTEMPTED TO SLOW THE VEHICLE, BUT AFTER ATTEMPTING TO SLOW THE VEHICLE, UPON RELEASING THE BRAKE, THE VEHICLE WOULD INCREASE IN SPEED AGAIN AND THE ENGINE CONTINUED TO RUN HIGH. I KNEW THERE WAS A MAJOR PROBLEM WHEN I WAS GOING UPHILL AND THE VEHICLE WAS INCREASING IN SPEED RELATIVELY QUICKLY. I PRESSED HARD ON THE BRAKES, BUT THE BRAKES WERE VERY HARD TO PRESS. I KNEW WE WERE IN TROUBLE AT THIS POINT BECAUSE I HAD JUST REPLACED ALL FOUR BRAKES THE WEEK BEFORE, SO I KNEW THE BRAKES WERE FINE. I SHIFTED THE VEHICLE INTO NEUTRAL, ENGAGED THE EMERGENCY BRAKE, AND MANAGED TO PULL THE VEHICLE OFF TO THE SHOULDER IN FRONT OF A BP GAS STATION IN MURRAY, KY. I TURNED OFF THE CAR, WAITED ABOUT ONE MINUTE AND STARTED IT AGAIN, BUT THE VEHICLE WAS RUNNING HIGH, AS THOUGH THE ACCELERATOR WAS STUCK. A FRIEND CAME TO HELP ME AND WE MANAGED TO GET THE VEHICLE RUNNING AGAIN AND I TRAVELED HOME THE NEXT DAY. THE SAME THING HAPPENED AGAIN ON 10/14/2011. I WAS TRAVELING TO WORK WITH A CO-WORKER AND I PUT THE VEHICLE INTO CRUISE (FOR THE FIRST TIME SINCE THE SEPTEMBER INCIDENT). SUDDENLY, UPON TRYING TO SLOW DOWN TO MAKE A RIGHT HAND TURN, THE VEHICLE BRAKES BECAME VERY HARD TO PRESS, THE ENGINE RAN HIGH, AND THE SPEED BEGAN TO INCREASE. I IMMEDIATELY KNEW THAT THE SAME THING WAS HAPPENING AS BEFORE, SO I IMMEDIATELY LOOKED FOR A SAFE PLACE TO PULL OVER (NO GOOD SHOULDERS ON A WINDY COUNTRY ROAD), PUT THE VEHICLE IN NEUTRAL, ENGAGED THE EMERGENCY BRAKE, STOPPED AND TURNED OFF THE VEHICLE. WHEN I TURNED IT BACK ON, IT WAS RUNNING HIGH STILL. I TURNED IT OFF, SHOOK THE ACCELERATOR PEDAL VIGOROUSLY AND THE VEHICLE RAN LIKE NORMAL. I HAVE NOT USED THE CRUISE CONTROL SINCE AND HAVE REMAINED WITHOUT INCIDENT. *TR
I WAS TRAVELING HOME TO CAMDEN, TN FROM WEST FRANKFORT, IL WITH MY CHILDREN ON HWY 69. CRUISE CONTROL WAS ENGAGED. WHEN ENTERING A LOWER SPEED ZONE, I ATTEMPTED TO SLOW THE VEHICLE, BUT AFTER ATTEMPTING TO SLOW THE VEHICLE, UPON RELEASING THE BRAKE, THE VEHICLE WOULD INCREASE IN SPEED AGAIN AND THE ENGINE CONTINUED TO RUN HIGH. I KNEW THERE WAS A MAJOR PROBLEM WHEN I WAS GOING UPHILL AND THE VEHICLE WAS INCREASING IN SPEED RELATIVELY QUICKLY. I PRESSED HARD ON THE BRAKES, BUT THE BRAKES WERE VERY HARD TO PRESS. I KNEW WE WERE IN TROUBLE AT THIS POINT BECAUSE I HAD JUST REPLACED ALL FOUR BRAKES THE WEEK BEFORE, SO I KNEW THE BRAKES WERE FINE. I SHIFTED THE VEHICLE INTO NEUTRAL, ENGAGED THE EMERGENCY BRAKE, AND MANAGED TO PULL THE VEHICLE OFF TO THE SHOULDER IN FRONT OF A BP GAS STATION IN MURRAY, KY. I TURNED OFF THE CAR, WAITED ABOUT ONE MINUTE AND STARTED IT AGAIN, BUT THE VEHICLE WAS RUNNING HIGH, AS THOUGH THE ACCELERATOR WAS STUCK. A FRIEND CAME TO HELP ME AND WE MANAGED TO GET THE VEHICLE RUNNING AGAIN AND I TRAVELED HOME THE NEXT DAY. THE SAME THING HAPPENED AGAIN ON 10/14/2011. I WAS TRAVELING TO WORK WITH A CO-WORKER AND I PUT THE VEHICLE INTO CRUISE (FOR THE FIRST TIME SINCE THE SEPTEMBER INCIDENT). SUDDENLY, UPON TRYING TO SLOW DOWN TO MAKE A RIGHT HAND TURN, THE VEHICLE BRAKES BECAME VERY HARD TO PRESS, THE ENGINE RAN HIGH, AND THE SPEED BEGAN TO INCREASE. I IMMEDIATELY KNEW THAT THE SAME THING WAS HAPPENING AS BEFORE, SO I IMMEDIATELY LOOKED FOR A SAFE PLACE TO PULL OVER (NO GOOD SHOULDERS ON A WINDY COUNTRY ROAD), PUT THE VEHICLE IN NEUTRAL, ENGAGED THE EMERGENCY BRAKE, STOPPED AND TURNED OFF THE VEHICLE. WHEN I TURNED IT BACK ON, IT WAS RUNNING HIGH STILL. I TURNED IT OFF, SHOOK THE ACCELERATOR PEDAL VIGOROUSLY AND THE VEHICLE RAN LIKE NORMAL. I HAVE NOT USED THE CRUISE CONTROL SINCE AND HAVE REMAINED WITHOUT INCIDENT. *TR
AS I WAS WATCHING TV IN MY HOUSE WITH MY SON. I NOTICED SOME YELLOW FLICKERING LIGHTS THROUGH MY WINDOW SHADES. I THOUGHT THERE WAS A TOW TRUCK OUT FRONT. I OPENED THE SHADE AND IT WAS MY VAN ON FIRE. *TR
Safety Rating for the 1992 FORD E-150
NHTSA has not yet tested the 1992 FORD E-150 in its New Car Assessment Program.
Technical Service Bulletins for the 1992 FORD E-150
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 1992 FORD E-150
NHTSA has opened 1 investigation into potential safety defects in the 1992 FORD E-150.
Other Model Years of the FORD E-150
- 1989 FORD E-150 — 2 complaints
- 1990 FORD E-150 — 2 complaints
- 1991 FORD E-150 — 20 complaints
- 1992 FORD E-150 (current)
- 1993 FORD E-150 — 95 complaints
- 1994 FORD E-150 — 180 complaints
- 1995 FORD E-150 — 104 complaints
- 1996 FORD E-150 — 81 complaints
- 1997 FORD E-150 — 122 complaints
Other FORD Models
- FORD F-150 — 45,660 total complaints
- FORD EXPLORER — 42,140 total complaints
- FORD ESCAPE — 34,654 total complaints
- FORD FOCUS — 29,539 total complaints
- FORD FUSION — 28,243 total complaints
- FORD TAURUS — 23,867 total complaints
- FORD WINDSTAR — 19,456 total complaints
- FORD EDGE — 17,247 total complaints