2001 CHEVROLET SILVERADO 2500 Electrical System Problems

GEAR SELECTOR LIGHTS AND MILEAGE LIGHTS DONT ILLUMINATE ON DASH, INTERMITTENTLY.

TRUCK JUST SHUTS OFF WHILE DRIVING. AS IF THE KEY WAS TURNED OFF AND THEN WON'T TURN BACK ON. IT HAS HAPPEND 3 TIMES IN THE LAST 3 WEEKS WHERE I AM DRIVING AND IT COMPLETELY JUST SHUTS OFF. CAN'T GET IT TO START BACK UP AND HAVE TO TOW IT HOME, IT WILL THEN TURN ON AND RUN FOR A FEW DAYS AND SHUTS OFF WHILE DRIVING

WHILE DRIVING DOWN THE HIGHWAY @ 75MPH THE VEHICLE SHUT OFF. THIS HAS NOW HAPPENED MULTIPLE TIMES AND IS A SAFETY ISSUE. WHILE IN TRAFFIC VEHICLES ARE HAVING TO MAKE QUICK ADJUSTMENTS TO AVOID HITTING MY VEHICLE AND FOR THEIR SAFETY. I CALLED THIS INTO OUR LOCAL CHEVY DEALERSHIP HERE IN COLORADO SPRINGS CO ALONG WITH CALLING CHEVROLET RECALL CENTER TO BE TOLD THAT MY VEHICLE IS NOT ON THEIR LIST. WELL APPARENTLY IT SHOULD BE ALONG WITH ALL THE OTHER 2001 2500 HD SILVERADO'S THAT ARE EXPERIENCING THIS PROBLEM.

WHILE DRIVING AT ANY SPEED, ENGINE WILL SUDDENLY SHUT OFF, REQUIRING ME TO PULL OFF THE ROAD (WITHOUT THE USE OF THE POWER STEERING) AND TO WAIT A FEW MINUTES TO RESTART THE ENGINE. HAD ONE CLOSE CALL, AS SOMEONE BEHIND ME HAD NOT NOTICED MY TRUCK SLOWING SUDDENLY. THEY HAD TO MAKE A QUICK ADJUSTMENT TO AVOID ME. THIS ENGINE FAILURE HAS HAPPENED ABOUT 10 OR TWELVE TIMES. DOING RESEARCH HAS FOUND THE PROBLEM TO ALMOST CERTAINLY BE THE CRANKSHAFT POSITIONING SENSOR. CHEVROLET TELLS ME THAT MY VIN NUMBER IS NOT ON THE RECALL LIST. AS THIS IS A SAFETY PROBLEM, WHY WOULD ONLY A CERTAIN NUMBER OF TRUCKS BE RECALLED TO BE FIXED? *TR

WHILE DRIVING THE TRUCK WOULD EXPERIENCE A SHUT DOWN AND LOSS OF POWER.MEROLLLIS CHEVROLET IN EAST PT., MICHIGAN, BECAME VERY DEFIANT,AND REFUSED TO ACKNOWLEDGE THAT THERE WAS A PROBLEM.BEFORE [XXX] BECAME CEO, [XXX] CONTACTED HER OFFICE VIA HANDWRITTEN COMMUNIQUE.IRIS CONTACT [XXX] IN DEC,2013,AND AN APPOINTMENT WAS TO BE ARRANGE W/ENGINEER BUT NEVER HAPPENED. [XXX] STOPPED DRIVING VEHICLE,EXCELLENT CONDITION W/19000 MILES.[XXX] WAS IN FEAR OF LIFE WHILE OPERATING VEHICLE..UPDATED 10/22/14 -BF INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) UPDATED 4/8/2015*JS *TR

THE ELECTRICAL WIRING HARNESS CONNECTED TO THE TURN SIGNAL LEVER WAS FOUND TO BE DEFECTIVE CAUSING THE LOW BEAM HEADLAMPS TO MALFUNCTION AND NOT PERFORM DURING NIGHT TIME HOURS. BASICALLY, THE LOW BEAM HEADLAMPS WOULD BLINK OUT AND NOT LIGHT WHILE THE VEHICLE IS BEING DRIVEN. THE TECHNICIAN FOUND SEVERAL WIRES HAD BURN AND DISCONNECTED FROM THE MAIN WIRING HOUSING CAUSING THE LOW BEAM HEADLAMPS TO MALFUNCTION. THIS WIRING HARNESS IS A DEALER ONLY PART AND HAS THE POTENTIAL OF CAUSING A FIRE WITHIN THE INSTRUMENT PANEL OF THE VEHICLE. I STRONGLY FEEL THERE SHOULD HAVE BEEN A MANUFACTURES RECALL ON THIS WIRING HARNESS SINCE IT IS A SAFETY ITEM. *TR

MY VEHICLE WOULD STALL OUT ON ME AT ANY TIME FOR ABOUT 2 MONTHS IT DIDN'T MATTER WHAT SPEED I WAS DOING OR WHERE I WAS IT WOULD STALL OUT SO I WOULD HAVE TO COAST TO THE SIDE OF THE ROAD WITH NO POWER STEERING AND WAIT TO CRANK THE VEHICLE BACK UP. THEN DECEMBER 23 2008 I WAS ON MY WAY HOME AND IT COMPLETELY STOPPED I COULDN'T GET IT TO CRANK BATTERY WAS COMPLETELY DEAD AND IT WAS AT NIGHT ON A HIGHWAY. I TOOK IT TO EVERY DEALER SHIP AND EVERY MECHANIC AND NOONE COULD TELL ME WHAT WAS WRONG WITH IT. FINALLY I LOOKED ONLINE AT RECALLS AND FOUND THAT THERE IS A RECALL FOR THE EXACT MAKE AND MODEL OF MY VEHICLE BUT WHEN I CALLED GMC THEY TOLD ME THAT THERE WAS NO RECALL FOR MY VEHICLE SO I WENT AND PAID OUT...

MY 2001 CHEVY WITH THE 8100 ENGINE WOULD STALL AT SPEED AND ALSO AT IDLE. THE AT-SPEED STALL WOULD RESTART ON ITS OWN WITHIN 3 OR 4 SECONDS. THE AT-IDLE STALL WOULD REQUIRE SOME ENGINE CRANKING BUT IT WOULD RESTART.(ODOMETER READING WAS 105,000KM)THERE IS A RECALL FOR THIS ENGINE (CRANK POSITIONING SENSOR)HOWEVER MY VIN IS OUTSIDE OF THE RECALL. DEALER NOT SURE WHAT TO DO. I HAD THEM REPLACE THE SENSOR AT MY EXPENSE. THIS MOVE RESOLVED THE STALL PROBLEM. IT HAS NEVER STALLED AGAIN. QUESTION: WHY WOULD MY VIN NOT BE INCLUDED IN THE RECALL....SAME SYMPTOMS ...SAME SOLUTION AS THE RECALL ! *TR

STARTING THE TRUCK START DRIVING AT DIFFERENT SPEEDS AND THE TRUCK JUST SHUTS DOWN. LET THE TRUCK SIT FOR A FEW MINUTES AND IT WILL RESTART. SEARCH THE INTERNET AND TALKED TO THE LOCAL DEALERSHIP MECHANICS AND THEY ALL SAID THAT THE CRANK SENSOR IS THE PROBLEM. *TR

WE WERE TRAVELING SOUTH ON I-5 WHEN WE STOPPED IN MEDFORD, OREGON TO FILL UP OUR 2001 CHEV. DURAMAX PICKUP WITH DIESEL. AFTER FILLING UP, WE NOTICED SMOKE AND A BURNT SMELL COMING OUT FROM UNDER THE HOOD. WE OPENED TO HOOD TO FIND WIRES SMOLDERING. WE IMMEDIATELY MOVED THE PICKUP AWAY FROM THE FUEL TANKS AT THE GAS STATION AND RE-OPENED THE HOOD. MY HUSBAND REMOVED THE PLASTIC SHROUD CONTAINING WHAT LOOKED TO BE ENCLOSED WIRES WHICH WERE SMOLDERING. I GOT THE FIRE EXTINGUISHER FROM THE GAS STATION ATTENDANT. AS MY HUSBAND WAS TRYING THE SEPARATE THE WIRES THAT WERE SMOLDERING WHICH WERE ALSO BURNING HIS FINGERS, FLAMES ERUPTED. WE USED THE FIRE EXTINGUISHER TO EXTINGUISH THE FLAMES. WE TOOK THE PICKUP TO THE DEALER IN JUNCTION CITY, OREGON (GUARANTY). THEY DIAGNOSED THE PROBLEM AS THE GLOW PLUG/INTAKE HEATER RELAY ASSEMBLY FAILURE WHICH CAUSED THE FIRE. IT WAS REPLACED...

PULLING AWAY FROM A STOP LIGHT, THE MOTOR AND ELECTRICAL SYSTEM SHUT DOWN. I COASTED OVER TO THE SIDE OF THE ROAD -- CONSTITUTING A TRAFFIC HAZARD TO OTHER MOTORISTS- AND RE-STARTED THE VEHICLE. THERE WERE NO OTHER INCIDENTS THAT DAY. MY SON AND DAUGHTER IN LAW REPORT SIMILAR EXPERIENCES ON SEPARATE OCCASIONS. *TR

I HAVE A 2001 2500 HD CHEVROLET WITH THE 8.1 LITER ENGINE. THE VEHICLE WILL STALL IN TRAFFIC AND WILL NOT START AGAIN. THE TRUCK WILL RUN ROUGH SOMETIMES WILL START AFTER A COOL DOWN PERIOD. THIS IS A VERY DANGEROUS SITUATION WITH IT STALLING IN TRAFFIC. THIS IS THE CRANKSHAFT SENSOR WHICH IS COVERED FOR SAME PICKUP WITH SAME ENGINE OUT OF A DIFFERENT PLANT. THEY SAY EVEN THOUGH IT IS THE SAME FAULTY PART MY PICKUP IS NOT COVERED BECAUSE IT IS FROM A DIFFERENT PLANT. THIS ALMOST CAUSED A ACCIDENT WHILE I WAS DRIVING AS IT STALLED AS I WAS MAKING A TURN. *TR

TL*THE CONTACT OWNS A 2001 CHEVROLET SILVERADO 2500 HD. WHILE PASSING TWO TRACTOR TRAILERS AT 55 MPH, THE VEHICLE SHUT OFF. THE CONTACT WAS ABLE TO SLOW THE VEHICLE DOWN AND MANEUVER TO THE SHOULDER. HE WAITED UNTIL THE VEHICLE RESTARTED. THE DEALER STATED THAT THE IGNITION SENSOR WAS FAULTY AND A HOLE WOULD NEED TO BE CUT IN THE FLOORBOARD TO MAKE THE NECESSARY REPAIRS. THE CONTACT REFUSED TO SUSTAIN MORE DAMAGE TO THE VEHICLE. THE FAILURE MILEAGE WAS 58,000 AND CURRENT MILEAGE WAS 70,000.

NHTSA ACTION NUMBER PE06016 2001 CHEVY 2500 HD 4X4 WITH 8.1 L; STALLING AT HIGHWAY SPEEDS, LOSS OF POWER STEERING AND BRAKES. BATTERY/SECURITY LIGHT COMES ON WHEN VEHICLE STALLS; VEHICLE MAY OR MAY NOT START FOR ABOUT 10-30 MIN AFTER STALL; CRANKING BUT NOT STARTING. ADDITIONAL, AFTER VEHICLE IS PARKED IT WILL CRANK BUT NOT START. REPLACED FUEL FILTER, CAP AND ROTOR, WIRES & PLUGS; HAD INJECTORS CLEANED AND THE PROBLEM HAS NOT BEEN FIXED. *NM