2003 CHRYSLER PT CRUISER Electrical System Problems

WHen the fog lights are engaged, smoke and burning smell appears to be coming inside the steering wheel on the left side.

I REPLACED MY VEHICLES BATTERY 2 DAYS AGO(NOV 12, 2019)(VERY OLD BATTERY AND WITH THE COLD IN MASSACHUSETTS IT NEEDED TO BE CHANGED). NOW WITH A PROPERLY FUNCTIONING BATTERY THE VOLTAGE REGULATOR IN PCM (NOT ALTERNATOR) IS SIGNALING ALTERNATOR TO RAISE CHARGING VOLTAGE INTERMITTENTLY TO AS HIGH AS 17.1VOLTS, BUT HAS BEEN FREQUENTLY BOUNCING BETWEEN 14.1V -16.7VOLTS. THIS INCREASE OF VOLTAGE TO A UNSAFE LEVEL CAUSES ALL ELECTRICAL ACCESSORIES THAT ARE IN CONNECTED TO THE CHARGING SYSTEM AND ARE OPERATIONAL TO FLASH/ FLICKER. EXTREMELY DISTRACTING AT NIGHT WITH HEADLIGHTS AND DASHBOARD FLASHING/ FLICKERING. AFTER A LOT OF RESEARCH I FOUND OUT THE PCM NEEDS TO BE REPROGRAMMED WITH THE PROPER UPDATED FIRMWARE IN ORDER TO FIX THE FACTORY WEAK PARAMETERS. I SPOKE WITH A SERVICE MANAGER TODAY(NOV 14,2019) AT MY LOCAL CHRYSLER DEALERSHIP (CENTRAL JEEP CHRYSLER DODGE RAM FIAT @ 56 BOSTON PROVIDENCE TPKE, NORWOOD, MA 02062) ABOUT THE PROBLEM...

THERE WAS AN ELECTRICAL FIRE WHERE THE RADIO CUP HOLDERS AND THE SHIFTER. CAR IS UNDRIVEABLE DUE TO THE DAMAGE. MY CAR WAS STATIONARY AT THE TIME. THE RADIO KEPT TURN ON AND OFF. I HEARD CRACKING WHEN I WENT INTO WORK. WHEN I CAME OUT I SAY THERE WAS A WHOLE LOT OF DAMAGE. I DID GET THE CAR STARTED AND WAS ABLE TO GET IT HOME, BUT IT'S NOT DRIVABLE SINCE THE CAR DIED AS I WAS PULLING INTO MY DRIVEWAY. WHEN I WENT TO PUT IT INTO PARK IT WAS LIKE PARK WAS NOT AN OPTION. AMD THE CAR KEPT MOVING SO I PUT THE E BREAK ON.

I DON'T TRULY KNOW WHAT'S HAPPEN TO IT N IF IT'S BEEN FIXED BUT I DO KNOW THAT PRIOR IT WOULD HAVE UNCONTROLLABLE SPEED CONTROL N STEERING PROBLEMS N GPS N VIDEO N AUTO RECORDING N RADIO FREQUENCIES.

VEHICLE WAS PARKED. TURNED OFF. MULTIFUNCTION SWITCH THAT HAD BEEN REPLACED PREVIOULSY MALFUNCTIONED AGAIN. FOG LIGHTS JUST CAME ON OUT OF NOWHERE LUCKILY I TURNED AROUND AND NOTICED IT. WHEN I OPENED MY CAR DOOR I NOTICED THE SWITCH WAS SMOKING. AFTER SOME QUICK THINKING I PULLED THE FUSE. IF I HAD NOT THOUGHT OF THIS I BELIVE IT WOULD HAVE CAUGHT MY CAR ON FIRE AND THE ONES PARKED NEXT TO IT. I HAVE HAD THE FUSE PULLED FOR A YEAR. FLASH FORWARD TO MY CURRENT STATE IN VA AND IT'S INSPECTION TIME. I FAILED FOR A FAULTY FUNCTION SWITCH. THE GUYS REPLACED THE SWITCH FIRST STOPLIGHT I COME TO NO SIGNAL. TOOK IT BACK TO GARAGE THEY SAID SWITCH WAS BAD OUT OF THE BOX. AFTER THIS EPIDEMIC THIS WILL BE THE 4TH MULTIFUNCTION SWITCH THAT I KNOW OF INSTALLED ON THIS CAR. HOW IN THE WORLD HAS...

TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. AFTER THE VEHICLE WAS STARTED, THE CHECK ENGINE AND AIR BAG WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER AND AN INDEPENDENT MECHANIC ON MULTIPLE OCCASIONS WHERE THE CATALYTIC CONVERTER, CPU, SPARK PLUGS, AND FUEL CAP WERE REPLACED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 151,000.

TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT STATED THAT THE VEHICLE STALLED AND THEN CAUGHT FIRE WITHOUT WARNING. THE CONTACT DID NOT DISCLOSE IF A POLICE REPORT WAS FILED OR NOT. THE DETAILS OF WHO EXTINGUISHED THE FIRE WERE UNKNOWN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 201,561.

THE WIRING HARNESS MELTED, WHICH CAUSED THE MULTIFUNCTION SWITCH TO BURN OUT AND RUNNING TAIL LIGHTS TO NOT WORK PROPERLY. REPLACED MULTIFUNCTION SWITCH AND BURNING SMELL CAME FROM STEERING COLUMN. PULLED NEW MULTIFUNCTION SWITCH AND NOTICED MELTED CONNECTORS. *TR

STOP AT A RED LIGHT AND WAS HIT FROM BEHIND BY ANOTHER CAR GOING OVER 30 MILES PER HOUR. IT PUSHED US INTO ANOTHER VEHICLE AND THE AIR BAGS DID NOT DEPLOY. MY HUSBAND AND SON GOT WHIP LASH. *TR

BATTERY WENT COMPLETELY DEAD AFTER ONLY TWO YEARS. HAD THE BATTERY REPLACED AND NOW THE DASHBOARD LIGHTS AND THE HEADLIGHTS FLICKER TERRIBLY AND EVEN MORE WHEN ON HIGH BEAMS. *TR

TL* THE CONTACT OWNS A 2003 CHRYSLER PT CRUISER. THE CONTACT STATED THE AIRBAG AND THE CHECK LIGHT ENGINE WARNING LIGHTS ILLUMINATED. THE CONTACT STATED THAT THE BATTERY WAS REPLACED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A MECHANIC WHERE IT WAS DIAGNOSED THAT THE ELECTRICAL SYSTEM NEEDED TO BE REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 84,000 AND THE CURRENT MILEAGE WAS 100,000. THE VIN WAS NOT AVAILABLE.

2003 CHRYSLER PT CRUISER. CONSUMER WRITES IN REGARDS TO IGNITION PROBLEMS. *SMD THE CONSUMER STATED SHE HAD A PROBLEM WITH THE RADIO GOING OUT, WHENEVER SHE HIT A BUMP IN THE ROAD. IT TURNED OUT, AFTER SEVERAL SERVICE APPOINTMENTS, THAT THE IGNITION KEY HAS BEEN KNOCKED OUT OF PLACE AND THE ELECTRICITY WAS OFF. *JB

LOW VOLTAGE LIGHT CAME ON, LOST ALL POWER ON THE HIGHWAY.I HAD TO HIT THE SHOULDER QUICKLY. I THEN TESTED CODE WITH KEY (3 CLICKS OFF/ON) GOT CODE P0622 AND P2403..TOWED TO A SHOP, TO FIND OUT THE WIRES FROM ALTERNATOR TO THE COMPUTER SHORTED OUT, IT'S A KNOWN PROBLEM, WIRING HARNESS RUNS ALONG CV SHAFT AND RUBS AGAINST A BOLT NEAR THE FRAME, THUS SHORTING OUT THE CHARGING SYSTEM AND BURNING OUT THE COMPUTER. SO NOW THE BILL FOR REPAIRS ARE ALMOST $650.00 AND LUCKY WE GOT OFF THE HIGHWAY IN TIME, ALMOST GOT HIT BY A SEMI CAUSE WE LOST POWER SO QUICK. I AM GLAD WE DIDN'T GET KILLED. IF CHRYSLER AND THE GOVERNMENT KNOWS THIS IS A PROBLEM WHY IS THERE NO RECALL.....OR A SAFETY WARNING . *TR

I'VE HAD THIS VEHICLE APPROX. 2 YEARS. AT AN EARLIER TIME I HAD USED THE FOG LIGHTS TWICE WITH NO INCIDENT. LATER AND PRIOR TO 12/17/13 THE FOG LIGHT INDICATOR APPEARED ON THE INSTRUMENT PANEL, THE FOG LIGHT SWITCH WASN'T EVEN TURNED ON BUT THE LIGHT CAME ON BY THEMSELVES. I JIGGLED THE SWITCH AND THE LIGHTS AND INDICATOR WENT OUT, AFTER THAT THE FOG LIGHTS WOULDN'T WORK AT ALL. ON 12/17/13 I WENT OUT TO MY GARAGE TO FIND THE FOG LAMPS ON. THE HEADLIGHTS WERE OFF, THE CAR NOT RUNNING, THE KEYS WEREN'T EVEN IN THE IGNITION. THE LIGHTS JUST CAME ON BY THEMSELVES. I MANAGED TO TURN THEM OFF (FOR THE NIGHT) ONLY TO FIND WHEN I GOT TO WORK THE NEXT MORNING I COULDN'T SHUT THEM OFF. I DROVE THE CAR HOME, FINALLY PULLED THE FUSE FOR THE FOG LAMPS AND RETURNED TO WORK. I'VE ALSO...

ABOUT 3 THREE YEARS AGO THE HEADLIGHTS STARTED FLICKERING AND THE RADIO LIGHT WOULD TOTALLY GO OUT. NOW THE FOG LIGHTS ARE COMING ON WITH THE CAR TURNED OFF. I AM TAKING THE CAR TO A MECHANIC - HOPEFULLY THEY CAN FIX THE ISSUE. *TR

2003 TURBO PT CRUISER ISSUE WITH ENGINE OVER HEATING LIGHT COMING ON ENGINE WAS NOT OVER HEATING. A WEEK LATER RUNNING LIGHTS AND FOGLAMPS STARTED COMING ON WHILE CAR IS OFF AND SITTING. CHECKED A SITE THAT SAID IT WAS A PROBLEM IN THE TURBO 2003 AND 2004 TURBO CRUISERS AND THE ISSUE WILL GET WORSE. MY CAR IS NOT INCLUDED IN THE RECALL. *TR

1. I GENERALLY DRIVE OUR 2003 CHRYSLER PT CRUISER WITH THE FOG LIGHTS ON DURING THE DAY, AND THE HEADLIGHTS AT NIGHT. THIS MEANS I WAS TURNING THE FOG LIGHT SWITCH ON THE TURN SIGNAL UNIT SEVERAL TIMES A DAY. 2. BEGINNING EARLY IN 2009 I EXPERIENCED TIMES WHEN THE FOG LIGHTS WOULD NOT TURN OFF WITH THE SWITCH WITHOUT A LOT OF CYCLING, OR THE FOG LIGHTS WOULD TURN THEMSELVES ON WHEN THE DOOR CLOSED. THE VIBRATION OF THE VEHICLE MADE THAT HAPPEN. THEN, WHEN TRYING TO GET THE FOG LIGHTS TO TURN OFF, THE SWITCH BEGAN TO SMOKE. TURNING OFF THE CAR CLEARED THAT, SO I STOPPED USING THE FOG LIGHTS. THE TURN SIGNALS AND HEADLIGHT PORTION OF THE SWITCH WORKED FINE. 3. I CONTACTED THE CHRYSLER DEALERSHIP AND WAS TOLD THEY WERE OUT OF THE SWITCH. I THEN CONTACTED A LOCAL AUTO MAINTENANCE COMPANY I HAVE USED...

HIGH BEAMS COMING ON WITHOUT BEING TURNED ON, AT FIRST ONCE OR TWICE A WEEK THEN EVERYDAY IT WOULD HAPPEN THEN EVERYTIME USING THE VEHICLE, THE HIGH BEAMS CAME ON AFTER I TURNED THEM OFF WHEN GETTING OUT OF MY CAR UPON RETURNING TO MY CAR WOULD NOT CRANK, THE HIGH BEAMS WHERE STILL ON, HAD TO GET MY CAR JUMPED STARTED, REMOVED THE FUSE AND HAVEN'T HAD THE HIGH BEAMS TO COME ON AGAIN, BUT I NEED MY HIGH BEAMS ESP. FOR LONG DISTANCE DRIVING THROUGH THE MOUNTAINS, THERE'S A SHORTAGE SOMEWHERE BETWEEN THE FUSE AND HIGH BEAMS LIGHTS. *TR

I PURCHASED A 2003 CHRYSLER PT CRUISER IN JULY 2008 IN OCT WE NOTICED LIGHTS FLICKERING HEADLIGHT SWITCH STARTED BURNING FOG LIGHTS CAME ON DIDN'T WORK BEFORE TOOK IT DODGE NEW SWITCH AND 22 PIN CONNECTOR . NEW PCM REPROGRAMMED IT STILL SAME PROBLEM LIGHTS FLICKER AND CHECK ENGINE LIGHT STAYS ON. *TR

FOG LIGHTS CONTINUE TO FLASH WITHOUT MY TURNING THEM ON. THIS IS MY THIRD DEAD BATTERY? IS THERE A RECALL? *TR

THIS PROBLEM STARTED IN THE SPRING OF 2006. ALTHOUGH I DIDN'T KNOW IT AT THE TIME, THE FOG LIGHTS CAME ON BY THEMSELVES WHILE JUST SITTING IN THE PARKING LOT OR AT HOME. NO WARNING, SO I DIDN'T KNOW UNTIL I WENT TO START THE CAR AND THE BATTERY WAS DEAD. SINCE THIS WAS INTERMITTENT, NO LIGHTS ON THE DASH ADVISING ME THE FOG LIGHTS WERE ON AND DURING DAYLIGHT HOURS, I NEVER NOTICED THAT THE FOG LIGHTS WERE ON. AFTER SEVERAL TIMES OF THIS HAPPENING. THIS CAUSED ME TO REPLACE THE BATTERY. WHILE REPLACING THE BATTERY I NOTICED THAT THE ORIGINAL CABLES HAD INFERIOR BATTERY CONNECTOR LEADS. THE CABLES CONNECTORS WERE MOSTLY EATEN THROUGH CAUSING ME TO HAVE TO REPLACE THEM. (I NOTICED THAT WHEN I GOT THE NEW LEADS THAT THE CONNECTORS WERE OF A BETTER MATERIAL). DUE TO THIS NOT HAVING ANY RIME OR REASON AS TO...

WE OWN A 2003 PT CRUISER. IT HAS MANIFESTED THREE SEPARATE PROBLEMS, ALL OF WHICH ARE SIMILAR TO COMPLAINTS I HAVE FOUND FROM OTHERS ON THE INTERNET: FIRST, THE "CHECK ENGINE" LIGHT COMES ON. THE DEALER SAID WE NEEDED TO CLICK THE GAS CAP. WE DID THAT, BUT THE LIGHT CAME BACK ON. SECOND, THE FOG LIGHT SWITCH FAILED SUCH SO THAT THE LIGHTS TURNED ON WITHOUT THE SWITCH BEING TOUCHED. WE DISCOVERED THE PROBLEM ONLY AFTER THE BATTERY HAD BEEN DRAINED, STRANDING MY WIFE AT WORK. I "FIXED" THIS PROBLEM BY PULLING THE FUSE ON THE FOG LIGHTS. I HAVE READ COMPLAINTS IN WHICH THIS FAULTY SWITCH HAS ACTUALLY STARTED FIRES. THIRD, WE HAVE THE INFAMOUS INTERMITTENT STARTING"PROBLEM. I HAVE REPLACED THE STARTER AND THE BATTERY. I CHECKED ALTERNATOR FUNCTION AND INTEGRITY OF ALL CABLE CONNECTIONS TO THE STARTER. THEN I READ OTHERS' COMPLAINTS AND HAVE FOUND THERE IS...

I PURCHASED A NEW 2003 PT GT TURBO CRUISER AND HAVE ELECTRICAL PROBLEMS SINCE DAY ONE. THE BATTERY HAS BEEN REPLACED TWICE AND THE LIGHTS HAVE NEVER STOPPED FLICKERING SINCE THE DAY I PURCHASED THE VEHICLE. THE CHRYSLER REPAIR FACILITIES WERE NICE TO DEAL WITH BUT THE PROBLEM HAS NEVER BEEN RESOLVED. I HAVE ALWAYS LIKED CHRYSLER PRODUCTS AND THROUGHOUT THE YEARS HAVE PURCHASED QUITE A FEW, AFTER THIS EXPERIENCE THIS WILL BE MY LAST CHRYSLER PRODUCT.

WE RECENTLY PURCHASED A USED 2003 PT CRUISER GT TURBO. WE REALLY LOVE IT. HOWEVER, THERE IS AN ISSUE WE HAVE BEEN TRYING TO FIGURE OUT. THE LIGHTING FLICKERS WHEN YOU START THE CAR. IT IS INTERMITTENT. AFTER RUNNING AWHILE IT DECREASES. USUALLY WHEN FIRST STARTING THE CAR IT IS REALLY BAD. WE DIDN'T NOTICE A DIFFERENCE WHEN WE USED MORE OR LESS POWER IN THE CAR, LIKE TURNING ON THE RADIO AND A/C. THE POWER FLUCTUATION MAKES ALL THE LIGHTS FLICKER INSIDE AND OUTSIDE OF THE CAR, AS WELL AS THE PANEL LIGHTS AND RADIO. *JB

2003 PT CRUSIER BOUGHT BRAND NEW. HEAD LIGHTS, INTERIOR LIGHTS, AND DASH LIGHTS ALL FLICKER HARD TO PAY ATTENTION WHEN DRIVING. CHRYSLER IS AWARE OF THE PROBLEM AND SAYS NO FIX. I WILL NEVER BUY ANOTHER CHRYSLER AGAIN, POOR CUSTOMER SERVICE. JUST WAITING FOR ALL LIGHTS TO FINALLY GO OUT. *JB

DT*: THE CONTACT STATED A KNOCKING SOUND IS HEARD WHEN THE VEHICLE IS PLACED INTO REVERSE, OR WHEN A STOP, AND THEN PLACED INTO PARK. THE SOUND IS COMING FROM THE DRIVER'S SIDE OF THE VEHICLE. THE VEHICLE STALLS AFTER EACH START AND HAS TO BE RESTARTED. THE DEALERSHIP DETERMINED THE LOWER CONTROL ARMS AND THE SKIM MODEL IN THE COMPUTER WAS DEFECTIVE AND NEEDS TO BE REPLACED. UPDATED 07/05/06. *JB

NOV 19, 2005 I PURCHASED A NEW LOT MODEL 2003 PT CRUISER WITH 14 MILES ON IT. AT 500 MILES I NOTIFIED THE DEALERSHIP WHERE I BOUGHT THIS VEHICLE THAT THERE WAS A PROBLEM OF FLICKERING HEADLIGHTS WHEN ANY OTHER ELECTRIC WAS TOUCHED IN VEHICLE, THIS ALSO HAPPENS WHEN NOTHING IS TOUCHED. THEY REPLACED THE BATTERY TWICE TO SEE IF THIS WAS THE PROBLEM, BUT THAT DIDN'T HELP. I HAVE TAKEN THE VEHICLE BACK TO THE DEALER ON AT LEAST FOUR OCCASIONS BUT THEY STILL CANNOT FIND THE PROBLEM.. I WAS ISSUED A TICKET BY THE POLICE FOR THIS PROBLEM AND HAVE GIVEN A COPY TO THE DEALERSHIP, THE TICKET SAID THAT THE PROBLEM IS TO BE FIXED OR I AM SUPPOSED TO STOP DRIVING IT.. I TOOK IT TO ANOTHER DEALERSHIP AND THEY REPROGRAMMED IT AND THAT HASN'T HELPED EITHER. I NEED TO HAVE THIS PROBLEM FIXED OR REPLACED...

CHECK ENGINE LIGHT COMES ON, CAR IDLES AT LOW RPM, AND STALLS AT ANYTHING NEAR 1000 RPM, WHICH IS ITS NORMAL IDLE SPEED, AT LEAST 25 STALLS IN THE PAST 2-3 MONTHS. SO FAR CHRYSLER KNOWS THERE IS A PROBLEM BUT CAN'T FIND IT, SO THEY KEEP GIVING IT BACK TO ME. *JB

SHORTLY AFTER PURCHASING OUR BRAND NEW 2003 PT CRUISER, WE NOTICED THE DASH LIGHTS AND HEADLIGHTS WOULD OCCASIONALLY FLICKER FOR NO APPARENT REASON. AT FIRST, IT WAS VERY INTERMITTENT AND WE DID NOT PAY MUCH ATTENTION TO IT. HOWEVER, SINCE ABOUT THE MIDDLE OF OCTOBER OF 2004, THE PROBLEM HAS GOTTEN MUCH WORSE. NOW WHENEVER THE BRAKE IS APPLIED, THE DASH LIGHTS AND THE HEADLIGHTS FLICKER VERY NOTICEABLY, AND THE FREQUENCY OF THE FLICKERING FOR NO REASON HAS INCREASED DRAMATICALLY. ON NOVEMBER 18, 2004, WE TOOK THE CRUISER INTO SPOKANE CHRYSLER TO CORRECT THE PROBLEM (INVOICE 147545). SPOKANE CHRYSLER WAS VERY COURTEOUS AND TRIED DILIGENTLY TO FIX THE PROBLEM. THEY REPLACED THE GENERATOR, THE POWERTRAIN CONTROL MODULE, AND EVEN TRIED A NEW BATTERY -- UNFORTUNATELY, NONE OF THEIR EFFORTS FIXED THE PROBLEM. SPOKANE CHRYSLER DID DISCOVER THAT THIS FLICKERING LIGHTS DEFECT WAS NOT UNIQUE TO OUR CRUISER. THE TECHNICIAN TESTED...

WHILE DRIVING AT ANY SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE DRIVER TRIED TO RESTART THE VEHICLE AND WAS ABLE TO DO SO. THE DRIVER NOTICED THAT THE VEHICLE DID NOT ACCELERATE OVER 60 MPH. WHILE DRIVING 60 MPH, THE DRIVER APPLIED THE ACCELERATOR PEDAL AND THE VEHICLE FAILED TO ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION NUMEROUS TIME. HOWEVER, THE MECHANIC CAN NOT DUPLICATE THE PROBLEM. PLEASE PROVIDE FURTHER DETAILS.

"CHECK ENGINE LIGHT" CAME ON REGULARLY, PROMPTING VISITS TO THE DEALER. WAS TOLD I WASN'T "CLICKING" THE GAS CAP ENOUGH TIMES UPON CLOSING IT. NUMBER OF TIMES TO BE CLICKED STARTED OUT AT 3 AND EVENTUALLY MOVED UP TO 7, INCREASING WITH EACH RETURN VISIT UNTIL I SCREAMED IN THE MIDDLE OF THE SERVICE AREA AND THEY ACTUALLY FIXED THE PROBLEM BY REPLACING THE LEAK DETECTION PUMP AND THE NATURAL VACUUM DETECTOR. SUNROOF MOTOR WOULDN'T RUN CONTINUOUSLY, THE SWITCH WOULD HAVE TO BE PUSHED REPEATEDLY TO GET THE ROOF TO CLOSE, MOVING A FRACTION OF AN INCH AT A TIME. THIS HAPPENED ON THREE SEPARATE OCCASIONS. PARTS REPLACED INCLUDED THE SWITCH, THE MOTOR, AND EVENTUALLY THE ENTIRE SUNROOF MOTOR ASSEMBLY. THE BIG PROBLEM: CAR WOULDN'T START, EVEN AFTER BEING JUMPED. THIS HAPPENED ON FIVE SEPARATE OCCASIONS DURING THE FIRST 16 MONTHS I OWNED THE CAR. PARTS REPLACED INCLUDE THE BATTERY...

I HAVE TAKEN MY 2003 PT CRUISER GT BACK TO THE DEALER EIGHT TIMES TO HAVE A CHECK ENGINE LIGHT PROBLEM REPAIRED. THE FIRST VISIT TO THE DEALER OCCURED ON JULY 3, 2003 THE SECOND VISIT TO THE DEALER OCCURRED ON JULY 9-12, 2003 THE THIRD VISIT TO THE DEALER OCCURED ON AUGUST 15-18, 2003 THE FOURTH VISIT TO THE DEALER OCCURRED ON MAY 7-12, 2004 THE FIFTH VISIT TO THE DEALER OCCURRED ON MAY 26-27, 2004 THE SIXTH VISIT TO THE DEALER OCCURRED ON JUNE 9TH, 2004 THE SEVENTH VISIT TO THE DEALER OCCURRED ON JUNE 28TH., 2004 (REPLACE LEAK DETECTION PUMP) THE EIGHTH VISIT TO THE DEALER OCCURRED ON JULY 16TH., 2004 (CAR TOWED) GENERAL SYPTOMS LEADING TO THE LIGHT COMING ON WERE HARD STARTING SEVERAL DAYS OR WEEKS PRIOR TO LIGHT COMING ON, AS WELL AS HESITATION UNDER ACCELERATION (OCCURED TWICE), AND THE LATEST INCIDENT IN WHICH...

WHILE DRIVING AT 55 MPH HEADLIGHTS WERE FLICKERING AND FINALLY BURNED OUT. VEHICLE WAS TAKEN TO THE DEALER EIGHT TIMES FOR THIS PROBLEM. DEALER HAS CHECKED EVERY COMPONENT, TRYING TO REPAIR THE PROBLEM, BUT TO NO AVAIL.*AK THE MANUFACTURER REPURCHASED THE VEHCILE FROM THE CONSUMER. *MJJ

WHEN CONSUMER BRAKES, THE HEADLIGHTS WOULD FLICKER. THIS CAUSES A DISTRACTION AT NIGHT TIME. DEALER HAS BEEN NOTIFIED. PH THIS ALSO OCCURED WHEN WINDOW SWITCH AND AUTO DOOR LOCKS WERE ENGAGED. DEALER CHECKED WIRING TO PCM, ALLG ROUNDS AND ELECTRICAL CONNECTIONS. NOTHING FOUND. *TT