NHTSA Complaint #11614529 — 2016 KIA SEDONA

On May 10, 2024 my van all of sudden started to jerk, stall and then die. My husband was able to make it to the side of the road before it died, but barely. There was no warning, no oil pressure lights, no engine lights nothing. It was running fine and then it wasn't. We took it to a shop because Valley Kia of Modesto was slammed. The mechanic at the shop told us we needed to make sure there was oil in the vehicle as there was none. I told them that I'm always keeping up with my oil. They repaired it and it cost close to $3,000. Then one month later on September 8, 2024. my husband and I are driving and out of the blue this time it starts to make a clinking noise, stall and die on us. It died on the highway and my husband was able to keep it rolling to the side of the road. Again, no warning, no oil pressure light, no signal light, no warning at all. Once we are safe, my husband checks the oil, there is none in the engine. We had only drove 2,446 miles in total from when we picked up the van from the shop on August 6th. From August 6th to September 8th and only 2,446 miles later all of of the oil the mechanic put in the van was gone. I took it to Valley KIA of Modesto and they tried to say it was the other mechanic's fault. I explained that there is an underlying issue with the vehicle causing it to use up so much oil and no warning or anything. There was never any oil leaks under the vehicle, oil leaking out of the engine, or smoke coming out of the tailpipe. Nothing to indicate something was wrong. Now they tell me I need a new engine and is not willing to admit that there is an extended warranty on the oil pressure switch due to it malfunctioning. They did admit that they can tell the check engine light is not registering that the engine is bad or showing any indication it's not running right. Now I have a KIA Sedona that needs a new engine due to faulty sensors and some other underlying issue of extreme oil consumption.