2004 CHEVROLET CAVALIER Structurebodytrunk Lid Problems
2 NHTSA complaints on file
Structurebodytrunk Lid Issues in the 2004 CHEVROLET CAVALIER
2 structurebodytrunk lid complaints have been filed with NHTSA for the 2004 CHEVROLET CAVALIER. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.
2
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
All Structurebodytrunk Lid Complaints
DT: CONTACT STATES THERE IS A WATER LEAK IN HIS TRUNK CAUSED BY THE CAR NOT BEING PROPERLY WELDED DURING MANUFACTURING. THE WATER LEAK CAUSES MOLD AND MILDEW TO FORM ON THE CARPETING AND THE INTERIOR OF THE VEHICLE. THIS MOLD AND MILDEW IS CAUSING ILLNESS TO THE OCCUPANTS OF THE VEHICLE. THE SERVICE DEALER APPLIED SEAM SEALER TO THE VEHICLE, BUT DID NOT REMEDY THE PROBLEM. THE INTERIOR AND CARPET HAS BEEN REPLACED ONCE.. THE CONSUMER IS AFRAID TO USE THE SPARE TIRE BECAUSE THE WATER HAS CAUSED IT TO RUST. THE SERVICE DEALER STATED THEY WOULD HAVE TO REPLACE THE INTERIOR AND CARPET AGAIN. THIS SERVICE DEALER CONTACTED GENERAL MOTORS, AND STATED THEY WOULD NO LONGER WORK ON THIS VEHICLE BECAUSE THE CONSUMER PICKED UP THE VEHICLE TOO EARLY FROM THE DEALERSHIP. *AK
UPON DELIVERY OF NEW 2004 CHEVROLET CAVALIER, IT WAS DISCOVERED THAT TWO OF THE FOUR BOLTS THAT HOLD THE TRUNK LID TO THE VEHICLE WERE BROKEN COMPLETELY OFF. ALSO, THE REAR WINDOW HAD TO BE REMOVED AND NEW WEATHER STRIPPING HAD TO BE APPLIED BY THE DEALER BODY SHOP. THE WEATHER STRIPPING THAT WAS APPLIED AT THE FACTORY IN LORDSTOWN WAS NOT INSTALLED PROPERLY. THE TRUNK AND REAR SEAT WAS SOAKED WITH RAIN WATER THE DAY AFTER DELIVERY TO ME. THE BRAND NEW VEHICLE WAS IN THE BODY SHOP FOR A TOTAL OF 6 DAYS. CHEVROLET WAS NOTIFIED IMMEDIATELY OF THESE PROBLEMS BY ME. *JB
Other 2004 CHEVROLET CAVALIER Problem Areas
Electrical System
109 complaints
Electrical System Instrument Clusterpanel
67 complaints
Vehicle Speed Control
24 complaints
Steering
13 complaints
Unknown Or Other
13 complaints
Air Bags
11 complaints
Power Trainmanual Transmission
11 complaints
Engine And Engine Cooling
8 complaints
Fuel System Gasoline
8 complaints
Visibilitypower Window Devices And Controls
8 complaints
Electrical Systemwiringinteriorunder Dash
7 complaints
Engine
7 complaints
Engine And Engine Coolingengine
7 complaints
Service Brakes Hydraulic
7 complaints
Structurebody
7 complaints
Power Train
6 complaints
Seats
6 complaints
Exterior Lighting
5 complaints
Visibility
5 complaints
Suspension
4 complaints
Tires
4 complaints
Air Bagsfrontal
3 complaints
Electrical Systemignition
3 complaints
Equipmentelectricalradiotape Deckcd Etc
3 complaints
Fuelpropulsion System
3 complaints
Power Trainclutch Assembly
3 complaints
Power Trainclutch Assemblypedalhand Levermotorcycle
3 complaints
Seat Belts
3 complaints
Structure
3 complaints
Visibilityglass Siderear
3 complaints
Electrical Systemignitionswitch
2 complaints
Electronic Stability Control Esc
2 complaints
Equipment
2 complaints
Exterior Lightingheadlights
2 complaints
Latcheslockslinkages
2 complaints
Seat Beltsfront
2 complaints
Visibilitywiper
2 complaints
Wheelsrim
2 complaints
Air Bagsfrontalsensorcontrol Module
1 complaint
Electrical Systemignitionmodule
1 complaint
Electrical Systemstarter Assembly
1 complaint
Electrical Systemwiring
1 complaint
Electrical Systemwiringfront Underhood
1 complaint
Equipmentapplianceair Conditioner
1 complaint
Equipmentelectricalanti Theft Devices
1 complaint
Exterior Lightingturn Signal
1 complaint
Fuel System Gasolinestoragetank Assemblyfiller Pipe And Cap
1 complaint
Fuel System Other
1 complaint
Fuel System Otherdeliveryfuel Pump
1 complaint
Fuel System Otherstoragefuel Gauge System
1 complaint
Interior Lighting
1 complaint
Latcheslockslinkagesdoorslatch
1 complaint
Latcheslockslinkagestrunk Lidlock
1 complaint
Power Trainautomatic Transmission
1 complaint
Seat Belts Rearotherbuckle Assembly
1 complaint
Seatsfront Assemblyrecliner
1 complaint
Seatsmidrear Assembly
1 complaint
Service Brakes
1 complaint
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip
1 complaint
Service Brakes Hydraulicfoundation Componentsdisc
1 complaint
Service Brakes Hydraulicfoundation Componentsdiscpads
1 complaint
Service Brakes Hydraulicfoundation Componentsdiscrotor
1 complaint
Service Brakes Hydraulicfoundation Componentsdrumdrum
1 complaint
Service Brakes Hydraulicfoundation Componentsdrumshoeslinings
1 complaint
Service Brakes Hydraulicfoundation Componentsmaster Cylinder
1 complaint
Service Brakes Hydraulicpedals And Linkages
1 complaint
Steeringcolumn
1 complaint
Steeringhydraulic Power Assisthose Piping And Connections
1 complaint
Steeringrack And Pinion
1 complaint
Structurebodyhood
1 complaint
Suspensionfront
1 complaint
Suspensionrear
1 complaint
Vehicle Speed Controlaccelerator Pedal
1 complaint
Vehicle Speed Controlcruise Control
1 complaint
Vehicle Speed Controllinkages
1 complaint
Visibilitydefrosterdefoggerhvac System
1 complaint
Visibilitydefrosterdefoggerhvac Systemfanmotor
1 complaint
Visibilityrear Window Wiperwasher
1 complaint
Visibilityrear Window Wiperwashermotor
1 complaint
Visibilityrearview Mirrorsdevicesexterior
1 complaint
Visibilitywindshield Wiperwasher
1 complaint
Visibilitywindshield Wiperwashermotor
1 complaint
Wheels
1 complaint
Wheelshub
1 complaint