2007 VOLVO S80 — Problems, Recalls & Safety Data
N/A
Safety Rating
32
Owner Complaints
5
Recalls
8
Service Bulletins
0
Investigations
Overview of the 2007 VOLVO S80
The 2007 VOLVO S80 has received a total of 32 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 5 recall campaigns affecting this vehicle, covering issues with SEAT BELTS:FRONT, STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS, EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM). 8 technical service bulletins have been issued by Volvo Car USA, LLC for this model year. The most commonly reported problems involve the Structurebody (5 complaints), Engine (4 complaints), and Steering (4 complaints).
Recalls for the 2007 VOLVO S80
NHTSA has recorded 5 recalls for the 2007 VOLVO S80, potentially affecting up to 333,020 vehicles.
Recall 20V378000 — SEAT BELTS:FRONT
| 308,260 vehicles affected
Defect: Volvo Cars of N.A., LLC (Volvo) is recalling certain 2008-2016 V70 and XC70, 2007-2016 S80, 2011-2018 S60 and V60, 2016-2018 S60 Cross Country, 2014-2020 S60L, 2009-2015 S80L, 2009-2016 XC60 and 2015-2018 V60 Cross Country vehicles. The flexible steel cable that connects the seat belt to the front outboard seating positions may fatigue over time, causing the seat belt to not...
Consequence: An unsecured occupant has an increased risk of injury in the event of a crash.
Remedy: Volvo will notify owners, and dealers will replace the seat belt anchor cable for both front seats. The recall began December 10, 2020. Owners may contact Volvo customer service at 1-800-458-1552. Volvo's number for this recall is R10029.
View full details →Recall 11V378000 — STEERING:HYDRAULIC POWER ASSIST:HOSE, PIPING, AND CONNECTIONS
| 8,406 vehicles affected
Defect: VOLVO IS RECALLING CERTAIN MODEL YEAR 2007 S80 PASSENGER CARS MANUFACTURED FROM MARCH 8, 2006, THROUGH MAY 16, 2007. THE POWER STEERING RESERVOIR RETURN HOSE MAY HAVE BEEN INCORRECTLY ROUTED, WHICH CAN RESULT IN INCREASED PRESSURE IN THE POWER STEERING SYSTEM. THE POWER STEERING RETURN HOSE MAY BURST AT THE STEERING GEAR DUE TO THE INCREASED PRESSURE, RESULTING IN A...
Consequence: THE DRIVER MAY EXPERIENCE A SUDDEN LOSS OF POWER STEERING, INCREASING THE RISK OF A CRASH.
Remedy: VOLVO DEALERS WILL INSPECT THE ROUTING OF THE POWER STEERING RESERVOIR RETURN HOSE AND MAKE REPAIRS AS NECESSARY, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2011. OWNERS MAY CONTACT VOLVO AT 1-201-768-7300.
View full details →Recall 10V566000 — EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
| 416 vehicles affected
Defect: VOLVO IS RECALLING CERTAIN VEHICLES EQUIPPED WITH GARMIN 760 PORTABLE GLOBAL POSITIONING SYSTEM (GPS) UNITS BECAUSE THE BATTERIES ON THOSE UNITS MAY OVERHEAT.
Consequence: AN OVERHEATED BATTERY COULD LEAD TO A FIRE.
Remedy: VOLVO ADVISES OWNERS TO PLEASE STOP USING THE GARMIN PORTABLE GPS DEVICE IMMEDIATELY, AND VISIT THE GARMIN WEBSITE TO DETERMINE IF THEIR UNIT IS AFFECTED. THE UNIT'S BATTERY WILL BE REPLACED WITH A NEW BATTERY AND A SPACER WILL BE...
View full details →Recall 10V335000 — TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
| 3,635 vehicles affected
Defect: VOLVO IS RECALLING CERTAIN MODEL YEAR 2007-2010 S80 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE TIRE AND LOADING INFORMATION LABEL AND A PAGE IN THE OWNER'S MANUAL CONTAIN INCORRECT MAXIMUM PERMISSIBLE INFLATION PRESSURE AND THE TIRE PRESSURE MONITORING SYSTEM (TPMS) SOFTWARE HAS AN INCORRECT TRIGGER LEVEL.
Consequence: THESE VEHICLES DO NOT MEET THE REQUIRED SAFETY STANDARDS.
Remedy: DEALERS WILL UPDATE THE VEHICLES WITH A NEW TIRE AND LOADING INFORMATION LABEL, OWNER'S MANUAL LABEL AND TPMS SOFTWARE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT AUGUST 27, 2010....
View full details →Recall 09V139000 — ELECTRICAL SYSTEM:SOFTWARE
| 12,303 vehicles affected
Defect: VOLVO IS RECALLING 12,303 MY 2007-2008 S80 AND V70 VEHICLES. THE DIAGNOSTIC SOFTWARE IN THE CENTRAL ELECTRONIC MODULE (CEM) MAY CAUSE A MALFUNCTION OF THE WINDSHIELD WIPER FUNCTIONALITY. IF THIS CONDITION OCCURS, THE WINDSHIELD WIPERS MAY NOT OPERATE WHEN ACTIVATED; OR IN CERTAIN CASES THE WINDSHIELD WIPERS MAY ACTIVATE WHEN NOT SWITCHED ON.
Consequence: OPERATING A MOTOR VEHICLE DURING INCLEMENT WEATHER CONDITIONS WITHOUT FUNCTIONING WINDSHIELD WIPERS CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE CEM AND UPGRADE THE SOFTWARE FREE OF CHARGE. THE RECALL BEGAN ON MAY 15, 2009. OWNERS MAY CONTACT VOLVO CUSTOMER CARE CENTER AT 1-800-458-1552, OR [email protected].
View full details →Owner Complaints for the 2007 VOLVO S80
32 complaints have been filed with NHTSA for the 2007 VOLVO S80. Below is a breakdown by vehicle component.
| Component | Complaints | Crashes | Fires | Injuries | Deaths |
|---|---|---|---|---|---|
| Structurebody | 5 | 0 | 0 | 0 | 0 |
| Engine | 4 | 0 | 0 | 0 | 0 |
| Steering | 4 | 0 | 0 | 0 | 0 |
| Electrical System | 3 | 0 | 0 | 0 | 0 |
| Unknown Or Other | 3 | 0 | 0 | 0 | 0 |
| Exterior Lighting | 2 | 0 | 0 | 0 | 0 |
| Visibility | 2 | 0 | 0 | 0 | 0 |
| Visibilitywiper | 2 | 0 | 0 | 0 | 0 |
| Electrical Systemsoftware | 1 | 0 | 0 | 0 | 0 |
| Fuel System Gasoline | 1 | 0 | 0 | 0 | 0 |
| Seat Beltsfrontwarning Lightdevices | 1 | 0 | 0 | 0 | 0 |
| Service Brakes Hydraulic | 1 | 0 | 0 | 0 | 0 |
| Structure | 1 | 0 | 0 | 0 | 0 |
| Suspension | 1 | 0 | 0 | 0 | 0 |
| Tirespressure Monitoring And Regulating Systems | 1 | 0 | 0 | 0 | 0 |
Most Recent Complaints
The contact owns a 2007 Volvo S80. The contact stated that while operating the vehicle during a rainstorm; rainwater leaked into the vehicle from the top section of the driver's side of the windshield, creating a visibility hazard for the driver. The cause of the failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted regarding the failure. The failure mileage was 150,000.
The contact owns a 2007 Volvo S80. The contact stated that while operating the vehicle during a rainstorm; rainwater leaked into the vehicle from the top section of the driver's side of the windshield, creating a visibility hazard for the driver. The cause of the failure was not determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not contacted regarding the failure. The failure mileage was 150,000.
These generation of Volvo p3 platform cars had a defective windshield seal that was not the best from the factory. Many cars of this generation (S60, S80, XC90, etc) have had the seals break, causing extreme water leakage as mine has had. And the possibility of the windshield falling out. Mine is bad enough that pushing it lightly from the inside to create a significant gap in the window and the frame of the A pillar. There are many forums and reports of this exact problem and Volvo has yet to voluntarily recall these cars. Many people have reported it to many dealers, but all say they cant replace them. This problem definitely puts the driver and other people in the cabin in danger. And no warning lights go off in relation to the problem. I appreciate your consideration.
Warning light on dashboard indicated right front headlamp out. Repair shop removed and replaced original component with new component. Internal inspection of light assembly revealed missing insulation(photos attached) on wiring harness causing a short circuit which also ruined the headlight igniter and control module. Shop stated that this issue is NOT uncommon with Volvo lighting systems. The current concern is the same condition is present in the left(driver) headlight and could cause a short and fire within the headlight assembly. Correspondence with Volvo resulted in no resolution of the issue and lack of concern for the reliability of installed components or possible safety concern for their product.
Warning light on dashboard indicated right front headlamp out. Repair shop removed and replaced original component with new component. Internal inspection of light assembly revealed missing insulation(photos attached) on wiring harness causing a short circuit which also ruined the headlight igniter and control module. Shop stated that this issue is NOT uncommon with Volvo lighting systems. The current concern is the same condition is present in the left(driver) headlight and could cause a short and fire within the headlight assembly. Correspondence with Volvo resulted in no resolution of the issue and lack of concern for the reliability of installed components or possible safety concern for their product.
Safety Rating for the 2007 VOLVO S80
NHTSA has not yet tested the 2007 VOLVO S80 in its New Car Assessment Program.
Technical Service Bulletins for the 2007 VOLVO S80
Volvo Car USA, LLC has issued 8 technical service bulletins (TSBs) for the 2007 VOLVO S80. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
TJ33250 — SERVICE BRAKES, HYDRAULIC
This is a Technical Journal: *If early or uneven wear occur on the right side front brake pads (mainly inner pad), then follow advice under Service. Concerned vehicles are equipped with 16" and 16.5" FNR front brake system, and can be identified with VDN code RE03. *If symptom is confirmed...
TJ30619.1.2 — VISIBILITY:REARVIEW MIRRORS/DEVICES:EXTERIOR
This is a Technical Journal: Customer may experience some play (tilting up/down, y-axis) in the outer rear view mirror. In case of customer complaints install repair kit
6453 — STEERING:HYDRAULIC POWER ASSIST:PUMP
STRON WHINING NOISE FROM POWER STEERING PUMP WHILE MOVING THE STEERING WHEEL. *KB
TJ-23905 — LATCHES/LOCKS/LINKAGES:DOORS:LATCH
VOLVO: CHILD LOCK SERVICE REQUIRED MESSAGE MAY APPEAR WITH FOUR POSSIBLE TROUBLE CODES PRESENT, BUT THE LATCH WILL STILL FUNCTION. *RM
US24111 — SEATS:FRONT ASSEMBLY:HEAD RESTRAINT
VOLVO: REAR SEAT ENTERTAINMENT IS NOT WORKING BECAUSE OF AN ELECTRICAL HARNESS. *RM
SC-232 — ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
VOLVO: COOLANT BLEEDER HOSE, LEAKING. VEHICLES EQUIPPED WITH ENGINE VIN CODE 98 7 99 S16. *PE
6425 — STEERING:HYDRAULIC POWER ASSIST:POWER STEERING FLUID
POWER STEERING FLUID LEAKAGE INTO THE STEERING RACK BELLOWS. *KB
173 — UNKNOWN OR OTHER
NEW SOFTWARE TO IMPROVE METHODS TO HELP INSURE CUSTOMER SATISFACTION. *KB
NHTSA Investigations for the 2007 VOLVO S80
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the VOLVO S80
- 2002 VOLVO S80 — 59 complaints
- 2003 VOLVO S80 — 30 complaints
- 2004 VOLVO S80 — 63 complaints
- 2005 VOLVO S80 — 26 complaints
- 2006 VOLVO S80 — 22 complaints
- 2007 VOLVO S80 (current)
- 2008 VOLVO S80 — 37 complaints
- 2009 VOLVO S80 — 20 complaints
- 2010 VOLVO S80 — 36 complaints
- 2011 VOLVO S80 — 8 complaints
- 2012 VOLVO S80 — 11 complaints
Other VOLVO Models
- VOLVO XC90 — 2,131 total complaints
- VOLVO S60 — 1,655 total complaints
- VOLVO V70 — 1,177 total complaints
- VOLVO XC60 — 846 total complaints
- VOLVO S70 — 780 total complaints
- VOLVO 850 — 732 total complaints
- VOLVO S40 — 677 total complaints
- VOLVO V70XC — 521 total complaints