NHTSA Complaint #10173736 — 2003 FORD EXPLORER

HAVE A 2003 FORD EXPLORER 2WD THAT WAS PURCHASED NEW FROM LOCAL FORD DEALERSHIP. STARTED HAVING TRANSMISSION CONCERNS IN EARLY 2005, VEHICLES JUST OVER A YEAR OLD. AFTER TAKING IT IN TO THE DEALERSHIP 4 TIMES IN A YEAR, WAS TOLD THEY COULDN'T VERIFY THE PROBLEM. FINALLY, IN MARCH 2005 WAS TOLD THEY HAD TO TEAR TRANSMISSION DOWN AND REPLACE THE CLUTCH PACK, ON TESTING TRANSMISSION, LINE PRESSURE WAS LOW. AFTER WORK PERFORMED, TOOK BACK AGAIN, WAS HAVING SAME CONCERN, AGAIN TOLD COULDN'T VERIFY PROBLEM. HAD TRANSMISSION SERVICED, AFTER TELLING THEM I WAS EXPERIENCING SAME PROBLEM, THEY SERVICED TRANSMISSION AND SAID ALL WAS FINE. IN OCTOBER OF 2006, WAS HEADING OUT OF TOWN ON A TWO LANE ROAD, WHEN I WENT TO PASS A BIG RIG ON HIGHWAY 113, JUST OUTSIDE OF WOODLAND, AS I GOT AROUND BIG RIG, AND ACCELERATED, THE CAR WOULDN'T GO INTO 3RD GEAR, THE RPMS KEPT RACING AND FALLING, RACING AND FALLING. I HAD PLENTY OF ROOM TO PASS THIS TRUCK, OR SO I THOUGHT, UNTIL THE CAR DID WHAT IT DID. I WAS NEARLY HIT HEAD ON BY AN ONCOMING CAR BECAUSE I COULDN'T GET AROUND THE TRUCK, DUE TO THE TRANSMISSION NOT SHIFTING INTO A HIGHER GEAR. WE GOT TO WOODLAND AND IMMEDIATELY WENT TO FORD DEALERSHIP WHERE WE WERE TOLD THE TRANSMISSION WAS NOT SERVICEABLE, AND THAT WE WOULD NEED A NEW TRANSMISSION INSTALLED. UPON RETURNING HOME, AND DOING SOME RESEARCH, HAVE DISCOVERED THERE ARE HUNDREDS OF PEOPLE OUT THERE THAT HAVE HAD EXACT SAME FAILURE OF THEIR TRANSMISSIONS. CONTACTED FORD MOTOR CO., AND HAVE HAD NO RESULT. LOCAL DEALERSHIP SAYS SORRY, CAR IS OUT OF WARRANTY NOW, IT WILL COST AROUND 3600.00. ASKED WHAT HAS TO HAPPEN BEFORE FORD RECOGNIZES THEY HAVE A PROBLEM WITH THIS TRANSMISSION, AND WAS TOLD THEY DIDN'T KNOW. VERY DANGEROUS IN MY OPINION, TO BE OUT ON A HIGHWAY AND HAVE THE CAR LOSE THE 3RD GEAR, PREVENTING YOU FROM GOING OVER ABOUT 25 MILES PER HOUR. *JB