NHTSA Complaint #11536777 — 2019 FORD EXPEDITION

On July 24th 2023, at approximately 2:15pm my wife and I were completely stopped at a red traffic light on 66th St N that crosses Ulmerton Rd in Pinellas County Florida. We were talking and listening to the radio, when all of a sudden, a loud shotgun or explosive sound filled the vehicle. I got hit with something in the chest that felt like a punch or a kick, knocking me out of breath. But my wife only heard the extremely loud noise. I was clutching my chest in pain as I thought I was shot. When the light turned green, I immediately pulled into a Dunkin donuts parking lot, and we exited the vehicle. There was no damage whatsoever on the inside and outside of the vehicle, but we smelled gun powder. My driver's seatbelt was stuck in the retracted position. I slowly drove to my home at 6500 30th Avenue N, St Petersburg, Fl 33710. I immediately called the Pinellas County Sheriff's Department to report the incident, because at the time I thought it was a gunshot. They have a record under my phone number. I had no idea what the loud gun sound was, so I started to research and found the driver's seat belt tensioner charge must have gone off. I called Auto Nation Ford and made an emergency appointment to bring the vehicle in. I explained everything to them, then dropped the vehicle off. Upon doing a full inspection, the Auto Nation Ford mechanic determined there was a factory short in the air bag circuit, which caused the seatbelt tensioner charge to explode. They found the location, under the center console & replaced all necessary wiring, sensors, modules, tensioner & seatbelt. I researched and found recalls for 2020 Expeditions and 2018 F150 pickups, but there was no recall for the 2019 Expedition. I can't imagine what would have happened if we were going fast on an interstate when it happened. Now I get in my 2 Ford vehicles and worry about it happening again. t turned out the kick in the chest was the seatbelt retracting 4 inches pulling me back in the seat.