1997 VOLVO 850 — Problems, Recalls & Safety Data

SIMILAR TO NHTSA ID NUMBER: 10365806. WHEN FUEL TANK IS FILLED COMPLETELY, THERE IS A STRONG ODOR OF FUEL OUTSIDE THE VEHICLE AND SOME FUEL ODOR IN THE TRUNK. NO ODOR WHEN TANK IS ONLY PARTIALLY FULL, E.G., 80% FULL. ODOR NOTICED WHEN VEHICLE STATIONARY. NO ODOR IN PASSENGER COMPARTMENT. ISSUE ONGOING FOR ROUGHLY LAST 7 YEARS (NOT SURE). NO DRIPPING FUEL OBSERVED. LEAK MAY BE AT FUEL PUMP QUICK-DISCONNECT FITTINGS. LEAK MAY HAVE STARTED AS A RESULT OF EVAP SYSTEM REPAIR IN LATE 2009--NOT SURE. DEALER CLAIMED TO HAVE FIXED LEAK AT FUEL PUMP FITTINGS IN 2011, BUT ODOR ISSUE PERSISTS IF TANK COMPLETELY FULL. NO CHECK ENGINE LIGHT ISSUES SINCE 2011. I AVOID FILLING TANK COMPLETELY TO AVOID ODOR. IF I INADVERTENTLY FILL TANK COMPLETELY, ODOR RETURNS. "WHEN DID THIS HAPPEN" DATE I ENTERED IS JUST A ROUGH GUESS OF WHEN THE ISSUE STARTED. VEHICLE IS STORED OUTDOORS AND DRIVEN INFREQUENTLY, ~ ONCE PER WEEK AVERAGE. ODOR IS EASILY NOTICEABLE OUTDOORS WHEN TANK IS COMPLETELY FULL.

GENERAL ALTIMAX RT43. I HAD 4 TIRES IN LESS THAN 6 MONTHS AND 6,000 MILES DEVELOP SIDE WALL BUBBLES CAUSED BY TIRE PLAY SEPARATION AND BANDS BREAKING. I TIRE HADE BEEN REPLACED AND IT DEVELOPED A BUBBLE IN LESS THAN A MONTH. NO HARD DRIVING ON THE CAR AND NO POTHOLES OR RAILROAD TRACK IMPACTS. THIS IS A COMMON THREAD AND IT IS TIME FOR THE NHTSA TO INVESTIGATE. I HAVE NOW BOUGHT SIX TIRES IN SIX MONTHS TO REPLACE THE DAMAGED TIRES. I AM STILL WAITING TO HERE IF GENERAL WILL REPLACE ONE UNDER WARRANTY AND HAVE ANOTHER IN THE TRUNK OF MY CAR THAT NEEDS TO BE REPLACED WHILE I DRIVE AROUND ON THE SPARE TIRE. THIS SHOULD NOT HAPPEN UNDER NORMAL USE. PRIOR TO THIS I HAVE DRIVEN APPROXIMATELY 1MILLION MILES AND HAVE NEVER HAD TO REPLACE A TIRE DUE TO SIDE WALL BUBBLES.

THE TIRE DEALER RECOMMENDED MICHELIN PRIMACY MXV4 AS A REPLACEMENT TIRE FOR MY 1997 VOLVO 850 (NORMALLY ASPIRATED) SEDAN. THE MICHELIN WEBSITE DESCRIBED THIS TIRE AS AN "ACCEPTABLE SUBSTITUTE" FOR THE TIRES SPECIFIED BY VOLVO BECAUSE MICHELIN NO LONGER OFFERS HIGH PERFORMANCE TIRES IN MY SIZE. STOPPING POWER IS MUCH WORSE WITH THESE NEW MICHELIN TIRES. THEY SQUEAL EASILY, EVEN AT VOLVO'S HIGHEST RECOMMENDED AIR PRESSURE (36PSI). I HAD DIFFICULTY STOPPING FROM 50MPH IN AN EMERGENCY, FOR THE FIRST TIME IN MY 17 YEAR OWNERSHIP OF THIS VEHICLE. I BLAME THESE NEW "COMFORT ORIENTED" TIRES. *TR

TL* THE CONTACT OWNS A 1997 VOLVO 850. THE CONTACT STATED WHEN FUEL WAS DISPENSED INTO THE FUEL TANK TO THE FULL CAPACITY LEVEL, SHE WOULD SMELL A STRONG ODOR OF FUEL INSIDE AND OUTSIDE OF THE VEHICLE. IN ADDITION, THERE WOULD BE FUEL LEAKAGE ON THE GROUND UNDERNEATH THE FUEL TANK. THE FUEL WAS DISPENSED TO THREE QUARTERS OF A TANK TO AVOID THE FAILURE. THERE WAS A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 04V368000 (FUEL SYSTEM, GASOLINE:STORAGE). THE VIN WAS NOT INCLUDED IN THE RECALL DEFECT. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000.

UNINTENDED ACCELERATION. CAR IN NORMAL DRIVE, JUST STARTS TO ACCELERATE. ALSO SOMETIMES ENGINE RACES WHILE IN PARK OR IDLE FOR NO REASON. OCCURS RANDOMLY, BUT HAS BEEN RECURRING DAILY FOR TWO WEEKS. HAVEN'T TAKEN TO DEALER YET. *TR