1999 VOLVO S70 Engine And Engine Cooling Problems

TWICE, WITHIN 50 METRES OF THE SAME SPOT EACH TIME, MY CAR HAS SUFFERED EXTREME ACCELERATION WHILST I WAS BRAKING AS HARD AS I COULD. FIRST TIME, MY MECHANIC CHECKED ALL COMPUTER DIAGNOSTICS USING TWO DIFFERENT COMPUTER TESTING DEVICES BUT THERE WERE NO FAULT CODES. NOW, AS WELL AS HAPPENING TWICE WITHIN 50 METRES OF THE SAME SPOT, I WAS AT THE SAME SET OF TRAFFIC LIGHTS, WHICH I DO NOT SUSPECT AS BEING THE PROBLEM, BUT ALSO NEXT TO A MAJOR HOSPITAL WITH AN ADJACENT HELIPAD. MY BEST GUESS AFTER 57 YEARS IN ELECTRONICS AND 40+ IN COMPUTERS IS THAT SOME SORT OF RF INTERFERENCE IS UPSETTING MY VEHICLE. I KNOW VOLVO CHECK ALL ACCIDENTS INVOLVING THEIR CARS IN SWEDEN AND WONDER WHETHER THEY HAVE EVER COME ACROSS MY PROBLEM. BOTH TIMES THE ENGINE SCREAMED ITS HEAD OFF ALTHOUGH I HAD NO TIME TO WORRY ABOUT THE TACHOMETER READING....

TL* THE CONTACT OWNS A 1999 VOLVO S70. WHILE TRAVELING 45 MPH, THE CONTACT NOTICED THAT THE ETS WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE COMPUTER SOFTWARE NEEDED TO BE UPGRADED. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE CURRENT AND THE FAILURE MILEAGES WERE 133,000. UPDATED 04/11/12 *BF THE CONSUMER STATED THE CAMSHAFT SEAL, IDLER PULLEY, TENSIONER AND WATER PUMP NEEDED TO BE REPLACED.

TL* THE CONTACT OWNS A 1999 VOLVO S70. THE CONTACT STATED THAT HE HEARD A LOUD KNOCKING COMING FROM THE ENGINE UPON STARTING THE VEHICLE. THE CONTACT BEGAN TO DRIVE, BUT THE VEHICLE WOULD NOT ACCELERATE BEYOND 25 MPH. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 101,000. THE VIN WAS UNAVAILABLE.

TL*THE CONTACT OWNS A 1999 VOLVO S70. THE CONTACT STATED THE VEHICLE WOULD INTERMITTENTLY STALL WHILE DRIVING AT VARIOUS SPEEDS. UPON RESTART THE VEHICLE WOULD OPERATE AS NORMAL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON NUMEROUS OCCASIONS; HOWEVER, THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THE VEHICLE WAS TAKEN TO VARIOUS AUTHORIZED DEALERS APPROXIMATELY SIXTEEN TIMES FOR THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 90,263.

1999 VOLVO S70. CONSUMER STATES MECHANICAL PROBLEMS *TGW THE CONSUMER STATED THE VEHICLE WOULD SUDDENLY STALL WITH NO WARNING, USUALLY IN RUSH HOUR TRAFFIC. THE CONSUMER WAS ABLE TO RESTART THE VEHICLE, BUT OFTEN IT WOULD GO NO MORE THAN 20-30 MPH. ALSO, SOME OF THE LIGHTS ON THE DASH WOULD COME ON AND GO OFF. THE CONSUMER HAS TAKEN THE VEHICLE TO THE DEALER AT LEAST SIXTEEN TIMES. *JB UPDATED 10/28/10. *JB THE VEHICLE WOULD HESITATE UPON ACCELERATION. UPDATED 11/12/10*JB

1999 VOLVO S70 ETS LIGHT CAME ON AND CAR STALLS . CAR IS BUCKING AND SPEEDING UP CAR SHUTS DOWN ALL OVER THE ROAD AND HIGHWAYS AND WILL NOT START. *TR

ONGOING PROBLEMS SINCE AUGUST 2008: ENGINE STALLS, DECELERATES, WON'T START, SOMETIMES ENGINE SURGES BADLY, ENGINE LIGHTS GO ON, THROTTLE GETS DIRTY EVEN WITH NEW PART ETM PROBLEMS ARE OCCURRING AND NOW VEHICLE WILL NOT START OR DRIVE AT ALL. *TR

TL*THE CONTACT OWNS A 1999 VOLVO S70. IN 2001, THE SPEEDOMETER FAILED AND DISPLAYED ZERO WHEN THE VEHICLE WAS TRAVELING 10 MPH. EVENTUALLY, THE VEHICLE BEGAN TO SHUT OFF IN TRAFFIC AND WHILE DRIVING BETWEEN 60-65 MPH. THE DEALER REPLACED THE SENSORS SEVERAL TIMES. THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP AND THE SENSORS WERE REPLACED AGAIN. SHE WAS UNSURE ABOUT THE NAME OF THE SENSOR; HOWEVER, THE FAILURES CONTINUED AND THE VEHICLE WAS UNABLE TO BE RESTARTED. RECENTLY, IN JUNE OF 2009, THE VEHICLE SHUT OFF AND WAS TOWED TO THE DEALER. THEY STATED THAT THE ELECTRONIC THROTTLE MODULE FAILED AND THE BATTERY CABLE WAS CORRODED. THE REPAIR COST WAS ESTIMATED AT $1,021. THE FAILURE MILEAGE WAS 79,842 AND CURRENT MILEAGE WAS 189,000.

AT APPROXIMATELY 206,000 MILES MY CAR WOULDN'T DRIVE OVER 40 MPH, THE ENGINE WOULD REV UP ON ITS OWN AND SPUTTERED THROUGHOUT THE REDUCED RPM RANGE. RPMS WOULD NOT GO OVER ABOUT 3500. CHECK ENGINE LIGHT CAME ON. DROVE IT TO VOLVO DEALER AND THEY REPLACED THE THROTTLE BODY AT AN OUT OF POCKET COST TO ME OF APPROXIMATELY $1,000. THEY STATED THAT IT WOULD HAVE BEEN COVERED UP TO 200,000 MILES AS THIS PART HAD A RECALL. I DO NOT FEEL THAT I WAS ADEQUATELY NOTIFIED OF THE RECALL. I RECEIVED A LETTER ABOUT A RECALL LAST YEAR AND CALLED THE DEALER TO ASK WHAT IT ALL MEANT SINCE I DID NOT UNDERSTAND IT. THE DEALER SAID IT WAS JUST A SOFTWARE UPGRADE AND WOULD ONLY TAKE ABOUT FIVE MINUTES. I TOOK THE VEHICLE IN FOR THAT SOFTWARE UPGRADE IN MARCH OF 2007 WITH LESS THAN 200,000 MILES ON...

TL*THE CONTACT OWNS A 1999 VOLVO S70. WHILE DRIVING 55 MPH, THE VEHICLE LOST POWER AND STALLED, BUT NEVER COMPLETELY SHUT OFF. THE FAILURE OCCURS DURING ACCELERATION AND WHEN STARTING THE VEHICLE. NO OTHER SYSTEMS OF THE VEHICLE WERE AFFECTED AND NO WARNING LIGHTS ILLUMINATED. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF FAILURE. THE VIN AND DEALER INFORMATION WERE UNAVAILABLE. THE CURRENT MILEAGE WAS 104,736 AND FAILURE MILEAGE WAS 104,000.

1999 VOLVO S70'S ETM (THROTTLE) HAD ACTED UP IN JUNE/JULY 2004, PAID AROUND $900 IN JULY 2004 TO HAVE IT FIXED. THE THROTTLE CAUSED THE CAR TO GO DEAD MULTIPLE TIMES & STRONGLY REV ITSELF OCCASIONALLY. THIS WOULD OCCUR WHEN SLOWING DOWN OR WHEN STOPPED. I WOULD OCCASIONALLY HAVE TO KEEP FOOT ON THE GAS TO KEEP THE CAR FROM GOING DEAD. ***NOW LESS THAN A YEAR AND A HALF AFTER HAVING THE PROBLEM "FIXED" (REPLACED UNIT) - THE PROBLEM IS BACK. THE CAR HAS GONE BACK TO SAME ISSUES. THIS PROBLEM DOES NOT OCCUR SLOWLY, FROM GOOD PERFORMANCE TO BAD, IT TOOK ONLY ONE WEEK FOR IT TO RECCUR. *JB

DT: THE CONTACT STATED THAT 1999 VOLVO S70 EXPERIENCED THE SAME PROBLEM WITH STALLING WHILE DRIVING UNDER 40 MPH. THE ENGINE LIGHT WAS COMING ON AND THE CAR WAS UNCONTROLLABLE. THE CAR WOULD SHAKE AND JERK, SPEED AHEAD AND SLOW DOWN. T THE CONTACT TOOK VEHICLE TO THE DEALERSHIP AND THEY REPLACED THE FUEL THROTTLE BODY, PUT IN NEW SPARK PLUGS, AND REPROGRAMMED THE COMPUTER. THE CAR HAS SINCE THEN RAN WELL. THE CONTACT STATED THAT THIS HAPPENED A YEAR AGO. THE REPAIR COST FOR THE CONTACT WAS ALMOST $1,000.00. THE CONTACT HAS BEEN IN TOUCH WITH VOLVO DEALERSHIP, AND THEY TOLD HIM THAT THEY HAVE NOT HEARD ANYTHING ABOUT RECALL. THE VOLVO MANUFACTURER SAID THAT THERE WAS AN INVESTIGATION ON THE CAR, AND TO CALL THE NHTSA. THE CONTACT HAS ALSO FILED A COMPLAINT WITH VOLVO.*AK

THE ENGINE THROTTLE CONTROL LIGHT ACTIVATED SPORADICALLY BEGINNING IN JULY, 2005. I NOTICED THAT THE CAR WAS NOT PERFORMING ADEQUATELY WHEN GOING UPHILL OR IN SEVERE HEAT. MY HUSBAND CONTACTED THE VOLVO DEALERSHIP IN ALLENTOWN, PA WHERE WE PURCHASED THE VEHICLE. HE WAS TOLD THAT THE COST TO REPAIR SAME WOULD BE OVER $800. WE DECIDED TO PASS ON THIS REPAIR DUE TO THE COST AND THOUGHT THAT ANOTHER AUTO SERVICE MECHANIC COULD PERFORM THE REPAIRS AT A LESSER PRICE. APPROXIMATELY 3 WEEKS LATER, THE ETS LIGHT WAS ACTIVATED ON EVERY OCCASION THAT THE VEHICLE WAS USED. SINCE A SECOND MECHANIC (NOT AFFILIATED WITH VOLVO) STATED THAT HE WAS UNABLE TO DO THE REPAIRS, WE DECIDED TO CONTACT ANOTHER VOVLO DEALERSHIP. THE REPAIR OF THE THROTTLE BODY AND ETM "RELOAD" WAS PERFORMED BY A VOLVO OF FORT WASHTINGTON, PA AT A COST OF OVER $800 ON AUGUST 17, 2005. AFTER...

BEGINNING IN APRIL OF 2005, THE ENGINE ON MY 1999 VOLVO S70 HAD STALLED SEVERAL TIMES. IN EACH INSTANCE, IT HAS RESTARTED AND OPERATED, HOWEVER, THE STALLS ARE BECOMING MORE FREQUENT. I HAVE READ OR THE NHTSA'S INVESTIGATION INTO THIS PROBLEM, AND AM CONCERNED ABOUT MY VEHICLE'S OPERATION AND REPAIR COSTS.*JB

WARNING LIGHT, ENGINE RAN ROUGH, STALLED SINCE APRIL 2004 UNTIL JANUARY 2005, AND DEALER REPEATEDLY RAN TESTS AND CHARGED ME HUNDREDS OF DOLLARS FOR TESTS AND REPLACING PARTS THAT DID NOT FIX THE PROBLEM UNTIL JANUARY 2005. *NM

IN THE LAST MONTH OUR 1999 S70 VOLVO HAS STALLED - ONCE WHEN TRAVELING AT SLOW SPEED AND THE OTHER ACCELERATING FROM A STOP LIGHT. IN BOTH INSTANCES THE CAR COULD BE RESTARTED. ALSO, THE "CHECK ENGINE" INDICATOR ILLUMINATES FREQUENTLY - AS IT IS NOW - AND WHEN TAKEN TO THE DEALER WE ARE ADVISED THEY CAN NOT FIND ANYTHING WRONG. *JB

CONSUMER STATED THAT WHILE DRIVING AND WITHOUT WARNING THE VEHICLE WILL SURGE FORWARD CAUSING A DISTRACTION TO THE CONSUMER. DEALER NOTIFIED. TS