2006 VOLKSWAGEN PASSAT Engine And Engine Cooling Problems

DRIVING 65 ON THE FREEWAY IN HEAVY RAIN, CAR MADE HORRIBLE SOUND AND LOST ACCELERATION POWER. ALMOST INVOLVED IN ACCIDENT , HOWEVER MANAGED TO PULL TO SHOULDER WHEN THE CAR THEN FILLED WITH A GAS SMELL. CALLED FOR ASSISTANCE AND WAS TOWED 100 MILES BACK TO MY MECHANIC. UPON INSPECTION, MECHANIC DISCOVERED THAT THE CATALYTIC CONVERTER DISCONNECTED AT THE TURBO FLANGE. HE ALSO STATED THAT HE HAD FIXED THE EXACT SAME PROBLEM IN MY EXACT VEHICLE MAKE/MODEL THE WEEK PRIOR. CONTACTED VW TO SEE IF THIS WAS COVERED UNDER THE 80K MILES EMISSIONS WARRANTY, ONLY TO DISCOVER THAT IN CALIFORNIA THE WARRANTY ONLY GOES TO 70K MILES. THE ENTIRE CATALYTIC CONVERTER WAS REPLACED TO THE TUNE OF $1,150. THE MECHANIC STATED THAT THE REPLACEMENT CATALYTIC CONVERTER FROM VW WAS MUCH MORE STURDY THAN THE ORIGINAL INSTALLED , INDICATING THAT VW IS AWARE OF THE ISSUE. ADDITIONALLY, HE STATED IT WAS...

THE CATALYTIC CONVERTER SEPARATED FROM THE FLANGE CONNECTING IT TO THE TURBOCHARGER. SEEMS COMMON FROM WHAT IS SEE ON THE INTERNET, BUT NO RECALL HAS BEEN DONE. *TR

OIL PUMP BOLT BACKED OUT/BROKE CAUSING ENGINE DAMAGE. CAR LOSS OIL PRESSURE FORTUNATELY WAS NEAR AN EXIT TO AVOID THE ENGINE COMPLETELY STOPPING IN THE MIDDLE OF THE HIGHWAY GETTING INVOLVED IN A POTENTIAL DANGEROUS WRECK. DEALER SAYS IT WILL COST $11,000.00 TO REPLACE ENGINE. VW KNOWS THIS IS AN ISSUE BUT WILL NOT TAKE ANY RESPONSIBILITY. THEY WOULD NOT DO ANYTHING SEEING I AM OUTSIDE THE WARRANTY AND STATED WOULD NOT DO A THING BECAUSE I AM THE SECOND OWNER. ONLY HAD THIS CAR FOR TWO YEARS AND BOUGHT IT AS A PRE-CERTIFIED OWNED USED VEHICLE FROM THE VW DEALERSHIP. I HAVE SEARCHED ON LINE AND MANY OTHER OWNERS HAVE HAD THIS ISSUE. LINK TO VIEW NUMEROUS ISSUE HTTP://FORUMS.VWVORTEX.COM/SHOWTHREAD.PHP?4321376-**OFFICIAL-24V-3.6L-ENGINE-(OIL-PUMP-BOLT)-FAILURE-THREAD**. ALSO ANOTHER LINK: HTTP://WWW.PASSATWORLD.COM/FORUMS/74-VOLKSWAGEN-PASSAT-B6-DISCUSSION/331097-OIL-PUMP-BOLT-FAILURE-74K-MILES.HTML THIS IS A SERIOUS ISSUE AND WE THE CONSUMERS A RE PAYING FOR IT. *JS

I BEGAN TO HAVE PROBLEMS WITH THE ENGINE LIGHT. EVERY TIME I HAD IT CHECKED, IT CODED SOMETHING DIFFERENT (PO455, PO171, PO441) WITH THESE RESULTS: FUEL CAP LIGHT CAME ON, HIGH PRESSURE FUEL PUMP, EVAPORATIVE EMISSION CONTROL SYSTEM , AND LEAN BANK 02 CENSOR BEFORE THE CATALYTIC CONVERTER. IT BECAME HARD TO CRANK, AND ONCE SHOOK WHEN IT DID CRANK. THE STEERING WHEEL MODULE AND COMFORT CONTROL MODULE WERE REPLACED IN 2008 UNDER WARRANTY AFTER I TOOK VOLKSWAGEN TO SMALL CLAIMS COURT. I TOOK THE CAR TO A DEALERSHIP IN ATLANTA (THERE ISN'T ONE CLOSE TO WHERE I LIVE) AND THEY COMPLETED THE FOLLOWING REPAIRS: CODE PO444, THE EVAPORATIVE EMISSION SYSTEM PURGE CONTROL VALVE CIRCUIT; CODE PO193, FUEL MEASURING SYSTEM 2 ABNK 1; AND P2187 SYSTEM TOO LEAN AT IDLE. TOTAL= $884.84 ($619.95 LABOR; $204.31 PARTS; $43.25 WASTE DISPOSAL CHARGE; AND $17.33 TAX). AT NO CHARGE, THEY CHECKED THE PASSENGER...

THE OIL PUMP BROKE AND DESTROYED THE MOTOR. I HAD TO BE TOWED TO THE DEALERSHIP; THEY TOOK A MONTH TO REPLACE PARTS AND REPAIR THE MOTOR. THERE HAVE BEEN A SIGNIFICANT NUMBER OF SUCH INCIDENTS; THIS HAS BEEN ADMITTED BY VW TO BE A MANUFACTURER PART FAULT, BUT THEY FAIL TO RECALL '06-'07 PASSATS AND COVER THE COSTS. I JUST SAW THIS SITE OR I WOULD HAVE REPORTED IT SOONER. I DID NOT OTHERWISE FIND ANY OTHER SUPPORT. *TT

DRIVING IN THE S CITY 45 MILES/P/H GIVING A WAY TO AMBULANCE I ACCELERATE THE CAR PULLING RIGHT LANE, CAR FELL ON HIS FACE NO POWER AMBULANCE ALMOST WAS GOING TO HIT ME SAME TIME EPC LIGHT CAME ON. VOLKSWAGEN OF AMERICA SHOULD BE RESPONSIBLE FOR THIS KIND LIFE THREATENING SITUATION. *TR

BOLT FAILURE IN CAM SYSTEM, COMMONLY KNOWN AS THE "OIL PUMP BOLT FAILURE". THE "CHECK ENGINE" & "EPC" LIGHTS CAME ON. THE ENGINE WENT INTO IT'S "SAFE" MODE, LIMITING ACCELERATION AND POWER. THE VEHICLE WAS UNDER WARRANTY & TAKEN TO THE DEALER. THE DEALER CONFIRMED THE BOLT FAILURE AND REPAIRS WERE MADE AND COVERED BY WARRANTY. THE REPAIRS TOOK APPROXIMATELY 1 MONTH TO MAKE. MAJOR COMPONENTS REPLACED WERE AS FOLLOWS: 2 - TIMING CHAINS OIL PUMP GEARS OIL PUMP BOLT TIMING CHAIN COVER TENSIONERS SOFTWARE UPDATE THE REPAIRS REQUIRED THE REMOVAL OF SOME MAJOR COMPONENTS, INCLUDING THE INTAKE MANIFOLD, VALVE COVER, TRANSMISSION AND SIDE COVERS. IN MY CASE, THE TIMING CHAIN COVER PREVENTED THE TIMING CHAIN SYSTEM FROM COMPLETELY FALLING APART. IF THIS HAD HAPPENED, IT WOULD HAVE BEEN COMPLETE DESTRUCTION OF THE INTERNAL COMPONENTS OF THE ENGINE REQUIRING COMPLETE REPLACEMENT OF THE ENGINE. MY VEHICLE WAS APPROXIMATELY 3 WEEKS...

IN AUGUST, MY CHECK ENGINE LIGHT HAD BEEN COMING ON AND OFF FOR ABOUT TWO WEEKS. I MADE AN APPOINTMENT AT THE DEALERSHIP. THEY FOUND SEVERAL FAULTS AND RECALLS (MY CAR ONLY HAD 39,000 MILES) AND TOLD ME THAT THE REPAIRS WOULD BE AROUND $800. I PAID THIS AMOUNT ONLY FOR THE LIGHT TO COME ON ABOUT A WEEK LATER. I CALLED THE DEALERSHIP TO MAKE ANOTHER APPOINTMENT BUT THE LIGHT WENT OFF AND STAYED OFF ABOUT A MONTH AND WAS TOLD TO TRY CHANGING OR TIGHTENING THE GAS CAP. I DID BOTH, HOWEVER, THE PROBLEM PERSISTED. THE LIGHT CAME ON AGAIN AND STAYED ON AND IN NOVEMBER, I BROUGHT THE CAR BACK. I WAS TOLD THERE WAS A PROBLEM WITH THE CAM SHAFT AND THAT THE CAR WAS NO LONGER SAFE TO DRIVE BECAUSE THE CAM SHAFT ATTACHED TO THE HIGH PERFORMANCE FUEL SHAFT WAS COMPLETELY WORN THROUGH. ADDITIONALLY,...

I NOTICED THAT I WAS RECEIVING NOTIFICATIONS TO CHANGE THE OIL MORE OFTEN PRIOR TO 3000 MILES. WHEN I WENT TO DEALERSHIP TO DETERMINE WHY I WAS TOLD THAT THE CAR SHOULD NOT REQUIRE AN OIL CHANGE USUALLY UNTIL 6000 MILES. I WAS TOTALLY BAFFLED BECAUSE I AM BARELY MAKING THE 3K MARK. SO, AFTER ANOTHER OIL CHANGE SHORTLY 3000 MILES...I GOT THE NOTIFICATION TO SHUT OFF ENGINE, OIL LEVEL TOO LOW. I PANICKED AND HAD THE CAR TOWED TO THE DEALERSHIP. THEY SAID IT WAS ALRIGHT AND SOME CAR ASORB MORE THAN OTHERS. A FEW WEEKS LATER, I RECEIVED NOTIFICATION OF A CHECK ENGINE LIGHT. THIS WAS SUPPOSEDLY THE CAM SHAFT. THIS WAS REPLACED IN FEB 2011. CONTINOUSLY I EXPERIENCED THE LOW OIL LEVEL AND HAVE HAD IT MONITORED. THE CHECK ENGINE LIGHT CAME ON THE NEXT DAY AFTER IT WAS MONITORED. THE DEALERSHIP IS UNABLE TO DETERMINE WHY...

I'VE ENCOUNTERED LOTS OF ISSUES WITH MY VEHICLE AND AM VERY TIRED OF TAKING IT TO THE SHOP LIKE IT IS AN OLD PIECE OF JUNK. THIS TIME I HAVE A NOISE WHICH IS COMING FROM THE UNDERHOOD. IT'S A CLICKING NOISE THAT IS VERY UNUSUAL. I TOOK IT TO THE SHOP BUT THEY WEREN'T ABLE TO IDENTIFY THE PROBLEM. AND I ALSO FOUND THAT I AM NOT THE ONLY ONE HAVING THAT NOISE, THERE ARE TONS OF PEOPLE WITH THE SAME EXACT PROBLEM THAT POSTED THEIR SAME PROBLEM ONLINE. THERE SHOULD BE A RECALL ON THIS. *TR

LOST MOST OF POWER WHILE DRIVING ON HIGHWAY. DROVE VEHICLE (2006 PASSAT 3.6L) TO VW DEALER WHERE THEY DIAGNOSED A "TIMING CHAIN ISSUE". VW DEALER CLAIMED THEY WOULD FIX ENGINE FOR $5000, USED REPLACEMENT FOR $8000, OR NEW ENGINE FOR $10,500... AFTER HEARING THAT GOOD NEWS, TOWED VEHICLE TO LOCAL VW PRO WHO ALSO DIAGNOSED "TIMING CHAIN ISSUE", AND WAS GIVEN THE GO-AHEAD TO FIX. PROBLEM ISOLATED TO INTERMEDIATE SHAFT BOLT, WHICH HAD BACKED OUT, ALLOWING TIMING SPROCKETS TO WANDER. BOLT ITSELF IS NEARLY SHEARED IN HALF - GOOD THING WE STOPPED WHEN WE DID. BOLT WAS ALSO RUBBING ON TIMING CHAIN COVER, AND WOULD HAVE LIKELY BROKE OR GROUND THRU TIMING CHAIN COVER. THIS PROBLEM WAS CORRECTED BY MY LOCAL VW GUY FOR $3300, WHICH INCLUDED ALL OEM PARTS, NEW WATER PUMP, PLUS PLUGS. IMHO, THIS IS A SERIOUS SAFETY ISSUE FOR OWNERS WHICH MAY EXPERIENCE THIS PROBLEM. MINIMAL...

I HAVE A 3.6 ENGINE AND THE OIL PUMP BOLT THAT HOLDS TIMING CHAIN AND CRANK CHAIN CAME LOOSE AND CAUSE MAJOR ENGINE PROBLEMS. DEALER SAYS I NEED TO REPLACE THE ENGINE AND IT'S GOING TO COST ME OVER $7000.00 DOLLARS FOR A USED ENGINE OR $16000.00 FOR A NEW ENGINE AND VW OF AMERICA WON'T TAKE ANY RESPONSIBILITY. *KB

VEHICLE STARTED MAKING A KNOCKING/RATTLING NOISE THAT MADE THE ENGINE SOUND LIKE IT WAS A DIESEL. THE ENGINE IN THIS CAR IS A 3.6 V6 GASOLINE ENGINE. I BROUGHT IT INTO MY MECHANIC AS SOON AS POSSIBLE AND HE ADVISED AGAINST DRIVING IT ANY MORE AS IT SOUNDED LIKE THE TIMING CHAIN WAS LOOSE. AFTER ATTEMPTING TO GET AT THE NOISE FROM UNDER THE HOOD HE FOUND OUT HE HAD TO GET UNDER THE COVER ON THE BACK OF THE ENGINE TO GET TO THE LOWER CHAIN. THIS WOULD REQUIRE REMOVAL OF THE TRANSMISSION IN THE FRONT SINCE THE CAR IS A 4MOTION AWD. AT THAT POINT I HAD TO PUT $2000 DOWN BECAUSE OF THE LABOR TO TAKE EVERYTHING APART. I'VE SEARCHED ONLINE AND FOUND MANY OTHER PEOPLE HAVE HAD THIS SAME ISSUE, DUE TO AN OIL PUMP BOLT THAT FAILS. THERE ARE LINKS TO THESE FAILURES HERE: HTTP://WWW.PASSATWORLD.COM/FORUMS/74-CLUB-B6/327507-3-6-OIL-BOLT-FAILURE-REFERENCE-MATERIAL.HTML...

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD STALL WITH THE ILLUMINATION OF THE COLUMN STEERING LOCK WARNING LIGHT. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 83,000 AND THE CURRENT MILEAGE WAS 85,000. THE VIN WAS UNAVAILABLE.

ENGINE LIGHT CAME ON WHILE DRIVING (2006 PASSAT 3.6 4MOTION) FOLLOWED BY EPC LIGHT (INDICATING E-GAS "LIMP MODE"). VEHICLE WOULDN'T DRIVE ANY FASTER THAN ~40 MPH. CAR REQUIRED OVER $3300 IN REPAIRS (EXCLUDING RENTAL), COVERED BY A CERTIFIED PRE-OWNED WARRANTY. DEALERSHIP TECHNICIAN INFORMED ME THAT THE CAUSE WAS THE OIL PUMP BOLT BACKING OUT. THIS ISSUE SEEMS TO BE WIDESPREAD AND HAS BEEN WELL DOCUMENTED WITH DOZENS OF REPORTED INCIDENTS ON VWVORTEX.COM AS WELL AS PASSATWORLD.COM. *TR

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE CONTACT STATED THE VEHICLE WAS BEING INSPECTED BY AN INDEPENDENT REPAIR SHOP WHEN HE WAS INFORMED THAT THE ENTIRE INTAKE AND MANIFOLD SYSTEM NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD NO LONGER ACCELERATE AS QUICKLY AS IT DID PRIOR TO THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 94,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATE SPEEDS OF 63-65 MPH, THE VEHICLE STALLED. ALL THE GAUGES WENT TO ZERO YET THE RADIO AND THE RADIO DISPLAY REMAINED ON. THE CONTACT MOVED THE VEHICLE OFF THE ROADWAY WHERE SHE ATTEMPTED TO REMOVE THE KEY FROM THE IGNITION. THIS TOOK SEVERAL ATTEMPTS BEFORE THE KEY DISLODGED. AFTER SEVERAL ATTEMPTS, THE VEHICLE RESTARTED. SHE STATED THIS WAS THE SECOND OCCURRENCE OF THE FAILURE. BOTH THE DEALER AND THE MANUFACTURER WERE CONTACTED AND SHE WAS AWAITING A RETURN CALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 73,300 AND CURRENT MILEAGE WAS 73,320.

THE CHECK ENGINE LIGHT CAME ON AFTER STARTING THE VEHICLE. NO ABNORMAL BEHAVIOR WAS OBSERVED BEFORE THE LIGHT CAME ON. ON SUBSEQUENT STARTS THE ENGINE SPUTTERED THEN DROVE NORMALLY (BUT THE LIGHT STAYED ON). THE DEALERSHIP DIAGNOSED THE PROBLEM AS A "FAULTY INTAKE FLAP MOTOR" WITH A QUOTED COST OF $475 TO REPLACE. PROBLEM RELATED TO SERVICE BULLETIN NUM : TSB-01-08-12, NHTSA ITEM NUMBER : 10028104. THIS SHOULD BE A RECALL AS IT IS A POLLUTION PROBLEM (CAR CANNOT PASS EMISSIONS INSPECTION). *TR

I BOUGHT MY CAR WITH 65000 MILES ON IT. OWNED IT FOR MONTH AND A HALF, THEN THE PIECE CONNECTED TO THE CATALYTIC CONVERTER, CLAMP AND GASKET BROKE. I HAD TO HAVE MY CAR TOWED AND THEY REPAIRED THIS BECAUSE OF THE FEDERAL LAW STATING IT WAS COVERED UP TO 80,000 MILES OR 8 YEARS. WHILE IT WAS AT VW BEING REPAIRED THEY CHECKED FOR ANY OTHER PROBLEMS AND INFORMED ME THAT MY HIGH PRESSURE FUEL PUMP LOBE AND FOLLOWER WERE ALSO IN NEED OF REPAIR SOON. AND BEGAN TELLING ME VW OF AMERICA HAS ADMITTED THAT THE CAMSHAFT LOBE (AND HIGH PRESSURE FUEL PUMP LOBE) WAS A MANUFACTURER DEFECT, BUT THE BULLETIN WAS ONLY ISSUED TO THE DEALERSHIP (NOT THE PUBLIC). THIS ALSO AFFECTS THE EVAP SYSTEM. I DO NOT UNDERSTAND HOW A COMPANY CAN KNOW OF A MANUFACTURER DEFECT AND NOT HAVE A RECALL ON A CAR? THE...

TL*THE CONTACT OWNS A 2006 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE STEERING COLUMN LOCKS UP ON HER VEHICLE AND PREVENTS IT FROM BEING DRIVEN. SHE ATTEMPTED TO START THE ENGINE AND AN INDICATOR ILLUMINATED, WHICH STATED THAT THE STEERING COLUMN WAS LOCKED. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE STEERING COLUMN WAS DEFECTIVE AND NEEDED A MODULE. THE REPAIR WOULD COST $1,300. THE FAILURE MILEAGE WAS 63,000. UPDATED 05/27/09 *BF UPDATED 06/08/09 *BF UPDATED 6/16/09 *NJ THE LEFT REAR CALIPER NEEDED TO BE REPLACED,THE CHECK ENGINE LIGHT ILLUMINATED, THE TRANSMISSION WAS MAKING A LOUD NOISE, THE TIRE PRESSURE LIGHT ILLUMINATED, THE LEFT TURN SIGNAL DID NOT WORK, THE LEFT WHEEL BEARING NEEDED TO BE REPLACED, THE HOOD RELEASE LEVER INSIDE THE VEHICLE WAS INOPERATIVE. UPDATED 06/17/09.*JB

I AM THE SECOND OWNER OF A 2006 VW PASSAT, WHO HAS HAD MULTIPLE ISSUES WITH THIS VEHICLE. THE LATEST BEING OF MOST CONCERN. WHEN I ATTEMPT TO START THE CAR, IT WILL EITHER NOT TURN OVER AT ALL, OR THE ENGINE TURN OVER, THEN DIE. THIS HAPPENS NEARLY EVERYTIME I AM IN THE CAR. MY VEHICLE IS 4,000 MILES OUTSIDE OF THE WARRANTY, SO NEITHERVOLKSWAGON, NOR MY LOCAL VW DEALER WILL ASSIST ME WITH THE COST (BEING AN '!@#$% AMOUNT OF $1643.00 OUT OF POCKET), NOR HAS A RECALL BEEN ISSUED. I HAVE CALLED AND EMAILED NUMEROUS INDIVIDUALS AT VW CORPORATE LEVEL, WITH NO RESULTS. IN DOING RESEARCH, I HAVE FOUND MANY FORUMS, WITH MULTIPLE POSTS OF CUSTOMERS HAVING THIS SAME ISSUE WITH THIS CAR, SPECIFICALLY THE 2006 MODEL. I HAVE ALSO WENT THROUGH THE BETTER BUSINESS BUREAU TO ATTEMPT TO GET ANSWERS ON WHY VW IS NOT DOING...

I HAVE A 2006 VOLKSWAGEN 2.0T & ON THE 18TH OF APRIL AS I CROSSED OVER A RAILROAD TRACK THE CAR EXHAUST GOT VERY LOUD. I HAD TO PULL OVER & SHUT CAR OFF. THIS HAPPENED ON A SATURDAY LATE AFTERNOON SO I HAD MY MECHANIC (NOT VOLKSWAGEN DEALER) LOOKED & FOUND THE FLANGE THAT BOLTS THE WHOLE EXHAUST TO THE MANIFOLD HAD BROKE (CLEAN BREAK ALL THE WAY AROUND ) @ THE FACTORY WELD, ALMOST LIKE IT HAD NEVER BEEN "TIG" WELDED COMPLETELY @ THE FACTORY. THIS IS SOMETHING THAT SHOULD NOT HAVE HAPPENED IN ANY CIRCUMSTANCE. *TR

EVENTS LEADING UP TO FAILURE: NONE - SUDDEN FAILURE. WAS ON INTERSTATE AT HIGHWAY SPEED. POWER SUDDENLY DROPPED AND DASHBOARD LIGHTS LIT UP. SPEED DROPPED VERY QUICKLY BUT WAS ABLE TO AVOID INCIDENT AND GO THE CAR TO THE SIDE OF THE ROAD. FAILURE: OIL PUMP DRIVE GEAR BOLT BROKEN. CAR WAS AT DEALER FOR 15 DAYS TO REPLACE OIL PUMP, TIMING CHAIN, SPROCKETS, ADJUSTER TENSIONERS. PARTS ARE NOT AVAILABLE. CAR WAS AT SECOND DEALER FOR ADDITIONAL 19 DAYS TO CORRECT PROBLEMS CREATED BY FIRST DEALER WHILE FIXING THE ENGINE. (RECEIVED APOLOGY BY PHONE FROM SERVICE MANAGER OF FIRST DEALER.) ISSUES: 1.SUDDEN LOSS OF POWER AT HIGHWAY SPEEDS COULD CAUSE AN ACCIDENT. 2.FOLLOWING INSTRUCTIONS IN MANUAL, I DROVE CAR TO NEAREST DEALER ? A DISTANCE OF 10 MILES ? WITH REDUCED OR ZERO OIL CIRCULATION. LONGEVITY OF THE ENGINE MAY BE SIGNIFICANTLY IMPACTED. 3.VW OF AMERICA DECLINED TO INSPECT THE...

MY VEHICLE HAD 19K ON IT AND FROM A COLD START SOUNDED LIKE A DIESEL. I MADE AN APPOINTMENT AT THE DEALERSHIP AND THE DAY OF THAT APPOINTMENT MY CHECK ENGINE LIGHT CAME ON. THE DEALERSHIP HAS NOW HAD MY CAR FOR 9 DAYS AND HAVE STILL NOT DIAGNOSED IT. APPARENTLY THERE IS A MAJOR DEFECT WITH CERTAIN YEAR PASSAT ENGINES. THE BOLT THAT HOLDS THE OIL PUMP IN PLACE BACKS OUT AND SHEARS OFF, THUS REQUIRING AN ENGINE REPLACEMENT. I AM VERY DISSATISFIED WITH VW SERVICE AND UNHAPPY THAT MY VEHICLE HAD SUCH A FATAL PROBLEM SO EARLY. *TR

HIGH IDLE DURING HIGH AMBIENT TEMPERATURES. IDLE IS RAISED TO 1000-1050RPMS DURING TEMPERATURES ABOVE 90F. THIS CAUSES LOADING OF THE TRANSMISSION AND ADDITIONAL BRAKE PRESSURE IS NEEDED TO KEEP THE CAR AT A STOP. THIS CAN OCCUR SUDDENLY AND RANDOMLY PRESENTING A SAFETY ISSUE. I HAVE ALMOST RAN INTO SEVERAL CARS AT VARIOUS TIMES WHEN STOPPED AT A LIGHT OR IN TRAFFIC. IT HAS HAPPENED COUNTLESS TIMES DURING THE HIGH AMBIENT TEMPERATURES. *TR

ISSUES WITH HESITATION WHEN A ROLLING STOP, AND WHEN COMPLETELY STOPPED. THERE IS A 2-3 SECOND DELAY BEFORE THE CAR RESPONDS TO THE GAS PEDAL. I HAVE ALMOST BEEN HIT 3 TIMES NOW WHEN PULLING OUT INTO TRAFFIC. THAT 2-3 DELAY IN ACCELERATION COULD CAUSE AN ACCIDENT. THIS IS AN ISSUE KNOWN TO VW, THEY SAY THEY ARE WORKIG ON A FIX. WHAT ARE THEY WAITING FOR, SOMEONE TO GET KILLED! NUMEROUS V6 OWNERS HAVE THE SAME ISSUES! ALSO SEOND ISSUE IS, WHEN I AM STOPPED IN HEAVY STOP AND GO TRAFFIC AND EXTREME HEAT MY CAR IDLES AT 1000RPMS. THIS IS CORRECTED BY ME PUTTING THE CAR IN PARK, STEPPING ON THE GAS TILL 3000 RPM AND IT WILL GO BACK TO NORMAL. IT FEELS LIKE THE CAR IN READY TO LUNGE FORWARD UNEXPECTEDLY. AGAIN WELL KNOWN ISSUE TO VW, SEVERAL INTERNET FORUMS DISCUSS THIS VW HAS DON'T NOTHING....

TL* - THE CONTACT STATED THAT WHILE DRIVING A 2006 VOLKSWAGEN PASSAT IT STALLED IN A TURN. HE HAD BEEN DRIVING ALONG STEADILY FOR 2 HOURS WITH OUT INCIDENT PRIOR TO THE VEHICLE LOSING POWER. THE CONTACT TOOK THE VEHICLE TO BE SERVICED, AND WAS INFORMED THAT THEY COULD NOT FIND THE CAUSE OF THE PROBLEM. *AK THE PASSENGER SIDE HEADLIGHT WAS INOPERABLE, THE WORK WAS COMPLETED, HOWEVER 2 HOURS LATER THE HEADLIGHT FAILED AGAIN. THE VEHICLE EXHIBITS A ONE TO THREE SECOND LAG IN THE ACCELERATOR, MOST NOTICEABLE WHEN THE CONSUMER IS TRUING TO ACCELERATOR. THERE WAS A RATTLE COMING FROM THE HEADLINER/SUNROOF ASSEMBLY. THERE WAS A RUBBING NOISE COMING FROM THE BRAKES. THERE WAS A RATTLING NOISE COMING FROM THE REAR VIEW MIRROR TRIM PIECES. THE WINDSHIELD WIPERS WERE INOPERATIVE. THE FOG LIGHTS WERE INOPERATIVE. UPDATED 01/31/07. *JB

2006 VOLKSWAGEN PASSAT DELAY IN ACCELERATION, WHILE ACCELERATOR WAS DEPRESSED. *KB THE CONSUMER WAS TOLD THERE WAS NO FIX FOR THE HESITATION. THE CONSUMER WAS TOLD THE PROBLEM WAS KNOW AS THE CALIFORNIA 5 MPH START HESITATION. THE DEALER STATED IT WAS A SOFTWARE ISSUE THAT WOULD BE CORRECTED IN THE NEAR FUTURE. *JB