2021 FORD BRONCO Structurebody Problems

Component/System Involved: Molded-in-Color (MIC) Hardtop – Composite Roof Panel What happened: The molded-in-color (MIC) hardtop on my 2021 Ford Bronco (2-door) has developed multiple visible stress cracks above the passenger-side window. These are not surface scratches — they are embedded, structural fractures in the composite roof material. The cracks have formed under normal, garage-kept driving conditions at just over 10,400 miles and continue to worsen. Safety risk: I am concerned these cracks pose a potential safety risk, particularly involving water intrusion during rainfall or car washes. The affected area is directly above the front-row passenger seat and adjacent to electrical systems, including interior lighting and airbags. If water penetrates the roof structure, it could lead to mold, short circuits, degraded visibility, or electrical malfunction — especially under motion. Additionally, the structural integrity of the hardtop could be compromised in a rollover scenario. Inspection history: A Ford dealership in Winchester VA...

Vehicles top is cracked and delaminating witch could come off in large sheets and cause harm to other vehicles and pedestrians The dealership got a rejection letter from ford and is resubmitting the claim again I was told they had another one in not too long ago with the same issue and they warranted it I need to drive the truck and am concerned about causing harm or damage to other vehicles or drivers

I am writing to report a serious safety issue with my 2021 Ford Bronco. While driving on the highway at approximately 55-60 mph in the early morning, I heard a loud noise and saw powder falling on me. Upon pulling over, I discovered that a large section of my hardtop had blown off. Specifically, the plastic part over the fiberglass detached. If there had been a car behind me, it would have certainly been struck by the debris. This incident poses a significant danger not only to me but to other motorists as well. Ford is aware of this issue but has refused to address it. I consider this a critical safety hazard and request that this matter be investigated promptly. I believe the manufacturer should replace the defective hardtop and take responsibility for ensuring the safety of their vehicles. Any assistance in resolving this issue would be greatly appreciated....

water is leaking from the passenger side roof through the passenger side door airbag when it rains. The passenger side top door airbag is constantly getting wet from this leak as water passes through.

The contact owns a 2021 Ford Bronco. The contact stated after the vehicle was parked in the rain, he noticed on the passenger’s side A-pillar, where the air bag marking was located that water was leaking into the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer where the cause was discovered as a clip was damaged allowing the water to get into the A-pillar. The dealer repaired the failure by adding additional sealant to the area. The contact stated he looked at the repair and contacted the dealer stating the repair was not proper. The dealer informed the contact that a TSB was recently issued for the failure. The contact was waiting for an appointment as parts needed to be ordered to repair the failure. The manufacturer was notified, and a case was opened. The approximate failure mileage was 600.