NHTSA Complaint #10568554 — 2011 FORD ESCAPE

CHECK ENGINE LIGHT CAME ON AND VEHICLE LOST POWER AND DIED. PULLED OVER TO THE SIDE OF THE ROAD AND TURNED OFF THE VEHICLE FOR A FEW MINUTES, THEN TURNED IT ON AND WAS ABLE TO PROCEED FOR ANOTHER 5-6 MILES, THEN THE ISSUE REPEATED. CHECK ENGINE LIGHT REMAINED ON, HOWEVER. FINALLY WAS ABLE TO COMPLETE MY TRIP WITHOUT FURTHER INCIDENT. THIS SAME ISSUE HAPPENED AGAIN ABOUT A WEEK LATER, WITH THE SAME OUTCOME AS THE FIRST TIME IT HAPPENED. SCHEDULED A REPAIR FOR 11/14/12 AT WHICH TIME I WAS INFORMED THAT THERE WAS A DEFAULT CODE P1450. CANNISTER WAS FULL OF FUEL. EVAPORATOR CANISTER, PIPE AND VALVE WERE REPLACED. TOTAL FOR THE REPAIR $557.16 PLUS SALES TAX BECAUSE VEHICLE MILEAGE EXCEEDED 36,000 WARRANTY CEILING. THEN ON MAY 16, 2013, WHILE ON VACATION, VEHICLE HAD SIMILAR PROBLEMS - ENGINE LIGHT CAME ON, VEHICLE LOST POWER AND DIED... PULLED OVER, TURNED OFF VEHICLE, TURNED IT BACK ON AND WAS ABLE TO MAKE IT TO THE NEXT TOWN WITH A FORD DEALERSHIP WHERE WE HAD A DIAGNOSTIC RUN ON THE VEHICLE. THIS TIME THE CODES WERE P0685 AND P2112, WHICH REQUIRED THE REPLACEMENT OF THE THROTTLE BODY AND MOTOR ASSEMBLY WHICH COST ANOTHER $314.18 PLUS SALES TAX. I HAVE SINCE RECEIVED A LETTER FROM FORD STATING THAT THE THROTTLE BODY IS NOW BEING COVERED UNDER THE CUSTOMER SATISFACTION PROGRAM 13N03, BUT WONDER WHY THERE IS NOT SIMILAR COVERAGE FOR THE EVAPORATOR CANNISTER ISSUE. *TR