2002 VOLVO S60 Engine And Engine Cooling Problems

WHILE DRIVING IN THE DARK, POWER TO THE ELECTRONICS LISTED BELOW WERE LOST INEVITABLY AND MANY WARNING LIGHTS/MESSAGES APPEARED ON THE DASH (ALSO LISTED BELOW UNDER SYMPTOMS). THERE WERE NO WARNING SIGNS THAT THIS WAS ABOUT TO HAPPEN NOR IS THERE ANY EXPLANATION FOR WHY IT HAPPENED. I WAS DRIVING ON A DARK ROAD AND I LOST COMPLETE VISION OF THE ROAD DUE TO HEADLIGHT FAILURE (BOTH LOW AND HIGH BEAMS). THIS SCENARIO IS A COMMON SAFETY ISSUE ASSOCIATED WITH MANY OTHER SIMILAR VOLVO YEARS AND MODELS. I HAD TO STOP THE CAR IMMEDIATELY TO AVOID CRASHING AND CALL SOMEONE TO PICK ME UP. ALL SYMPTOMS FROM THIS "BLACKOUT" DID NOT AND HAVE NOT DISAPPEARED SINCE IT HAPPENED, MAKING THE CAR UNDRIVABLE. THESE SYMPTOMS ARE SUSPECT TO BE THE RESULT OF A CEM FAILURE, WHICH ALSO CONTROLS EMISSIONS. AS STATED PREVIOUSLY, THIS EXACT SCENARIO HAS CAUSED THOUSANDS OF SIMILAR VOLVO...

TL* THE CONTACT OWNS A 2002 VOLVO S60 2.4. THE CONTACT WAS DRIVING 70 MPH WHEN A LOUD EXPLOSION EMITTED FROM UNDER THE HOOD AND SMOKE ENTERED THE INTERIOR. THE VEHICLE THEN STALLED AND WAS TOWED TO AN AUTHORIZED DEALER. THE DEALER STATED THAT OIL WAS NOT FLOWING INTO THE ENGINE AND THE BEARINGS WERE MELTED. THE MANUFACTURER WAS NOT NOTIFIED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 49,000.

TL* THE CONTACT OWNS A 2002 VOLVO S60. WHILE DRIVING APPROXIMATELY 20 MPH, THE CONTACT APPLIED PRESSURE TO THE ACCELERATOR PEDAL BUT THE VEHICLE WOULD NOT ACCELERATE. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED ON THE DASH BOARD AS THE VEHICLE INDEPENDENTLY ACCELERATED AND THEN DECELERATED. THE CONTACT DID NOT FEEL SAFE OPERATING THE VEHICLE AND IT WAS PARKED. THE DEALER WAS CONTACTED AND STATED THAT THERE WAS AN EXTENDED WARRANTY OFFERED FOR THE ETM UNIT IN THE SAME YEAR, MAKE AND MODEL AS THE CONTACTS VEHICLE BUT THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 156,000.

I OWN A VOLVO S60 AND AM HAVING PROBLEMS (RACING IDLE, UNCONTROLLABLE CRUISE CONTROL, AND COMPLETE DYING OF ENGINE RANDOMLY) WHICH ARE RELATED TO EVENTUAL FAILURE OF THE ETM WHICH COULD BE A CATASTROPHIC EVENT, RESULTING IN SERIOUS INJURY OR DEATH. VOLVO HAS ISSUED A LIMITED RECALL BUT IN ORDER TO BE GRANTED THIS FIX ONE'S VEHICLE MUST FAIL A CERTAIN TEST. IF THERE IS NO FAILURE, NO FIX.(THE TEST IS NOT A COMPREHENSIVE METER OF FAILURE) A SOFTWARE UPGRADE IS OFFERED WHICH IS ESSENTIALLY AN OVERRIDE , IN WHICH THE SYSTEM IS SET TO IGNORE SYMPTOMS, SO THAT THE CHECK ENGINE LIGHT DOES NOT EMPLOY. THIS IS NOT A FIX.. THE PROBLEM EXISTING IS THAT MY CAR EXHIBITS ALL THE PRELIMINARY PROBLEMS OF THE EVENTUAL FAILURE OF THE ETM WHICH WILL RESULT IN A LIMP HOME MODE ,WHEREAS THE CAR WILL ONLY GO APPROX 15MPH, AND IS IMMEDIATE, MEANING...

TL*THE CONTACT OWNS A 2002 VOLVO S60. WHILE DRIVING APPROXIMATELY 35 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE INDICATOR REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY STATED THAT THE FAILURE WAS RELATED TO THE THROTTLE BODY. THE VEHICLE WAS REPAIRED. THE FAILURES WERE RELATED TO RECALL#07V152000, FUEL SYSTEM; HOWEVER, HER VIN WAS EXCLUDED. THE FAILURE AND CURRENT MILEAGES WERE 102,000.

I WAS DRIVING ON THE FREEWAY AND WITHOUT WARNING THE ENGINE LOST POWER AND THE CHECK ENGINE LIGHT CAME ON. I COASTED OFF TO THE SHOULDER AND THE ENGINE WOULD ONLY IDLE, AND EVEN THAT WAS ROUGH. THE MESSAGE INDICATOR ON THE DASH SAID SOMETHING LIKE "REDUCED ENGINE PERFORMANCE". I HAD THE CAR TOWED TO GENGRAS VOLVO IN MERIDEN. THEY REPLACED THE ETM , SOFTWARE AND THROTTLE BODY AT THE COST OF $1195.43. ABOUT TWO WEEKS LATER, I WAS DRIVING ON THE FREEWAY AND THE SAME THING HAPPENED. THIS TIME THE DEALERSHIP SAID THE ELECTRICAL CONNECTIONS TO THE ETM MUST BE BAD AND REPLACED SAME AT NO COST TO ME. NOW ABOUT 10 DAYS AFTER THAT REPAIR, THE SAME THING HAPPENED TO ME ON THE FREEWAY AGAIN. SINCE IT IS THE WEEKEND, I HAVE TO WAIT UNTIL MONDAY FOR THE DEALER TO GIVE ME THE DIAGNOSIS THIS TIME. SINCE THE...

TL*THE CONTACT OWNS A 2002 VOLVO S60. THE VEHICLE UNNECESSARILY GOES INTO UNEVEN ENGINE IDLING WHEN DRIVING BETWEEN 10-30 MPH. THE FAILURE PREVENTS THE BRAKES FROM WORKING PROPERLY. WHEN DEPRESSING THE BRAKE PEDAL, THE VEHICLE WOULD CONTINUE TO ROLL INSTEAD OF STOPPING. WHEN THE CONTACT TOOK THE VEHICLE TO THE DEALER, THEY REPLACED THE THROTTLE, INSTALLED A NEW ECM, AND REPLACED THE MASS AIR FLOW PIPE. THE CURRENT MILEAGE WAS 63,600 AND FAILURE MILEAGE WAS 59,554. UPDATED 12-12-07. *KB THERE WAS A MASS AIR FLOW FAILURE. UPDATED

SEP 29,2006 MY WIFE WAS DRIVING HOME AND THE CAR SHUT OFF AS SHE WAS MAKING A TURN. SHE ALSO NOTED THE SIGNAL LIGHTS AND DASH LIGHTS WERE ACTING ERRATICALLY. COME MONDAY WE ARE SCHEDULING A VISIT TO THE DEALERSHIP. THIS APPEARS TO BE A SAFETY ISSUE THE REASON BEING SUPPOSE SHE HAD BEEN IN HIGHWAY TRAFFIC. *JB