NHTSA Complaint #10594850 — 2009 VOLKSWAGEN JETTA

WHILE DRIVING, A WARNING MESSAGE BRIEFLY APPEARED STATING ENGINE MANAGEMENT MALFUNCTION FOLLOWED BY A BLINKING HEAT COIL LIGHT. THE MANUAL SAID TO TAKE TO REPAIR STATION AS SOON AS POSSIBLE, BUT WITHIN 1 MILE THE JETTA TDI LOST POWER, MY CAR ALMOST STOPPING AND EVENTUALLY LOSING ALL POWER. LUCKILY I WAS NOT ON THE FREEWAY WHERE THIS WOULD HAVE BEEN VERY DANGEROUS, AND I WAS ABLE TO PULL TO THE SIDE OF A COUNTRY ROAD, CALLING FOR A TOW TRUCK. ANALYSIS FOLLOWING INSTRUCTIONS ON A VW SERVICE BULLETIN SHOWS THE PRIMARY FUEL PUMP THAT SUPPLIES THE SYSTEM FAILED AND THE VANE PUMP RELEASED METAL INTO THE ENTIRE FUEL SYSTEM, GETTING PAST THE FILTER (ANOTHER DEFECT?) AND GOING ALL THE WAY TO THE INJECTORS. THE ENTIRE SYSTEM EXCEPT THE GAS TANK WILL NEED TO BE REPLACED. VW SAYS THIS $7000 REPAIR IS NOT UNDER WARRANTY. VW SHOULD HAVE RECALLED THE FAULTY FUEL PUMP AND FAULTY FILTER THAT ALLOWED THE METAL TO CONTINUE INTO THE ENTIRE SYSTEM. I AM BEING TOLD THAT ONE DEALERSHIP IS HANDLING 2-3 OF THESE CASES A WEEK! I FIND ON THE INTERNET THAT THIS HAS CAUSED ACCIDENTS. *TR