NHTSA Complaint #10373202 — 2005 CHEVROLET COBALT

*PLEASE NOTE...THE INCIDENT DATE IS APPROXIMATE. WE HAVE A 2005 CHEVROLET COBALT SEDAN THAT WAS INVOLVED IN THE RECALL FOR THE POWER STEERING MOTOR INTERMITTENT POWER STEERING FAILURE. WE HAD NEVER HAD A PROBLEM WITH THE STEERING PRIOR TO THE RECALL BEING PERFORMED. AFTER THE RECALL WAS PERFORMED, WE BEGAN HAVING TROUBLE WITH INTERMITTENT POWER STEERING FAILURE - PLUS ADDITIONAL FAILURES. UPON START-UP, WE HAVE EXPERIENCED NO POWER STEERING, AND HAD TO SHUT THE VEHICLE OFF AND RETRY NUMEROUS TIMES BEFORE THE POWER STEERING RETURNS. IN ADDITION TO LOSS OF POWER STEERING, WE HAVE EXPERIENCED THE FOLLOWING ELECTRICAL PROBLEMS: TRACTION CONTROL LIGHT ILLUMINATING RANDOM CLICKING OF THE BRAKE SAFETY INTERLOCK RELAY / ACTUATOR (WITHOUT TOUCHING THE BRAKE). CHECK ENGINE LIGHT TRANSMISSION GOING INTO "LIMP MODE"..."SLAMMING" INTO GEAR WHEN SHIFTING FROM PARK - OR IMPROPER SHIFTING WHILE DRIVING. RANDOM DASH GAUGE FAILURE RANDOM FAILURES OF THE "DRIVER'S INFORMATION CENTER" - FLASHING, ETC. THIS WAS INITIALLY HAPPENING ONLY UPON START-UP...BUT STARTED HAPPENING WHILE DRIVING AS WELL - NEARLY LEADING TO AN ACCIDENT WHILE MY WIFE WAS DRIVING ON A BUSY URBAN STREET. SHE WAS FORTUNATELY ABLE TO DRIFT INTO THE TURN LANE AND COME TO A STOP TO AVOID A COLLISION AND LIKELY SERIOUS INJURY TO HERSELF AND OTHERS, AS IT WAS VIRTUALLY UNCONTROLLABLE. IN ADDITION TO THE LOSS OF POWER STEERING (WHILE DRIVING), THE TRANSMISSION ALSO WENT INTO "LIMP MODE", CAUSING VERY HARD SHIFTING AND MUCH DIFFICULTY IN DRIVABILITY. THIS HAS ALSO HAPPENED WHILE I WAS DRIVING THE VEHICLE. I AM 6'3", 260LBS., AND I WAS STRUGGLING TO CONTROL THE VEHICLE. I HAVE ALSO BEEN IN CONTACT WITH OTHER COBALT OWNERS WITH THE EXACT SAME SET OF "SYMPTOMS". IT IS CLEAR THAT THE MOTOR REPLACEMENT WAS NOT SUFFICIENT TO REPAIR THE PROBLEM, AND - IN SOME CASES - MAY BE LEADING TO FURTHER PROBLEMS AS IN OUR CASE. THIS VEHICLE IS VERY DANGEROUS! *TR