NHTSA Complaint #11674097 — 2015 HYUNDAI ELANTRA

Vehicle routinely (3,000-5,000 miles, depending on oil used) maintained by qualified mechanics. Around 129,000 miles the engine began to knock / rattle. Mechanic was unable to determine the cause, but the rattle was only present between 0-40mph and would settle at higher speeds. Mechanic also noted the absence of sludge. Around 133,000 miles the vehicle stalled. The vehicle would start, but would stall again. Mechanic diagnosed timing chain failure and that the vehicle is burning oil. Vehicle has never indicated low oil, but it is now manually checked and burning about a quart of oil per 1,000 miles. Replaced timing chain and vehicle has continued to operate. Around 134,500 miles some power loss during low-speed acceleration and a slight engine rumble at lower speed. Mechanic diagnosed a wrist pin failure on cylinder 2. Vehicle may be inspected upon request. Vehicle stalls create some safety concerns, but have only occurred at low speeds. Vehicle timing chain was diagnosed by two different mechanics. When the vehicle was brought to a Hyundai dealership for a trunk latch recall in May of 2024 at 125,000 miles, no issues were noted. Vehicle has not been inspected by the manufacturer, police, or insurance represenstatives since May of 2024, with no reported issues. No check engine notifications or warnings appeared until the vehicle stalled. Prior to slightly decreased acceleration, the only notable indicator of an issue is the persistent engine rattle (knock, piston slap). The engine rattle began in February of 2025.