2000 VOLVO S80 Engine And Engine Coolingenginegasoline Problems

MY 2000 VOLVO S80 T6 STALLS (TYPICALLY IN JUNCTIONS) AFTER 120K MAINTENANCE SERVICE / RECALL 155 ETM SOFTWARE UPGRADE. THE SERVICE WAS PERFORMED ON 5/12/06 AT AUTHORIZED VOLVO DEALER (128VOLVO.COM). SINCE THE SERVICE, THE CAR STALLED 5 TIMES, AND HAS BEEN TO THE DEALERSHIP THREE MORE TIMES, WITHOUT A FIXING THE PROBLEM. THE DEALER REJECTS MY COMPLAINS AND WANTS THIS ISSUE TO "HAPPEN MORE FREQUENTLY BEFORE TAKING ACTION". SUDDEN STALLS ALMOST LEAD ME TO A TRAFFIC ACCIDENT ALREADY AT LEAST ONCE; THE DEALERSHIP ISN'T CONCERNED ABOUT TRAFFIC SAFETY. *NM

(1) NO WARNING PRIOR TO FAILURE (2) THE ENGINE SUDDENLY STALLED, LEADING TO INSTANT LOSS OF POWER / SPEED. THE VERY FIRST TIME IT HAPPENED TO ME WAS 2.5 YRS AGO(JULY, 2003) THE DAY AFTER I BOUGHT THE CAR AT 62 K MILES. THE ENGINE STALLED WHEN I WAS DRIVING @40-50 MILES/HR FOR 6 MILES. THE CAR WAS TOWED TO THE GARAGE AND A THROTTLE WAS REPLACED. THEN, AFTER 2.5 YEAR, WHEN THE MILEAGE REACHED 91K (LESS THAN 30K AFTER THROTTLE REPLACEMENT), THE SAME STALLING APPEARED AGAIN. THE FIRST TIME IT HAPPENED WAS AROUND 12/10, WHEN I PARKED THE CAR. THE SECOND TIME WAS ON 12/18, WHEN I PULLED OVER TO A TRAFFIC LIGHT THE THIRD TIME WAS ON 12/19, AGAIN WHEN I APPROACHED PARKING LOT, TO TAKE IT TO THE VOLVO SERVICE. (3) IN THE FIRST DAY AT VOLVO DEALER SERVICE (@ 96TH ST., INDIANAPOLIS) COULD NOT DIAGNOSE THE...

SERVICE ENGINE LIGHT - URGENT WENT ON. I NOTICED SLIGHT HESITATION IN CAR ONLY WHEN THIS LIGHT IS ON. SERVICE LIGHT COMES ON & OFF. WENT TO DEALER AND INFORMED THAT I NEED A NEW THROTTLE BODY UNIT AT A COST OF $1129.95. CAR ONLY HAS 73,000 MILES AND IS REGULARLY SERVICED BY VOLVO. INFORMED THAT THIS IS NOT UNDER WARRANTY. WENT ON LINE TO NHTSA AND DISCOVERED MANY COMPLAINTS REGARDING SIMILAR PROBLEM. *NM

VOLVO 2000 S80 T6 - 61000 MILES "VENT BOX SEALS LEAKING OIL".*AK

THE CHECK ENGINE LIGHT CONTINUE TO COME ON WITH A MESSAGE EMMISION SYUSTEM REQUIRE INSPECTION .VOLVO GWINNETT PLACE HAD SUPPOSEDLY REPAIRED IT AT LEAST THREE TIMES WITH THE LATEST BEING OCTOBER 2. ONLY TO HAVE THE LIGHT COME ON AGAIN OCTOBER 3. WE WILL RETURN THE CAR ON OCTOBER 5TH. MR

CONSUMER STATES WHILE DRIVING 60 MPH THE ENGINE SHUT CAUSING LOST OF POWER STEERING. MR

WHILE DRIVING AT APPROXIMATELY 40 MPH ENGINE COMPLETELY SHUTDOWN WITHOUT WARNING, VEHICLE VERY DIFFICULT TO CONTROL WITH NO POWER TO MANEUVER OUT OF TRAFFIC.*AK

CAR HAS HAS MANY RETURNS TO DEALER IN FIRST 20,000 MILES FOR MECHANICAL PROBLEMS. NO SAFETY DEFECT LISTED. *AK

ENGINE AND CAR COMPLETELY SHUT DOWN ON 2 OCCASIONS (4/13/01 AND 7/27/01). MASS AIR FLOW SENSOR REPLACED INITIAL INSTANCE AND SOFTWARE UPDAED. IGNITION ND FUEL INJECTION FAULT TRACING. UNABLE TO ISOLATE CAUSE SECOND INSTANCE. INTERMITTENT COMMUNICATION FAULT AT ELECTRONIC THROTTLE MODULE. UNABLE TO DUPLICATE PROBLEM. REFUSE PICK-UP OF THE CAR AT ROYAL VOLVO SINCE VERY CONCERNED ABOUT SAFETY ISSUES. HAVE NOTIFIED VOLVO CUSTOMER SERVICES TWICE, VOLVO DEALERSHIP, NHTSA, OFFICE OF ATTORNEY GENERAL. THOROUGH LETTER BEING SENT TO NHTSA, CENTER FOR AUTO SAFETY, AND OFFICE OF ATTORNEY GENERAL ON 8/6/01. PLEASE THOROUGHLY REVIEW THE CONTENT. MAJOR CONCERNS----HAVE FOUND AT LEAST 6 OTHER INSTANCES OF THE SAME PROBLEM. WILL SEND ALL DOCUMENTATION IN THE EXPRESS LETTER BEING SENT. CALL IF ANY QUESTIONS AND LEAVE AN 800 NUMBER FOR RESPONSES. URGE YOU TO PLEASE TAKE NOTE....THIS ISSUE IS BROADER THAN MY OWN.*AK