2002 CHEVROLET SILVERADO 2500 Electrical System Problems

WHILE TOWING A 7000 LB 5TH WHEEL TRAILER THE ELECTRICAL PLUG BETWEEN THE VEHICLE AND TRAILER BECAME PARTIALLY DISLODGED AND AFFECTED THE VEHICLE ELECTRICAL SYSTEM WHICH MADE THE GAUGE NEEDLES GO HAYWIRE INCLUDING THE TACHOMETER. ENGINE STALLED WITH RESULTANT LOSS OF POWER STEERING AND BRAKES. LUCKILY WAS ABLE TO PULL INTO PARKING LOT AND STOP USING TRAILER BRAKES. REINSERTED PLUG FULLY INTO SOCKET AND HAVE NOT HAD A PROBLEM SINCE. *TR

I BELIEVE THAT I ALSO HAVE A PROBLEM WITH MY IGNITION AND FRONT PANEL. I CAN PULL MY KEY OUT IN ANY POSITION. EVERYTHING LIGHTS UP ON THE DASHBOARD AT ONE TIME OR ANOTHER. IT HAS CALLED MY VEHICLE TO STALL OR EVEN SHUT DOWN ALTOGETHER. I DON'T UNDERSTAND WHY MY VEHICLE HAS NOT BEEN RECALLED. I HAVE HAD IT IN SEVERAL TIMES BUT AM UNABLE TO FIND OUT WHAT THE CAUSE IS. PLEASE HELP ME. MY TRUCK SCARES ME SO MUCH, I'M AFRAID TO DRIVE IT, ESPECIALLY ON THE FREEWAY, OR ROADS THAT ARE BLACKED OUT FOR CELL PHONES, AND NO WAY TO GET HELP. *TR

BLOWER MOTOR STOPPED WORKING LAST YEAR. I HAD A NEW BLOWER MOTOR INSTALLED AND THE REPLACEMENT STOPPED WORKING. WHEN I BROUGHT MY TRUCK TO BE REPAIRED FOR THE SECOND TIME, I WAS INFORMED THAT THERE IS A PROBLEM WITH THE WIRING/RESISTOR WHICH SUPPLIES POWER TO THE BLOWER MOTOR. APPARENTLY, THE MOTOR PULLS MORE POWER THAN THE WIRING IS RATED FOR WHICH CAUSES IT TO HEAT UP AND BURN THE INSULATION OFF OF THE WIRING UNDER THE DASHBOARD. MY MECHANIC TOLD ME THAT I SHOULD CONSIDER MYSELF LUCKY THAT MY TRUCK DID NOT CATCH FIRE LIKE ANOTHER CUSTOMER'S TRUCK HE HAD RECENTLY REPAIRED FOR THE SAME REASON AS MINE HAD. I FEEL THAT I HAVE PAID FOR REPAIRS TWICE DUE TO DEFECTIVE GM PARTS. *TR

ON 01/10/2010 AT 2:45 A.M. WE WERE AWAKENED BY A PASSER BY WHO NOTICED OUR TRUCK WAS ON FIRE. BY THE TIME THE FIRE DEPARTMENT WAS ABLE TO PUT THE FIRE OUT IT HAD COMPLETELY DESTROYED OUR TRUCK, OUR CAR ,OUR GRANDSONS TRUCK AND $66,000.00 DAMAGE TO THE HOUSE WE WERE RENTING. WE LOST OUR VEHICLES AND 90% OF EVERYTHING WE OWN. IT WAS DETERMINED TO BE THE ENGINE BLOCK HEATER IN OUR 2002 CHEVY SILVERADO 2500 HD. WE HAVE BEEN IN CONTACT WITH GENERAL MOTORS. WE GAVE THEM ALL THE FIRE REPORTS FROM BOTH WEST VALLEY CITY FIRE DEPARTMENT AS WELL AS THE REPORT AND PICTURES PROVIDED BY THE INVESTIGATOR. THEY DO NOT CLAIM ANY RESPONSIBILITY FOR THE FIRE AND WILL NOT COMPENSATE US FOR OUR LOSS. *TR

THE CAR WAS OPERATING NORMALLY AS I WAS LEAVING THE PARKING LOT AFTER SHOPPING. THE ENGINE WAS AT NORMAL OPERATING TEMPERATURE. THE ENGINE STALLED, LOST POWER BRAKES AND STEERING. THIS OCCURRED FIVE TIMES IN A PERIOD OF APPROXIMATELY ONE WEEK. THE ENGINE WOULD RESTART AFTER ONE MINUTE OR MORE. THERE WERE NO SES OR MIL INDICATIONS OR DTC CODES. I GOOGLED THE FAILURE AND FOUND SEVERAL PEOPLE WITH SAME PROBLEM. I ALSO FOUND A NHTSA RECALL 06083 FOR A 2001 YEAR MY VEHICLE IS A 2002. I TOOK THE VEHICLE TO THE CHEVROLET DEALER AND HAD THE CRANKCASE POSITION SENSOR REPLACED AND THAT SOLVED THE PROBLEM. TO ELABORATE ON THE PROBLEM IT DID OCCUR WHILE I WAS DRIVING DOWN THE HIGHWAY AT 65 MILES PER HOUR. THAT IS VERY SCARY AND AS THIS IS A TRUCK I COULD HAVE BEEN TOWING MY BOAT. I DO HAVE THE DEFECTIVE PART. IT...

TL*THE CONTACT OWNS A 2002 CHEVROLET SILVERADO 2500 HD. INTERMITTENTLY, WHILE DRIVING VARIOUS SPEEDS, THE CONTACT NOTICED THAT THE BATTERY WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. AFTERWARDS, THE VEHICLE STALLED. NORMALLY AFTER THE FAILURE OCCURS, THE VEHICLE IS ABLE TO BE RESTARTED. IN ADDITION, THE VEHICLE EXHIBITED A NO-START CONDITION. THE CONTACT TOOK THE VEHICLE TO THE DEALER ON SEVERAL OCCASIONS AND THEY REPLACED THE ALTERNATOR, ON-BOARD ASSEMBLY IN THE COMPUTER SYSTEM, THROTTLE PLATE, AND REPROGRAMMED THE PCM. THE REMEDIES HAVE NOT CORRECTED THE FAILURES. THE FAILURE AND CURRENT MILEAGES WERE 138,000. UPDATED 07/24/09. *LJ

I OWN A 2002 CHEVROLET SILVERADO 2500 HD, 8.1 LITER, V8. IN THE PAST 4 MONTHS, THE VEHICLE COMPLETELY WOULD LOSE POWER AND SHUT OFF. AFTER A FEW MINUTES, THE VEHICLE WOULD RESTART. IT DID NOT MATTER THE SPEED OF THE VEHICLE, NOR DISTANCE DRIVEN. THERE WAS NO DASH BOARD LIGHTS ON INDICATING ANY PROBLEMS. I STALLED SEVERAL TIMES IN TRAFFIC, NEARLY MISSING/CAUSING ACCIDENTS. THE DEALER HAD VEHICLE FOR 3 DAYS AND SAID THERE WAS NOTHING ON DIAGNOSTIC SHOWING PROBLEMS. I REFUSED VEHICLE STATING I WAS NOT GOING TO ENDANGER MYSELF OR FAMILY TILL RESOLVED. IT WAS DETERMINED, AFTER THE GM BLOG AND PERSONAL INTERNET SEARCH OF THIS VEHICLE COMPLAINTS, THE CRANKSHAFT POSITION SENSOR WAS BAD. THE DEALER REPLACED FOR A CHARGE OF $288.38 PARTS/LABOR AT MY EXPENSE. THIS VEHICLE NEEDS A RECALL FOR THIS PART AND SOMEONE IS GOING TO BE SERIOUSLY HURT, ESPECIALLY WHEN THERE IS NO INDICATION...

MY 2002 CHEVY 2500 HD SILVERADO WITH 8.1 ENGINE QUITS RUNNING WHILE DRIVING. DOES NOT MATTER WHAT SPEED I'M GOING, IT JUST STOPS RUNNING. AFTER I PULL OVER PUT TRUCK IN PARK, TURN KEY OFF FOR A FEW MINUTES IT WILL USUALLY START UP. *JB