2003 CHEVROLET SILVERADO 1500 — Problems, Recalls & Safety Data

My heater started to shut off then I’d turn it off then turn it back on then it’d come back on again. That went on for a few days. Started my truck in the morning and let it warm up for a few moments when I hear truck is on fire. The fire was in the cab of the truck. It was investigated and they said fire started in the right side of the dash which is where the faulty part is from what I’ve learned about other Chevy trucks same make model and year as my truck

Instrument panel stopped working. Speedometer, fuel gauge and ammeter not working.

The vehicle was being driven in a parking lot, fortunately, when there was a loud snapping noise that resulted in the total loss of steering control. The vehicle was moving at about 5 MPH at time of the incident. 10 minutes prior, it was being driven on the Freeway at 60 to 65 MPH. In the parking lot, at the time of the steering failure, it was put into Park, ignition was turned off and a Tow service was called to tow vehicle home. The next day, I (the owner) inspected the steering system and found the reason it failed. A threaded connection on the "Pitman Arm" had snapped in half, terminating the connection between the steering column and the center link, causing catastrophic failure of steering system. The vehicle was transported to a repair facility where my diagnosis was confirmed. The Pitman Arm was replaced, at a cost of about $600.00 and returned to service. There were no warning signs, that I was aware of, prior to the component failure. In my opening sentence, I use the term "fortunately" , which truly is an understatement . Had the incident occurred 10 minutes earlier while on the freeway or if it hadn't occurred in a parking lot at a relatively low speed, I don't even like to think about the death, injury and damage that would have occurred.

When I try and use my left turn signal the hazard lights turn on!! Read numerous instances of this problem online with no solutions! A gentleman online referred me to turn this in to you(nhtsa.gov). The problem is ongoing!!

The undercarriage or frame of our recent purchase of our 2003 used chevrolet k1500 silverado was discovered recently after purchase to be rusted through and through and chipping off day by day. A private master mechanic has looked the truck over and said that it was not safe to drive. Upon further investigating, the panels that hold up the roof of the truck underneath the interior panels are rusting through and through to the point of breaking. Dealership we bought it from just shrugged their shoulders and said basically oh well, it was sold as is. under the truck on the frame where the wheels are attached, forgive my descriptions but im no mechanic, looks like they can break off at any minute. we have ony about 3/4 of a front and back bumper we later discovered, and the roof of the truck looks as if it had rusted and messed up beause someone before us put plaster to redo the roof of the truck. im scared to put my mother in law in this truck to go anywhere because if it got into a wreck... it would be devestating for everyone. truck has been in a wreck before. pictures and truck is available for inspection upon request,