2004 CHEVROLET CAVALIER Fuelpropulsion System Problems
3 NHTSA complaints on file
Fuelpropulsion System Issues in the 2004 CHEVROLET CAVALIER
3 fuelpropulsion system complaints have been filed with NHTSA for the 2004 CHEVROLET CAVALIER. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.
3
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
All Fuelpropulsion System Complaints
AT TIMES, DURING THE PAST SEVERAL MONTHS THIS VEHICLE HAS BEEN HARD TO START. HAD THE FUEL PUMP AND IGNITION SWITCH REPLACED, BUT DID NOT SEEM TO SOLVE THE PROBLEM. RECENTLY, THE CAR STALLED OUT WHILE DRIVING AND TOOK 15 MINUTES TO FINALLY RE-START. I HAVE READ ONLINE WHERE THIS HAS BEEN A PROBLEM FOR OTHER OWNERS OF CHEVY CAVALIERS- HARD TO START AND STALLS OUT SOMETIMES. NOT SURE WHAT IS CAUSING THE PROBLEM, BECAUSE THE CHECK ENGINE LIGHT DOES NOT COME ON AND THERE IS NO CODE TO DIAGNOSIS/READ. *TR
2004 CAVALIER, 2.2L DOHC, 5-SPEED MANUAL TRANSMISSION. WHILE DRIVING AT 60 MPH VEHICLE FELT AS IF CRUISE CONTROL WAS ENGAGED. RPMS WOULD NOT FALL OFF AS FAST AS USUAL WHEN FOOT TAKEN OFF GAS, AND WHEN I DEPRESSED THE CLUTCH (WHICH WAS JUST REPLACED LAST WEEK DUE TO ANOTHER KNOWN ISSUE THAT CHEVY REFUSES TO RECALL) RPMS WENT ABOVE 4,000. TAPPED GAS PEDAL THINKING MAYBE IT WAS STUCK AND IT ONLY REVVED HIGHER AND DID NOT COME DOWN ON ITS OWN. RPMS CONTINUED TO CLIMB AS I CAME TO A STOP, AROUND 6,000 BY THE TIME I PULLED OVER. SHUT THE CAR OFF AND IMMEDIATELY BACK ON, NO PROBLEMS FOR THE REST OF THE TRIP HOME (ANOTHER 8 MILES). I CANNOT RISK MY CAR REVVING AT 6,000 RPMS IN STOP AND GO TRAFFIC WHICH I'M IN EVERY WEEKDAY AND I CAN'T SHUT IT OFF AND TURN IT BACK ON TO...
SO WHEN MY GAS GAUGES GET DOWN BELOW THE HALF LINE THE CHECK GAUGES LIGHT COMES UP AND I KNOW FOR SURE THAT MY CAR ISN'T YET EMPTY. WHAT DO I DO? *TR
Other 2004 CHEVROLET CAVALIER Problem Areas
Electrical System
109 complaints
Electrical System Instrument Clusterpanel
67 complaints
Vehicle Speed Control
24 complaints
Steering
13 complaints
Unknown Or Other
13 complaints
Air Bags
11 complaints
Power Trainmanual Transmission
11 complaints
Engine And Engine Cooling
8 complaints
Fuel System Gasoline
8 complaints
Visibilitypower Window Devices And Controls
8 complaints
Electrical Systemwiringinteriorunder Dash
7 complaints
Engine
7 complaints
Engine And Engine Coolingengine
7 complaints
Service Brakes Hydraulic
7 complaints
Structurebody
7 complaints
Power Train
6 complaints
Seats
6 complaints
Exterior Lighting
5 complaints
Visibility
5 complaints
Suspension
4 complaints
Tires
4 complaints
Air Bagsfrontal
3 complaints
Electrical Systemignition
3 complaints
Equipmentelectricalradiotape Deckcd Etc
3 complaints
Power Trainclutch Assembly
3 complaints
Power Trainclutch Assemblypedalhand Levermotorcycle
3 complaints
Seat Belts
3 complaints
Structure
3 complaints
Visibilityglass Siderear
3 complaints
Electrical Systemignitionswitch
2 complaints
Electronic Stability Control Esc
2 complaints
Equipment
2 complaints
Exterior Lightingheadlights
2 complaints
Latcheslockslinkages
2 complaints
Seat Beltsfront
2 complaints
Structurebodytrunk Lid
2 complaints
Visibilitywiper
2 complaints
Wheelsrim
2 complaints
Air Bagsfrontalsensorcontrol Module
1 complaint
Electrical Systemignitionmodule
1 complaint
Electrical Systemstarter Assembly
1 complaint
Electrical Systemwiring
1 complaint
Electrical Systemwiringfront Underhood
1 complaint
Equipmentapplianceair Conditioner
1 complaint
Equipmentelectricalanti Theft Devices
1 complaint
Exterior Lightingturn Signal
1 complaint
Fuel System Gasolinestoragetank Assemblyfiller Pipe And Cap
1 complaint
Fuel System Other
1 complaint
Fuel System Otherdeliveryfuel Pump
1 complaint
Fuel System Otherstoragefuel Gauge System
1 complaint
Interior Lighting
1 complaint
Latcheslockslinkagesdoorslatch
1 complaint
Latcheslockslinkagestrunk Lidlock
1 complaint
Power Trainautomatic Transmission
1 complaint
Seat Belts Rearotherbuckle Assembly
1 complaint
Seatsfront Assemblyrecliner
1 complaint
Seatsmidrear Assembly
1 complaint
Service Brakes
1 complaint
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip
1 complaint
Service Brakes Hydraulicfoundation Componentsdisc
1 complaint
Service Brakes Hydraulicfoundation Componentsdiscpads
1 complaint
Service Brakes Hydraulicfoundation Componentsdiscrotor
1 complaint
Service Brakes Hydraulicfoundation Componentsdrumdrum
1 complaint
Service Brakes Hydraulicfoundation Componentsdrumshoeslinings
1 complaint
Service Brakes Hydraulicfoundation Componentsmaster Cylinder
1 complaint
Service Brakes Hydraulicpedals And Linkages
1 complaint
Steeringcolumn
1 complaint
Steeringhydraulic Power Assisthose Piping And Connections
1 complaint
Steeringrack And Pinion
1 complaint
Structurebodyhood
1 complaint
Suspensionfront
1 complaint
Suspensionrear
1 complaint
Vehicle Speed Controlaccelerator Pedal
1 complaint
Vehicle Speed Controlcruise Control
1 complaint
Vehicle Speed Controllinkages
1 complaint
Visibilitydefrosterdefoggerhvac System
1 complaint
Visibilitydefrosterdefoggerhvac Systemfanmotor
1 complaint
Visibilityrear Window Wiperwasher
1 complaint
Visibilityrear Window Wiperwashermotor
1 complaint
Visibilityrearview Mirrorsdevicesexterior
1 complaint
Visibilitywindshield Wiperwasher
1 complaint
Visibilitywindshield Wiperwashermotor
1 complaint
Wheels
1 complaint
Wheelshub
1 complaint