NHTSA Complaint #10573205 — 2008 FORD ESCAPE HYBRID

SINCE THE FIRST TIME I EXPERIENCED A BRAKING FAILURE INCIDENT I HAVE DONE A LOT OF RESEARCH&VISITS TO MECHANICS TO RETRIEVE CODES THROWN FROM THE CAR OFF DIAGNOSTIC MACHINES. REPLACING THE HCU CARRIES A PREMIUM PRICE TAG OF $5K-7K. PRIOR TO THE FIRST ACCIDENT,THERE IS NO OBVIOUS WAY THAT I COULD HAVE DAMAGED THE HCU WITH MY VERY NORMAL DRIVING HABITS (I.E.NO HISTORY OF TOWING, NO LONG DOWNHILL BRAKING)&THE HCU IS NOT A COMPONENT SUSCEPTIBLE TO WEAR TO THE POINT OF EARLY FAILURE. I BELIEVE THAT THE ESCAPE HYBRIDS BRAKING SYSTEM IS DEFECTIVE BY DESIGN (HENCE THE TSB)&FAULT LIES WITH FORD.I CONSIDER THIS BRAKE FAILURE VERY SERIOUS&A PROBLEM THAT FORD HAD NEVER BOTHERED TO NOTIFY ME ABOUT OR RECALL.MY ATTEMPTS TO GET FORD'S ATTENTION ON THIS MATTER HAVE BEEN FRUITLESS.TO SUMMARIZE NHTSA IS NOT CONCERNED B/C NOBODY HAS GOTTEN KILLED BY THESE DEFECTIVE BRAKES. FORD CLAIMS NO RESPONSIBILITY FOR THIS VERY SERIOUS&SIGNIFICANTLY DANGEROUS DESIGN FLAW.AFTER SEVERAL EPISODES OF BRAKE FAILURE I FOUND TSB 05-8-5 (8/5/05 NHTSA ID#10017553:ESCAPEHYBRIDVEHICLES EXHIBIT THE YELLOW ABS&RED E- BRAKE WARNING LAMPS ILLUMINATING AFTER THE ENGINE IS STARTED,&AN INCREASE INBRAKE PEDALEFFORT)FORD CLAIMS NO RESPONSIBILITY TO DEAL W/THE PROBLEM.ITS NOT SAFE TO DRIVE W/O THE REPAIR,IT HAD NO VALUE BEING BROKEN,&I DID NOT HAVE THE CONSCIENCE TO SELL THE VEHICLE W/A DANGEROUS PROBLEM.FORDS FAILURE TO PROACTIVELY ADDRESS THIS SAFETY ISSUE IS RATHER APPALLING.FORD ABANDONED ME W/A$7,000 BILL TO REPAIR A PROBLEM THAT IS SOLELY RELATED TO THEIR POOR DESIGN.FIRST ACCIDENT DESCRIPTION:ABS WARNING LIGHT&SERVICE ENGINE LIGHT ILLUMINATED ON CLUSTER."SERVICE BRAKE SYSTEM"&"REGENERATIVE BRAKING DISABLED" ILLUMINATED ON MESSAGE BOARD. ON THE HIGHWAY IN RUSH HOUR TRAFFIC,UPON EXTREME BRAKING, BRAKES FAILED TO STOP THE VEHICLE IN TIME TO AVOID A REAR-END COLLISION WITH THE VEHICLE STOPPED IN FRONT OF ME. *TR