1994 VOLVO 850 — Problems, Recalls & Safety Data

I HAVE A 1994 VOLVO 850. I HAVE A LEAK WHERE THE HEAT SHIELD IS ATTACHED TO THE GAS TANK. VOLVO IS WELL AWARE OF THIS PROBLEM BUT MY VIN DOES NOT SHOW THE RECALL. THE LEAK OF GAS IS 100% FROM THE RECALLED SPOT HEATSHIELD SIDE OF THE GAS TANK. THIS IS A SAFETY ISSUE BECAUSE IT COULD BLOW BACK ON THE EXHAUST AND CAUSE A FIRE.

WE SMELL GAS. WHEN STOP NOTICE FUEL LEAKING FROM FUEL ENTRY PIPE. WHEN GOT CLOSER LOOK IT WAS LEAKING FROM FUEL ENTRY PIPE THAT CONNECTED TO FUEL TANK. *TR

THE CONSOLE AND STEERING WHEEL WERE WET FROM RAIN. THE SRS DASH WARNING LIGHT CAME ON. ABOUT 5 MILES AFTER THAT, THE DRIVER'S SIDE AIR BAG DEPLOYED. THE BAG WAS THE ORIGINAL BAG. THE SRS LIGHT HAD GONE ON ONCE 20 MONTHS BEFORE WHEN THE CONSOLE GOT WET. THE DEALERSHIP RAN A TEST FOR ABOUT $115 EACH ON BOTH OCCASIONS AND SAID THE CAUSE OF THE SRS LIGHT COMING ON WAS INDETERMINATE. TWENTY MONTHS AGO A TOP, LONGTIME VOLVO DEALERSHIP SERVICE MANAGER ASSURED ME THAT AIR BAGS NEVER GO OFF WITHOUT AN IMPACT. HE SAID THERE HAD NOT BEEN A SINGLE OCCASION OF THAT EVER HAPPENING. I SHOULD HAVE GOOGLED THE TOPIC. I WOULD HAVE SEEN RIGHT AWAY THAT HE DIDN'T KNOW WHAT HE WAS TALKING ABOUT. TWO BONES IN MY FOREARM WERE BROKEN AND HEAVY BRUISES THAT ARE STILL VISIBLE 5 WEEKS LATER WERE LEFT ON MY STOMACH AND THIGHS. CORPORATE OFFICES AND THE DEALERSHIP SAY THE BAG WAS OUT OF WARRANTY; A REPLACEMENT STEERING WHEEL TO INSTALL A NEW BAG IS NOT AVAILABLE; AND THAT THEY WILL NOT DISCONNECT THE PASSENGER BAG, THOUGH I CONSIDER IT A TIME BOMB. BEFORE WRITING AN EMAIL ATTEMPTING TO PLACE THE BLAME ON ME, ERICA AT "THE EXECUTIVE OFFICES OF VOLVO" LEFT AN APPARENTLY INANE VOICE MAIL THAT I HAVE SAVED FOR NOW SAYING "THIS IS NOT EXACTLY A SPONTANEOUS DEPLOYMENT. WE DO KNOW WHY THE BAG DEPLOYED IN YOUR VEHICLE." I EMAILED BACK THAT HER CLAIM THAT "WE" KNOW WHAT CAUSED THE BAG TO DEPLOY "STRUCK ME AS ODD BECAUSE NO ONE AT THE VOLVO [DEALERSHIP] THIS PAST WEEK SAID THAT THEY KNEW." EVEN AFTER RUNNING A CHECK ON THE SRS SYSTEM, AND CHARGING ME $115 TO DO SO, THEY STILL SAID THEY DID NOT KNOW. IN FACT A FEW WEEKS AGO TWO LONG TIME SERVICE MANAGERS WERE SAYING MY EXPERIENCE WAS UNPRECEDENTED OR IMPOSSIBLE. I SUGGESTED IN ANOTHER EMAIL TO ERICA THAT THE CORPORATION HAD A MORAL OBLIGATION TO INFORM THEIR SERVICE MANAGERS OF DOCUMENTED CASES OF SPONTANEOUS DEPLOYMENT. *TR

TL* THE CONTACT OWNS A 1994 VOLVO 850 TURBO. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, FUEL LEAKED FROM UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER STATED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED AND THEY STATED THAT THE REMEDY FOR THE RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 04V368000 (FUEL SYSTEM, GASOLINE:STORAGE) WAS PERFORMED SEVEN YEARS AGO. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 52,000.

TL* THE CONTACT OWNS A 1994 VOLVO 850. THE CONTACT STATED THAT THE RADIATOR FOR THE HEATING CORE WAS LEAKING AND EMITTING CHEMICAL FUMES INTO THE VEHICLE. AS A RESULT, THE CONTACT SUFFERED A SEVERE RESPIRATORY PROBLEM. THE CONTACT WAS TAKEN TO THE HOSPITAL ON VARIOUS OCCASIONS FOR TREATMENT. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.