1994 CHEVROLET G20 — Problems, Recalls & Safety Data
N/A
Safety Rating
53
Owner Complaints
7
Recalls
0
Service Bulletins
0
Investigations
Overview of the 1994 CHEVROLET G20
The 1994 CHEVROLET G20 has received a total of 53 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 7 recall campaigns affecting this vehicle, covering issues with EQUIPMENT, FUEL SYSTEM, GASOLINE, SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP. The most commonly reported problems involve the Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip (11 complaints), Air Bagsfrontal (4 complaints), and Service Brakes Hydraulicfoundation Componentsdiscrotor (3 complaints).
Recalls for the 1994 CHEVROLET G20
NHTSA has recorded 7 recalls for the 1994 CHEVROLET G20, potentially affecting up to 2,678,707 vehicles.
Recall 07E088000 — EQUIPMENT
| 121,680 vehicles affected
Defect: CERTAIN HONEYWELL FRAM RACING BRAND HP4 AND HP8 OIL FILTERS THAT WERE MANUFACTURED FROM MAY 25, 2006, THROUGH SEPTEMBER 14, 2007, AND SOLD FOR USE AS REPLACEMENT EQUIPMENT FOR VEHICLES LIST ABOVE. THE AFFECTED FILTERS ARE MARKED WITH A DATE CODE A61451 THROUGH A72571 SEQUENTIALLY. THE DATE CODE AND PART NUMBER APPEAR ON THE FILTER HOUSING. FRAM RACING HP4 AND...
Consequence: THIS CONDITION MAY CAUSE INADEQUATE SEALING AND LOSS OF ENGINE OIL, POSSIBLY RESULTING IN A FIRE.
Remedy: HONEYWELL WILL REPLACE THE AFFECTED OIL FILTERS FREE OF CHARGE. THE RECALL BEGAN DURING NOVEMBER 2007. OWNERS CAN CONTACT FRAM CUSTOMER SERVICE TOLL-FREE AT 1-800-890-2075.
View full details →Recall 06E043000 — FUEL SYSTEM, GASOLINE
| 88,303 vehicles affected
Defect: CERTAIN REPLACEMENT FUEL FILTERS, FRAM BRAND NAME P/N G3727, WITH DATE CODES X52911 THROUGH X60801 SEQUENTIALLY OR X600141 AND A MEXICO COUNTRY OR ORIGIN MARKING ON THE FUEL FILTER HOUSING MANUFACTURED FROM OCTOBER 18, 2005, THROUGH MARCH 21, 2006, SOLD FOR USE ON THE VEHICLES LISTED ABOVE AND ON CERTAIN SCHOOL BUSES. (TO SEE THE SCHOOL BUS ENGINE SIZES, CLICK...
Consequence: THIS CONDITION MAY CAUSE AN INADEQUATE SEAL AT THE CONNECTION, POTENTIALLY LEADING TO A FUEL LEAK. IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD OCCUR.
Remedy: HONEYWELL WILL NOTIFY OWNERS AND REPLACE THE FUEL FILTERS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT FRAM CUSTOMER SERVICE AT 1-800-890-2075 (OPTION 1).
View full details →Recall 99I006000 — SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
| 2,400,000 vehicles affected
Defect: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: CERTAIN LIGHT DUTY PICKUP TRUCKS, SPORT UTILITY VEHICLES, OR MINIVANS EQUIPPED WITH 3-SENSOR ABS (ANTILOCK BRAKING SYSTEM) EBC4 UNITS.
Consequence: THESE VEHICLES CAN EXPERIENCE EXTENDED STOPPING DISTANCES DURING ABS STOPS ON CERTAIN MULTIPLE SURFACES, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL MODIFY THE COMPUTER PROGRAM WHICH OPERATES THE ABS UNIT ON SOME VEHICLES, OR REPLACE THE COMPUTER ON OTHERS TO IMPROVE THE PERFORMANCE OF THE ABS ON THESE SURFACES.
View full details →Recall 94V177000 — SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
| 381 vehicles affected
Defect: THE FRONT DRIVER AND PASSENGER SEAT BACK HEIGHT DOES NOT CONFORM TO THE REQUIREMENTS OF FMVSS NO. 202, "HEAD RESTRAINTS."
Consequence: CONSEQUENCE OF NON-COMPLIANCE: SEAT OCCUPANTS ARE SUBJECT TO INCREASED RISK OF INJURY IN THE EVENT OF A SUDD STOP OR ACCIDENT.
Remedy: SHERRY DESIGNS WILL PROVIDE AN ATTACHABLE HEADREST FOR THE DEALER OR CUSTOMER TO ADD TO THE SEATS.
View full details →Recall 94V128000 — INTERIOR LIGHTING
| 6,088 vehicles affected
Defect: THE TRANSFORMER USED TO POWER THE NEON CENTER LIGHTBEAM CAN OVERHEAT AND CATCH ON FIRE.
Consequence: THE OVERHEATING AND FIRES CAUSED BY THE NEON TRANSFORMER CAN RESULT IN DAMAGE TO THE LIGHTBEAM ASSEMBLY, THE ROOF OF THE VEHICLE, AND COULD RESULT IN A VEHICLE FIRE.
Remedy: MARK III DEALERS WILL MODIFY THE ASSEMBLIES TO ELIMINATE THE NEON LIGHTING FIXTURE IN THE VEHICLE AND REPLACE IT WITH INCANDESCENT LIGHTS OPERATING DIRECTLY FROM THE VEHICLE 12-VOLT BATTERY.
View full details →Recall 94V087000 — EQUIPMENT:OTHER:LABELS
| 2,255 vehicles affected
Defect: THE MANUFACTURER'S CERTIFICATION LABEL AND/OR THE DRIVER AIR BAG ADVISORY LABEL MAY BE MISSING FROM THE VEHICLES, WHICH DOES NOT CONFORM TO THE REQUIREMENTS OF 49 CFR 567.
Consequence: CONSEQUENCE OF NON-COMPLIANCE: OWNERS OF VEHICLE WOULD BE UNAWARE OF THE LOAD CAPACITY OF THE VANS, THE VAN BUILD DATE, AND WOULD NOT HAVE ANY ASSURANCE THAT THE VANS MEET THE FEDERAL MOTOR VEHICLE SAFETY STANDARDS.
Remedy: THE LABELS WILL BE FURNISHED TO OWNER'S FOR INSTALLATION ON THE VEHICLES.
View full details →Recall 95I005000 — ENGINE AND ENGINE COOLING:ENGINE:DIESEL
| 60,000 vehicles affected
Defect: VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS, VANS AND MOTORHOMES EQUIPPED WITH ELECTRONICALLY FUEL INJECTED 6.5L DIESEL ENGINE. THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH FEDERAL REGULATION PART 573. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. THE CAMPAIGN WILL IMPROVE THE OVERALL DRIVEABILITY OF THESE VEHICLES.
Consequence: CERTAIN VEHICLES CAN EXHIBIT SOME DRIVEABILITY CONCERNS SUCH AS POOR THROTTLE RESPONSE, STALLING, MISFIRE, POOR HOT OR COLD STARTING, EXTENDED CRANKING OF A HOT ENGINE, OR STALLING AFTER START. TRUCKS WITH MANUALTRANSMISSIONS CAN EXHIBIT POOR ACCELERATION FROM START OR COULD STALL DURING DECELERATION.
Remedy: DEALERS WILL INSTALL SOME RECENTLY DEVELOPED ENHANCEMENTS WHICH WILL IMPROVE THE OVERALL DRIVEABILITY OF THESE VEHICLES.
View full details →Owner Complaints for the 1994 CHEVROLET G20
53 complaints have been filed with NHTSA for the 1994 CHEVROLET G20. Below is a breakdown by vehicle component.
Most Recent Complaints
WHILE DRIVING APPROACHING STOPLIGHT BRAKES WOULD NOT ENGAGE. PRESSED BRAKE PEDAL TO FLOOR AND DRIVE VAN UP AND OVER CURB WHILE USING EMERGENCY BRAKE. CONTACTED DEALER WHERE VAN WAS TOWED. SAID BRAKES NEEDED TO BE BLED AGAIN. BRAKES BLED AND PEDAL STILL FELT THE SAME-SPONGY. TOLD THIS IS NORMAL. DRIVING HOME ON WINDDY ROAD,APPLIED BRAKES NOTHING HAPPEND RELEASED BRAKES AND TRIED AGAIN AND THE FRONT BRAKES LOCKED UP. DEALER SAID TO BRING BACK. THEY INSPECTED SYSTEM SAID BAD MASTER CYLINDER. REPLACED MASTER CYLINDER AND STILL SPONGY BRAKES. DEALER SAID THIS IS NORMAL. THEY STILL DO NOT GRIP AS STRONG DESPITE ALL BRAKE COMPONENTS REPLACED EXCEPT FOR THE VACCUME BOOSTER AND ABS MODULE. I ALSO NO LONGER HEAR THE ABS MODULE COME ON LIKE IT USED TO BEFORE ALL OF THIS, THE ABS LIGHT DOES COME ON AND GOES OUT AFTER STARTING VAN. THE OWNERS MANUAL STATES YOU SHOULD HEAR THE ABS PUMP COME ON WHEN STARTING VAN THEN COME ON AGAIN AT ABOUT 7MPH. IT DOES NOT. TOLD DEALER THIS AND THEY SAID THE MANUAL IS WRONG AND THAT THE BRAKES ARE FINE. YEAH, RIGHT. WHEN GOING 55 MPH DOWN HILL VAN WOULD NOT SLOW DOWN UNLESS I HOLD THE BRAKE PEDAL ALMOST ALL THE WAY DOWN OR USE THE EMERGENCY BRAKE AND COME TO A VERY FAST STOP. AS THIS BEING A FAMILY VAN WE A SCARED TO DRIVE IT. OTHER MECHANICS CAME TO CONCLUSION THE ABS IS AT FAULT. POSSIBLE AIR IN CHAMBERS AND HAS TO BE SERVICED BY DEALER COMPUTER. DEALER SAYS THE ABS IS FINE. WE HAVE ALSO FOUND RECALL ON ABS, BUT OUR VAN IS NOT INCLUDED ACCORDING TO G.M. PLEASE HELP US GET THIS RESOLVED!! THANK YOU *TR
DT*: THE CONTACT STATED WHILE DRIVING LESS THAN 10 MPH ON AN ICY ROAD, A VEHICLE STOPPED SHORT IN FRONT OF THE CONTACT'S VEHICLE. IN AN ATTEMPT TO BRAKE, THE ABS ON THE VEHICLE DID NOT ENGAGE. THE CONTACT'S VEHICLE COLLIDED WITH THE VEHICLE IN FRONT OF IT. THERE WAS A DRILL-LIKE SOUND WHEN THE BRAKES ARE DEPRESSED. THE VEHICLE DOES NOT NORMALLY ENGAGE ON WET OR ICY SURFACES. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC. THERE IS A NHTSA RECALL, 99I006000, REGARDING THE SERVICE BRAKES. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.
NHTSA# 99-I-006-000: THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: CERTAIN LIGHT DUTY PICKUP TRUCKS, SPORT UTILITY VEHICLES, OR MINIVANS EQUIPPED WITH 3-SENSOR ABS (ANTI-LOCK BRAKING SYSTEM) EBC4 UNITS. THE CONSUMER'S VEHICLE EXPERIENCED THE SAME FAILURE, HOWEVER THE VEHICLE IDENTIFICATION NUMBER WAS NOT INCLUDED. *JB
ANTI LOCK BRAKES FAIL WHEN A BUMP, POT HOLE OR SLICK SURFACE IS ENCOUNTERED
VEHICLE PULLS TO THE LEFT WHEN APPLYING BRAKES. I HAD THE FRONT BRAKES REPLACED AND ROTORS TURNED LAST MONTH AT 32,095 ACTUAL MILES. THE PROBLEM OF PULLING TO THE LEFT CONTINUES WHEN BRAKES ARE APPLIED. WHEN BRAKES ARE RELEASED, IT PULLS TO THE RIGHT--IT DOESN'T RELEASE. IN CASE OF AN EMERGENCY STOP, IT PULLS TO THE LEFT, THEN RIGHT, THEN LEFT, THEN RIGHT. I WAS TOLD I NEED TO REPLACE THE BRAKE PRESSURE MODULATOR VALVE TO CORRECT THIS PROBLEM. THIS WILL COST APPROXIMATELY $1100.00. I FEEL THIS SHOULD NOT HAPPEN AT THIS LOW MILEAGE.*AK
View all Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip complaints →
Safety Rating for the 1994 CHEVROLET G20
NHTSA has not yet tested the 1994 CHEVROLET G20 in its New Car Assessment Program.
Technical Service Bulletins for the 1994 CHEVROLET G20
No technical service bulletins have been reported for this vehicle.
NHTSA Investigations for the 1994 CHEVROLET G20
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the CHEVROLET G20
- 1989 CHEVROLET G20 — 7 complaints
- 1990 CHEVROLET G20 — 18 complaints
- 1991 CHEVROLET G20 — 5 complaints
- 1992 CHEVROLET G20 — 29 complaints
- 1993 CHEVROLET G20 — 68 complaints
- 1994 CHEVROLET G20 (current)
- 1995 CHEVROLET G20 — 114 complaints
- 1996 CHEVROLET G20 — 9 complaints
- 1997 CHEVROLET G20 — 7 complaints
- 1998 CHEVROLET G20 — 2 complaints
- 1999 CHEVROLET G20 — 3 complaints
Other CHEVROLET Models
- CHEVROLET MALIBU — 28,991 total complaints
- CHEVROLET SILVERADO 1500 — 22,175 total complaints
- CHEVROLET IMPALA — 15,197 total complaints
- CHEVROLET TAHOE — 12,511 total complaints
- CHEVROLET EQUINOX — 12,135 total complaints
- CHEVROLET BLAZER — 11,032 total complaints
- CHEVROLET SILVERADO — 10,928 total complaints
- CHEVROLET SUBURBAN — 10,375 total complaints